Professional Documents
Culture Documents
Planning and Design Hospitals Other Facilities PDF
Planning and Design Hospitals Other Facilities PDF
List of Volumes
Volume 4 – APPENDICES
First Edition
DEPARTMENT OF HEALTH
Manila
2017
MANUAL ON TECHNICAL GUIDELINES
FOR HOSPITAL PLANNING AND DESIGN
250-BED HOSPITAL
(LEVEL 3)
VOLUMES
Volume 4 – APPENDICES
First Edition
DEPARTMENT OF HEALTH
Manila
2017
MANUAL on TECHNICAL GUIDELINES for
HOSPITAL PLANNING and DESIGN
250-BED HOSPITAL
(LEVEL 3)
VOLUME 1
INTRODUCTION and INSTRUCTIONS FOR USE
First Edition
DEPARTMENT OF HEALTH
Manila
2017
VOLUME 1
INTRODUCTION and INSTRUCTIONS FOR USE
TABLE OF CONTENTS
PAGE
1.0 INTRODUCTION
1.1. Purpose of the Manual on Technical Guidelines 1
1.2. Format of the Technical Guidelines 1
1.3. Functions of the Technical Guidelines 1
1.4. Updating of the Technical Guidelines 1
1.5. Need for Technical Guidelines 2
1.6. Limitation of the Manual on Technical Guidelines 2
1
Comments and results from test-case application of the technical guidelines shall be
evaluated. The final outcome of the evaluation will determine the corresponding revisions
to be made in the guidelines. These shall be the inputs used in the updating the guidelines.
1.5 Need for Technical Guidelines
In writing about using a selection of existing techniques and tools for planning health
facilities, Dr. Montoya Aguilar of the SHA/WHO Headquarters says, “Subject to an
understandable range of nuances, people agree that rigid standards are to be excluded and
that typical plans and modules are useful, but only as references or examples of
approaches. Indeed, along with alternative reference plans designed for typical situations,
planners should also formulate guidelines on how to adapt them for more specific
circumstances. Certain technical norms are, of course, necessary and statutory. But, even
these must be revised from time to time.” Truly, there are a lot of these guidelines and
typical plans but these are however scattered and not thoroughly explained nor set in the
proper context of our environment. There is therefore a need for selecting and if possible
formulating a set of tools for health facility planning design appropriate for our milieu.
It is generally perceived that the licensing requirements set by the Health Facilities and
Services Regulatory Bureau (DOH-BHFS) is a large effort to readily meet the “norms and
standards which are necessary and statutory.” What this technical guideline manual seeks
to achieve is to address the challenge of hospital planning and go beyond what is required
by the BHFS. Because in the final analysis, each hospital project will and shall remain
novel and unique in its adaption of the socio-cultural, physical and other characteristics of
the community it seeks to serve.
1.6 Limitation of the Technical Guidelines
This Manual of Technical Guidelines is limited to a 250-Bed Hospital, Level 3
Classification only.
Typical, Redundant and Special Rooms/Spaces
In the use of these Technical Guidelines, there will be some rooms/spaces/areas shown on
the floor plans that do not have Room Data Sheets --- this is due to several reasons: 1) they
are “typical” in nature and thus can be referenced through other Room Data Sheets (i.e.
Office, Clinic, etc.); 2) they are redundant, meaning previous Room Data Sheets have
already been presented (i.e. Conference/Meeting Room, Storage Room, Pantry, etc.); or 3)
they are specialty layouts which are beyond the scope of this Manual (i.e. Auditorium,
etc.).
For all cases, it is recommended that the users of this Manual perform due diligence in
executing their work: hospital administrators to properly brief designers, and designers to
consult hospital end-users regarding the specific and unique requirements of their
rooms/spaces/areas.
Refer to the tabulation below for rooms/spaces/areas shown on the floor plans that do not
have Room Data Sheets:
2
Infection Control Office Refer to Typical Office; shown in Manual as
ADMINISTRATIVE – Office (Typical):
250B-AD-RDS-22
Legal Office
Public Health Office
4
Isolation Room May be cross-referenced with NURSING
WARDS – Isolation Room: 250B-NU-RDS-
07
Releasing Area Room/space is an open plan
Neo-Natal Intensive Care Unit (NICU)
On-Call Room May be cross-referenced with ER – On-Call
Room: 250B-ER-RDS-18
Receiving Area Room/space is an open plan
Linen and Laundry
Pantry May be cross-referenced with
ADMINISTRATIVE – Pantry: 250B-HIMS-
RDS-08
5
work period or shift. Through anthropometrics, space quantification can be done
to identify the size of work areas to be provided to support the activities of the
room occupants. This shall also help in determining the number of particular
furniture and equipment needed.
