Professional Documents
Culture Documents
Service Manual PWM6010M PDF
Service Manual PWM6010M PDF
Service Manual PWM6010M PDF
PWM6010M
PWM8010PM
PWM1010PM
PWM1210PM
TABLE OF CONTENES 1.SAFETY PRECAUTION
1. Safety precaution 2 Do not dismantle the machine Do not install the machine in Do not place inflammable Do not spray water directly to
2. Introduction of product 3 by yourself. damp or rainy environment to materials like burning candle, the machine.
avoid electric shock, fire, mosquito incense, cigaret etc.
2.1 Name of parts 3 machine failure,or deformation. or heating source like electric
3.Trouble shooting 4 stove, calorifier etc. on the
machine.
3.1 Malfuction and solution 4
3.11. Unusual sound when washing or wash 4
weakly (motor with sound)
Forbid dismantling Avoid dampness Avoid spraying water
3.12. Can not wash(motor does not rotate) 4 Forbid
wash tub
3.111. Water leakage from the side of spin tub 7
To avoid electric shock Do not let baby climb to the If use warm water, the water Do not wash down-filled coat,
3.2 Fault tree 8 resulting from electric leakage, machine or play near running temperature should not raincoat or similar clothes.
3.21. Can not wash (motor does not rotate) 8 please connect grounding wire
of the plug properly.
tub to avoid accident. exceed 50℃.
Forbid
4.2. Remove the control panel 11 Grounding Forbid
5.Electronic components 15
5.1. Self-test method of wash timer 15
Insert the plug tightly when Do not pull the cord when Do not insert or unplug the plug Unplug the plug from socket
5.2. Self-test method of spin timer 15 use. unplug the plug. with wet hands to avoid electric after use.
5.3. Self-test method of wash-drain selection switch 15 shock.
5.4. Self-test method of safety switch 16
5.5. Self-test method of capacitor 16
5.6. Self-test method of motor 16
6.Circuit diagram 18
7.Explored view & list of parts 19 Forbid wet hands Unplug the plug
-1- -2-
SAFETY PRECAUTION
2. INTRODUCTION OF PRODUCTS 3.TROUBLE SHOOTING
3.1 Malfuction and solution
2.1 Name of parts
Symptom Possible reason Solution
Control panel Drain hose
(For upper drain only) a. Laundry is much more than rated a. Reduce the laundry till the
washing capacity. pulsator can rotate normally.
b. pulsator is tangled with clothes or b. Take off plug, remove the
Wash cover Spin cover blocked by things like coins. pulsator and take out the
c. V-belt loose, broken or fall from tangled clothes or other things.
1. Unusual
the strap wheel. c. Replace v-belt or reload the
Lint filter Safety cover sound when
d. Pulley broken or pulley screw is v-belt.
washing or
loose . d. Replace the pulley or tight the
wash weakly
e. Capacitor failure. pulley locking screw.
Wash tub Frame (motor with
f. Wash-drain selection switch does e. Replace the capacitor.
sound)
not work. f. Replace the switch.
Pulsator
Cabinet
Power plug
Base a. Power supply is cut off or poor a. Check the power supply and
Drain hose contact of plug and socket. adjust the plug to insure good
(For lower drain only) b. Voltage is too low. contact.
c. Wash timer is in poor contact or b. Do not use the washing
faulted. machine until the voltage rise to
d. Fuse is burned. rated voltage.
2. Can not wash e. Wash motor failure. c. Check the wire harness or
* The drawing above is based on the actual washer. (motor does replace the wash timer.
not rotate) d. Replace the fuse.
e. Replace the wash motor.
-3- -4-
3.TROUBLE SHOOTING 3.TROUBLE SHOOTING
a. Spin motor winding is burned. a. If the motor is damaged a. There is things like coins, buttons a. Dismantle the pulsator and take
b. Fuse is burned. because of water leakage under the pulsator. out the things.
c. Spin timer does not work. from spin tub, check the b. The fixing screw become loose b. Tighten the fixing screw.
d. Capacitor failure. reason of leakage and solve and the pulsator vibrates. c. Replace the retarder.
e. Cable joint is loosened. the problem. c. Gear in the retarder is damaged. d. Screw tight the anti-loose nuts.
b. Replace the fuse. d. Anti-loose nuts on the big pulley e. Replace the v-belt.
c. Replace the spin timer. become loose, so the wheel f . Adjust the motor pulley to make
4. Spin tub can d. Replace the capacitor. jumps and make unusual noise. it at the same level with the big
not rotate e. Join the cable with a pair of e. The v-belt is not smooth and pulley.
plier. makes noise when running on the g. Replace the wash motor.
7.Unusual pulley.
sound when f. The motor pulley and the big
pulsator pulley is not at a level.
rotates g. Noise inside the wash motor.
-5- -6-
3.TROUBLE SHOOTING 3.TROUBLE SHOOTING
3.2 Fault tree
Symptom Possible reason Solution
1. Can not wash (motor does not rotate)
a. Safety switch contact does not a. Adjust the safety switch contact.
Can not wash
open when open the spin cover. b. Reload the brake belt or brake
b. The tightwire kit becomes loose. steel wire.
c. Brake plate is badly worn. c. Replace the brake plate. Y
d. Brake belt is too tight. d. Adjust the position of drain belt
and brake belt hanging hole to Whether the power N
Check the power supply
supply is well
keep a proper space between
9. Poor brake
the brake plate and coupler.
of spin tub
Y
-7- -8-
3.TROUBLE SHOOTING 3.TROUBLE SHOOTING
Y Y
Y Y
Y Y
Whether the capacitor N Whether the drain N Replace the drain belt
Replace the capacitor
is well belt is well
Y Y
Whether the Cable N Join the cable with a Whether the drain N Hang the drain
joint is well pair of plier belt is on the switch belt onto the switch
-9- -10-
4.DISMANTLING WAYS OF MAIN PARTS 4.DISMANTLING WAYS OF MAIN PARTS
a. Open the spin tub cover. Loosen a. Screw off fixing screws of the
the connector of the brake belt . frame.
b. Keep the spin tub cover open and b. Screw off screws under the
remove the hinge spring. handles at both sides of the
c. The spin cover can be drawn frame.
out by swinging. c. Screw off the stainless steel
screw on the top surface of
the frame.
d. The frame can be removed.
c. c. d.
-11- -12-
4.DISMANTLING WAYS OF MAIN PARTS 4.DISMANTLING WAYS OF MAIN PARTS
-13- -14-
5.ELECTRONIC COMPONENTS 5.ELECTRONIC COMPONENTS
-15- -16-
5.ELECTRONIC COMPONENTS 6.CIRCUIT DIAGRAM
-17- -18-