This listing varies in accordance with existing official and projected plantilla or
organizational set-up in any particular hospital.
2.1.3 Planning Relationship: indicates the areas and services that are to be located
adjacent/close to one another, and easily accessible to the room being discussed or
referred to in the manual.
2.1.4 Equipment and Accessory Checklist: indicates any of the following: tools,
implements, apparatus, appliances, devices, accessories, attachments, and gadgets.
2.1.5 Furniture and Fixture Checklist: indicates either movable or non-movable
articles and fixtures found in a room that may or may not significantly occupy floor
areas.
2.1.6 Additional Equipment and Engineering Terminals: indicates other accessories
and fixtures that do not necessarily occupy a particular floor area within the room
but must be recognized for their functional importance. These fixtures are usually
wall- or ceiling-mounted.
2.2 Room Data Sheet B: TECHNICAL DESIGN DATA
This pertains to the essential technical data that must be considered in establishing and
maintaining quality and the ideal environment for any hospital in relation to the following
four (4) conditions:
2.2.1 Air
2.2.1.1 Outdoor Air Temperature (deg. C) – the average prevailing atmosphere
temperature of a locality in degrees Centigrade. As the outdoor
temperature increases, the desirable room temperature in an air-
conditioned space increases.
Temperature Ranges:
Cold - below 10 deg. C
Cool - 10 deg. C to 15 deg. C
Temperate - 15 deg. C to 27 deg. C
Hot - 27 deg. C to 38 deg. C
Very Hot - above 38 deg. C
2.2.1.2 Room Temperature (deg. C) – the ideal temperature of an air-
conditioned space for employees or hospital staff to work with ease or for
a patient to be comfortable. This is sometimes referred to as the effective
temperature. Effective temperature is an empirically determined index
which combines into a single value the effect of temperature, humidity,
and air movement on the sensation of warmth or coolness felt by the
human body. The numerical value is that of the temperature of still
6
saturated air which could induce an identical sensation. The wide range of
effective temperature is indicated in graphical representation of comfort
zone.
2.2.1.3 Mechanical Ventilation – the process of supplying air or removing air by
mechanical means for or from any space. Such air may or may not have
been conditioned. To minimize odors and to maintain freshness of the air,
a quantity of outdoor air should be required to control body odors. Odors
satisfactorily decreases as the volume space per occupant increase.
2.2.1.3.1 Volume (cu.m./hr.-person) – the quantity of outside air
ventilation requirement in cubic meter per hour per person
2.2.1.3.2 Velocity (m./min.) – the speed of outside air ventilation
requirement in meter per minute
2.2.1.4 Pressure Differential – in all infectious rooms, bacteriology laboratory
and rooms using toxic chemicals, the following are required:
2.2.1.4.1 Negative Pressure (Pa) – amount of pressure required for an
exhaust fan to force the contaminated air out of the room
2.2.1.4.2 Positive Pressure (Pa) – amount of pressure required for an
equivalent inlet fan to normalize the room air pressure
2.2.1.5 % Dust Filtration – the quality of indoor air should be clean and dust
free. Dust and other heavily contaminated tiny particles of pollutants
should be removed from the air to prevent respiratory ailments and other
diseases.
2.2.1.6 Humidity (% RH) – unless otherwise stated will mean the relative
humidity in percent (%RH). This is the ratio of the actual (measured)
partial pressure of the water vapour in the air mixture to its saturation
pressure at the same dry bulb temperature. This is also the ratio of the
actual weight of moisture per cubic meter of mixture to the weight of the
saturated water vapour per cubic meter of mixture at the same dry bulb
temperature.
Relative Humidity Ranges (%RH)
Very Dry - 0-25%
Dry - 25-50%
Humid - 50-75%
Very Humid - 75-100%
2.2.1.7 Cooling Load (TR) – the total calculated heat and moisture of a room in
Tons of Refrigeration (TR) equivalent to 12,660 KJ/Hr.
The following are the major sources of cooling load:
a. Product load in cooling and maintaining low temperature of a product;
b. Solar transmission through walls, ceilings, floors, doors, ducts, and pipes --- a
process of conduction;
7
c. Radiation and conduction through windows;
d. Occupants - sensible heat given-off by people;
e. Electrical equipment - heat from lights, motors, and other appliances;
f. Infiltration - exchange of conditioned air with outdoor air through door
openings and cracks;
g. Ventilation - the controlled replacement of conditioned air with outdoor air;
and
h. Latent load - condensation by the air-conditioner or moisture from such
sources as people, cooking appliances, and outdoor air.
2.2.2 Sound
2.2.2.1 Acceptable Sound Level (db) – the level that must be observed in a
particular area to achieve the acoustical requirements in order that the
activities involved may proceed unhampered.
The following tables provide information on the acceptable sound level
(db) for a particular area:
2.2.2.1.1 Table I – Recommended Category Classification for
Background Noise Levels
Acceptable
Acoustical Equivalent
Type of Space
Requirements
Noise Level
Range in
decibels (db)
Intensive care areas, Quiet surrounding 20 - 30
recovery areas must be maintained
For listening to faint
musical sound
Large meeting and For good listening 35 - 40
conference rooms,
executive offices and
conference rooms for
50 people
Bedrooms, sleeping For sleeping, resting, 35 – 45
quarters and relaxing
Private and semi- For good listening 40 – 45
private offices, small conditions
conference rooms,
classrooms, libraries
Lounging areas and For conversing or 45 – 55
similar spaces listening to radio or
TV
Large office, reception For moderately good 45 – 60
areas, waiting areas, listening conditions
dining areas, cafeterias
Lobbies, laboratory For fair listening 50 – 55
work spaces, general conditions
secretarial areas
Light maintenance For moderately fair 55 – 70
shops, offices, and listening conditions
computer equipment
8
rooms, kitchen and
laundry areas
Shops, garages, power For acceptable speech 70 – 110
plant control rooms and telephone
communications
Sound
Subjective
Type of Sound Level
Impression
(db)
Siren at 30,480mm Deafening, threshold 120
of pain
Wood working shop, Threshold of 110
accelerating discomfort
motorcycle
Loud street noise Very loud 90
Power lawn mower
Car/truck unmuffled
Kitchen blender
Noisy office Loud, intolerable 80
Average street noise For phone use 70
Quiet typewriter
Average radio
Average office Usual background 60
Normal conversation
General office
Quiet radio
Quiet street
Private office Noticeably quiet 40
Quiet bedroom 30
Quiet conversation
Whisper Very quiet 20
Human breathing 10
Complete silence Intolerably quiet 0
threshold of audibility
Average Ambient
Area
Noise Level (db)
Television or radio station, church, 20-34
synagogue
Office, residence, night school 26-30
Library, reception or reading 31-36
room, school study hall
Noisy office, doctor’s or dentist’s 37-42
office, classroom
Store and factory 43-49
2.2.2.2 Speech Privacy – levels that indicate extent of acoustical limits and
identify areas where application of acoustical provisions is necessary
9
2.2.2.3 Quality Which Cannot be Tolerated – the presence of noise
characterized as tonal impacts which are incompatible with the required
acceptable sound/noise level and may also hinder achieving and
performing the desired activities involved in a particular area
2.2.3 Lighting and Visual
2.2.3.1 General Illumination (lux) – is a method of illumination that provides an
approximately uniform level of illumination on the work plane over the
entire area. The luminaries are usually arranged in a symmetrical plan
fitted into the physical characteristics of the area and blend well with the
room architecture. They are relatively simple to install and does not
require coordination with furniture or machinery that may not be in place
at the time of the installation. Perhaps the greatest advantage of using this
system of illumination is that it permits complete flexibility in task
location.
In this system of illumination, lighting units are supported fairly close to
the ceiling or at least at a considerable distance above the working plane.
They are spaced uniformly throughout the area without special regard to
the location of equipment, machinery, furniture, etc., and at such a distance
from one another as to give nearly uniform illumination.
2.2.3.2 Night Illumination (lux) – reduced lighting levels for period of low or
minimal activity usually observed during night time
2.2.3.3 Task Illumination (lux) – provides lighting only over a relatively small
area occupied by the task and its immediate surrounding. The illumination
may be from lamps mounted near the task or from remote spotlights. This
system is also called local lighting. It is an economical means of providing
higher illumination levels over a small area, and it usually permits some
adjustment of the lighting to suit the requirements of the individual.
Improper adjustment may, however, cause annoying glare for nearby
workers. Local lighting by itself, is seldom desirable. To prevent excessive
changes in adaptation, it should be used in conjunction with general
lighting or illumination that is at least 20% of the local lighting level; it
then becomes supplementary lighting.
2.2.3.4 Color Rendering – is a general expression for the effect of a light source
on the color appearance of objects in conscious or subconscious
comparison with their color appearance under a reference light source. For
example, a case of the fish looking red or fresh under pink light. It is
defined as the degree to which perceived colors of objects as illuminated
by a test source conform to the colors of the same objects as illuminated
by a standard source. The standard is always daylight as that color
temperature. Therefore, the color rendering index of a light is really a
measure of how closely it approximates daylight of the same color
temperature.
10
2.2.3.5 Standby Light – the installed reserve lighting equipment in excess of that
required which is a reliable support or source to carry peak load
2.2.3.6 Emergency Light – lighting designed to supply illumination essential to
the safety of life and property in the event of failure of the normal supply.
It is required when the normal source is interrupted for any of the
following reasons:
a. Interruption of current flow through operation of a circuit disconnect.
For example, inadvertent de-energizing of a circuit at a panel or
switchboard;
b. Failure of the building’s electrical system; or
c. General power failure.
2.2.3.7 Daylight – the cheapest (insofar as energy is concerned), most abundant
and in many ways, most desirable form of lighting available. The presence
of daylight in interior spaces is made possible by windows and other
similar openings. When daylight enters through windows (side lighting, as
opposed to top lighting), its horizontal directivity provides good modelling
shadows, minimal veiling reflections and excellent vertical surface
illumination. Further, the continual variation of daylight, which is one of
its prominent characteristics, provides a constantly changing pattern of
space illumination; that is unattainable with artificial light. Since these
changes are gradual, the eyes adapt easily and the effect is one of visual
restfulness and interest.
On the other hand, no ill effects have conclusively been demonstrated to
have been caused by lack of daylight; that is by working in an artificially
lighted space. An artificial lighting system must be installed in any event,
to furnish interior illumination during periods when daylight is
insufficient.
Since daylight is variable, it creates special problems of glare control,
direct sunlight control and heat gain limitation in large measure. The
science and art of daylighting is not so much how to provide daylight but
how to do so without the attendant undesirable effects. It is thus imperative
to adopt the technique of permanent supplementary artificial lighting in
interiors. This design approach/technique views artificial lighting as
supplementary to daylight and not vice versa. For structures that are
extracted to be in use at night, artificial lighting must be designed to
furnish all of the required lighting.
2.2.3.8 View Out – the provision of openings, like windows, in interior spaces
that will create visual contact with the outside and the resultant effect
providing a bright, pleasant and airy ambiance to the room
2.2.3.9 Privacy – as opposed to being public, not exposed; not open; seclusion;
isolation; separateness
11
2.2.3.10 Black Out – deliberated exclusion of unwanted light necessary in the
performance of specific activities involving special procedures that may
require special low level lighting or the complete absence of some specific
type of lighting
2.2.4 Safety
2.2.4.1 Accessible Hot Surface – identifies heat generating equipment whose
surfaces may reach temperatures of dangerous levels that users may
possibly come in contact with
2.2.4.2 Accessible Hot Water – identifies the sources and location of accessible
hot water with its allowable maximum temperature for safe use
2.2.4.3 Access Limit – identifies the authorized room or facility users in order to
identify the proper security measures to be adopted
2.2.4.4 Fire Risk – identifies the level (quantity and quality) of fire hazards
present in the space being discussed in order that proper fire prevention
measures may be applied
2.2.4.5 Other Risks – identifies other health hazards that may be present in the
room other than what it previously listed that may pose as some danger to
room users
2.3 Room Data Sheet C: TECHNICAL DESIGN DATA ON DIRECT SERVICES AND
DEMANDS ON FLOOR AND WALL and LAYOUT OF ROOM AND SPACE
COMPONENTS
2.3.1 Direct Services – this refers to the required basic utilities and other convenient
necessities that must be provided in a specific area
2.3.1.1 Disposal – identifies the type of waste generated in an area, treatment of
which must conform with the approved operational programs for solid
waste management as established by the Department of Health (DOH)
2.3.1.2 Hot Water – identifies fixture source and location of this particular utility
2.3.1.3 Cold Water – identifies fixture source and location of this particular
utility
2.3.1.4 Drainage – identifies fixtures and areas to be provided with this utility.
Treatment of sewage material must also conform with the approved
operational programs for liquid waste management as established by the
Department of Health (DOH)
2.3.1.5 Gas – identifies areas to be provided with this utility (may either refer to
medical or non-medical); the types of which, whether supplied in portable
cylinders or through wall outlets, must be determined according to the
capacity to supply and to safely maintain such as system
2.3.1.6 Compressed Air – see 2.3.1.5
12
2.3.1.7 Steam – identifies location where required
2.3.1.8 Others – indicates other necessary utilities not previously listed
2.3.2 Direct Demands on Floor and Wall – the extent of usage and other factors, such
as the activities involved, affecting the performance of materials to be used as
finishing for floors and walls
2.3.2.1 Loading – type of loads, whether light moving loads or heavy stationary
loads that will be taken into consideration so that ample structural support
can be provided
2.3.2.2 Spillage – the type and frequency of accidental or unintentional falling or
throwing of items and materials in the area, that the floor and finishing
materials must conform with
2.3.2.3 Foot Traffic – the expected maximum level of the traffic that can be
observed in a particular area that the floor finishing materials must be able
to support. The finishing material must be durable enough to withstand the
movement with the least need for maintenance and upkeep
2.3.2.4 Wheel Traffic – see 2.3.2.3
2.3.2.5 Impact – the force or collision where either floor or wall is subjected to
when equipment or other bulky items are being moved or transported
2.3.2.6 Abrasion – scraping or wearing away by friction in either floor or wall
brought about by foot and wheel traffic and the movement and
transportation of equipment and other load-bearing items
2.3.2.7 Easy Maintenance – where the practice and observance of cleanliness or
sanitation can be carried out with a minimum involvement of work and
effort
2.3.2.8 Vibration Free – maintaining the constant absence of quivering or
trembling disturbances both physical and auditory, that may originate from
machines, equipment, and other obvious sources. The absence of these
disturbances may be necessary to maintain a safe and secure room
atmosphere
2.3.2.9 Door Sets – identifies the type of door, its size and material finish, so that
equipment and other listed items may be provided easy access, smooth
transfer and movement from one area to another
2.3.2.10Windows – determine the type, size, and material finish of the windows
in order to meet the quality of the interior atmosphere that must be
maintained in a room
2.3.2.11Internal Glazing – identifies the type of glass finishes to be used, whether
clear, opaque, etc.
13
2.3.3 Layout of Room and Space Components – indicative rooms plans showing the
space components, dimensions, and the required equipment and furnishings to be
installed in the room
2.3.4 Space Demands – the quantity or the number of each space component and its
standard minimum area requirement that shall comprise the total minimum area
requirements of the room (To be filled out by the Designer, in most cases; since
this is based on End-Users’ specific needs; in addition to licensing and minimum
requirements)
2.3.5 Regulations and Notes – special rules, regulations, and directives that must be
applied during the design process to improve and standardize the hospital design
and plan (To be filled out by the Designer, in most cases; for local laws and
ordinances in addition to national rules and regulations)
14
MANUAL on TECHNICAL GUIDELINES for
HOSPITAL PLANNING and DESIGN
250-BED HOSPITAL
(LEVEL 3)
VOLUME 2
STANDARD PLANS and TECHNICAL
REQUIREMENTS of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
VOLUME 2
STANDARD PLANS and TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
TABLE OF CONTENTS
PAGE
2.A 250-BED HOSPITAL (LEVEL 3)
FOUR-STOREY MODEL
17
MORGUE
HEALTH ENGINEERING
INFORMATION MAINTENANCE
MANAGEMENT PROPERTY SUPPLY LAUNDRY & SECURITY
SYSTEM & MANAGEMENT LINEN HOUSEKEEPING
DIETETICS
250-BED
HOSPITAL
CENTRAL
WASTE
STORAGE
250-BED HOSPITAL
SITE DEVELOPMENT PLAN
SCALE 1:1200M
19
20
MORGUE
SERVICE
YARD
LAUNDRY
& LINEN
UP UP UP
RAMP
UP
UP
UP UP
LABORATORY DEPARTMENT
IMAGING DEPARTMENT
UP UP UP UP
UP
PHYSICAL
REHABILITATION UP
RAMP UP UP UP
HOSPITAL DEPARTMENT
LOBBY
OPD HEMODIALYSIS
OPEN
TB DOTS COURT OPEN
RAMP RAMP RAMP RAMP COURT
UP UP UP UP
CLINIC
CENTRAL WASTE
STORAGE
UP UP UP UP
RAMP
UP
250-BED HOSPITAL
GROUND FLOOR PLAN
SCALE 1:1000M
HEALTH
INFORMATION
DN UP DN UP UP DN
MANAGEMENT
SYSTEMS SURGERY WARD OBSTETRICS WARD
SOLARIUM
DN
RAMP
UP
RAMP
DN
UP DN
DN UP DN
CENTRAL
STERILE
SICU PICU SUPPLY
BURN UNIT
DN
ROOM
DN DN DN DN
MICU
OPEN
DN
BELOW
RAMP
DN
OPEN NICU
OPEN OPEN OPEN
BELOW BELOW
BELOW BELOW
AUDITORIUM
DN DN
RAMP DN
OPEN
BELOW
OPEN OPEN
BELOW BELOW
DN DN DN DN
250-BED HOSPITAL
21
SECOND FLOOR PLAN
SCALE 1:1000M
22
DN UP DN UP UP DN
RAMP
UP
RAMP
DN
UP DN
250-BED HOSPITAL
THIRD FLOOR PLAN
SCALE 1:1000M
DN DN DN
RAMP
DN
DN
250-BED HOSPITAL
FOURTH FLOOR PLAN
SCALE 1:1000M
MORGUE
UNASSIGNED
ENGINEERING,
MAINTENANCE,
TOILETS UP UP UP
HOUSEKEEPING &
DIETETICS PROPERTY SUPPLY and LINEN & LAUNDRY
DINING HALL SECURITY
DEPARTMENT MANAGEMENT OFFICE DEPARTMENT
HEALTH WATER
INFORMATION POWER
PUMP
MANAGEMENT HOUSE
ROOM
SYSTEMS
RAMP E
UP
EE
ELEVATOR ROOM
LOBBY
E
UP
TOILETS
UP UP
IMAGING DEPARTMENT
UP UP UP UP
UP
TOILETS
EE ROOM
UP
DRUG
CANTEEN GARDEN
E TESTING
EE ELEVATOR
ROOM LOBBY OPEN
OPEN E
COURT MRI RAMP
GARDEN COURT
UP PRAYER
BLOOD
STATION ROOM
PHYSICAL TOILETS GARDEN
REHABILITATION
DEPARTMENT
E
EMERGENCY
UP
RAMP UP
TOILETS MAIN UP
DEPARTMENT
OPD ADMINISTRATIVE HOSPITAL
PHARMACY EMERGENCY
UP
OFFICES LOBBY UP
TB DOTS
CLINIC OPD HEMODIALYSIS OPEN
OPEN COURT
RAMP RAMP RAMP RAMP
UP UP UP UP
COURT
OPD MAIN HOSPITAL EMERGENCY
ENTRANCE ENTRANCE ENTRANCE
CENTRAL WASTE
STORAGE TOILETS
UP UP UP UP
RAMP
UP
250-BED HOSPITAL
23
GROUND FLOOR ZONAL PLAN
SCALE 1:1000M
24
HEALTH
DN UP DN UP UP DN
INFORMATION
MANAGEMENT
SYSTEM SURGERY WARD OB-GYNE WARD
RAMP E
UP
EE
ELEVATOR ROOM
LOBBY
RAMP E
DN
UP DN
DN UP
CENTRAL DN
DN DN
MEDICAL ICU UNIT ROOM DN DN
ICU NICU
O P E N
DN B E L O W
O P E N
E B E L O W
ELEVATOR RAMP
EE DN
O P E N LOBBY
ROOM
B E L O W O P E N O P E N
E
B E L O W B E L O W
OPD CLINICS OPD CLINICS EXECUTIVE
AUDITORIUM
OFFICES
R O O F
DN
G A R D E N DN
RAMP DN
O P E N
B E L O W
AMBULATORY O P E N
OPD CLINICS OFFICES B E L O W OFFICES
SURGERY
DN
DN DN DN
250-BED HOSPITAL
SECOND FLOOR ZONAL PLAN
SCALE 1:1000M
DN UP DN UP UP DN
RAMP E
UP
EE
ELEVATOR ROOM
LOBBY
RAMP E
DN
UP DN
250-BED HOSPITAL
THIRD FLOOR ZONAL PLAN
SCALE 1:1000M
DN DN DN
E
EE
ELEVATOR ROOM
LOBBY
RAMP E
DN
DN
250-BED HOSPITAL
25
FOURTH FLOOR ZONAL PLAN
SCALE 1:1000M
26
250-BED HOSPITAL
AERIAL PERSPECTIVE
250-BED HOSPITAL
MAIN ENTRANCE
PERSPECTIVE
250-BED HOSPITAL
SITE ENTRANCE
PERSPECTIVE
27
MANUAL on TECHNICAL GUIDELINES for
HOSPITAL PLANNING and DESIGN
250-BED HOSPITAL
(LEVEL 3)
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
VOLUME 3
DEPARTMENTAL PLANS and TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
TABLE OF CONTENTS
PAGE
3.1 ADMINISTRATIVE SERVICE FACILITIES 33
3.2 EMERGENCY SERVICE FACILITIES 131
3.3 OUTPATIENT SERVICE FACILITIES 195
3.3.1 OUTPATIENT CLINICS 199
3.3.2 AMBULATORY SURGERY CLINIC 249
3.3.3 PHYSICAL REHABILITATION 279
3.3.4 DIALYSIS 292
3.4 ANCILLARY SERVICE FACILITIES 315
3.4.1 PHARMACY 319
3.4.2 LABORATORY 344
3.4.3 BLOOD STATION 396
3.4.4 RADIOLOGY 418
3.5 NURSING SERVICE FACILITIES 473
3.6 BURN UNIT SERVICE FACILITIES 499
3.7 OPERATING ROOM & ICU SERVICE FACILITIES 513
3.7.1 OR & ICU 516
3.7.2 CSSR 590
3.8 DELIVERY and NICU SERVICE FACILITIES 603
3.9 NUTRITION and DIETETICS SERVICE FACILITIES 675
3.10 ENGINEERING, MAINTENANCE and
HOUSEKEEPING FACILITIES
731
31
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
33
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE 250B-AD-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
ADMINISTRATIVE 1,086.00
ADMINISTRATIVE (FRONTLINE) 422.00 250B-AD-DDS-01A 37
Main Lobby 180.00 250B-AD-RDS-01 38
Info/ Reception & Communication Area 19.00 250B-AD-RDS-02 41
Admitting Office 27.00 250B-AD-RDS-03 44
Billing & Claims Office 36.00 250B-AD-RDS-04 47
Cashier's Office 36.00 250B-AD-RDS-05 50
Medical Social Work Office 43.00 250B-AD-RDS-06 53
Public/ PWD Toilets 45.00 250B-AD-RDS-07 56
Staff Toilets 36.00 250B-AD-RDS-08 59
35
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE 250B-AD-SFSI-02
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
HEALTH INFORMATION MANAGEMENT 785.00 250B-HIMS-DDS-01 105
MANAGEMENT SYSTEMS
Waiting Area 90.00 250B-HIMS-RDS-01 106
Staff Office and Releasing/Receiving 54.00 250B-HIMS-RDS-02 109
Completion Room 27.00 250B-HIMS-RDS-03 112
Head's Office 11.00 250B-HIMS-RDS-04 115
Admin Records 45.00 250B-HIMS-RDS-05 118
Records Room 36.00 250B-HIMS-RDS-06 121
Files Storage Area 486.00 250B-HIMS-RDS-07 124
Staff Pantry, Lockers and Toilets 36.00 250B-HIMS-RDS-08 127
36
SCALE 1:300 M
15000
TO ER
12000
12000
MAIN
LOBBY
MAIN
ENTRANCE
3000
MALE PABX
INFORMATION
STAFF T ROOM
ADMITTING
3000
9000
MALE OFFICE
PHILHEALTH
STAFF
OFFICE
36000
LOCKERS
FEMALE
STAFF
6000
LOCKERS
BILLING &
WAITING
CLAIMS
AREA
FEMALE
24000
STAFF T
CASHIER WAITING
6000
AREA
15000
FEMALE T
6000
JAN PWD
CLO T
MEDICAL
SOCIAL
MALE T
SERVICE
TO
OPD
37
Hospital: Department of Health
People Involved:
Patients, Relatives and Visitors
Planning Relationships:
a. Within the frontline service building
38
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE MAIN LOBBY 250B-AD-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
39
15000
4 2 3 2 5
3 3
1
SD SD 2
12000
2
SD SD
DT
40
Hospital: Department of Health
41
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-02B
INFORMATION/ RECEPTION &
April 2016 ADMINISTRATIVE COMMUNICATIONS ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
42
2100 4000
2
9 CH 9 DT CH
7
4 5
4 4
CH
3000
SD SD
5 4
D
8 6 1 T
4 3
8 CH
43
Hospital: Department of Health
44
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE ADMITTING OFFICE 250B-AD-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
45
3000
7 8
9 7
7000
SD
6 6
9000
6 6
T T
1 D 1 D
5 5
8 4 4 4
4
2000
SD
2 5 3
6 6 TD 8
46
Hospital: Department of Health
47
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE BILLING AND CLAIMS 250B-AD-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
48
6000
4 D 4 D 4 DT
6 3 6 3 6 3
9
CH
9 9
8
6000
SD 1 10
6 3 6 3 6 3
D D DT
4 4 4
8
5
CH
5
9
6 2
DT 5 5 5
9 4 7 7
49
Hospital: Department of Health
50
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE CASHIER'S OFFICE 250B-AD-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
51
6000
2900 3100
3 3 4
D 10 DT D
8 2 8 2 9
CH
3900
9 1
SD CH
6000
8 2 8 2 9
3 D 10 3 D CH
2100
6 SD
7 10 5 5 10
52
Hospital: Department of Health
People Involved:
1 x Head Medical Social Worker
5 x Clerks
Patient, family and significant others
Medical team
NGO's, GO's, other stakeholders
ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
Planning Relationships: ENGINEERING TERMINALS
a. Close to Admitting Office Window curtain rail 5
b. Accessible to Emergency Room and Outpatient Dept. Outlet, 10A, 2P, 240V, duplex 12 grounding type
c. Accessible to the Office of the Administrative Officer universal
d. Close to Business and Finance Office Outlet, 10A, 2P, 240V, single 3 emergency light
Outlet, DATA 6 wall-mounted
Outlet, Telephone 6 desktop
Smoke Detector 4
53
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
MEDICAL SOCIAL
April 2016 ADMINISTRATIVE WORK OFFICE 250B-AD-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
54
3000
4 4
DT
2000
3 6
1 SD
7 2
3
2000
1 DT
4
SD 3
2000
1 D
T
4
3
2000
1 D
15000
T
4
3
2000
1 D
T
SD 4
3
2000
1 D
T
4
3000
SD
5
7 5
55
Hospital: Department of Health
56
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE PUBLIC/ PWD TOILETS 250B-AD-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
57
6000 3000
3
1
3000
7 6 3
2200
5 4
3000
2
3
58
Hospital: Department of Health
59
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE STAFF TOILETS 250B-AD-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
60
3000
3000
1
3
3000
4 SD
12000
3
3
5
3000
4 SD
3 2
3000
KEY SCALE 1:150 M
61
SCALE 1:300 M
45000
6000
CHIEF NURSE PANTRY NURSING SERVICES
OFFICE OFFICE
FEMALE MALE
PUBLIC PUBLIC
TOILET TOILET
3000
A U D I T O R I U M
6000
INFECTION LOUNGE
PROCUREMENT LIBRARY
ELECTRICAL CONTROL
DEPT. / COA
ROOM BAC OFFICE OFFICE
ROOF
O P E N B E L O W O P E N B E L O W
GARDEN
6000
INT. HOSPITAL CHIEF OF PUBLIC
CONFERENCE HRD HEAD'S HRD STAFF
LEGAL OPERATIONS & MGT. SECRETARY PANTRY HOSPITAL PANTRY HEALTH FEMALE MALE
ROOM OFFICE OFFICE
OFFICE PROGRAM OFFICE STAFF STAFF
TOILET TOILET
3000
PANTRY
6000
CHIEF OF
BUDGET & FINANCE AO CPMT
BUDGET & OPET SEC CLINICS
ACCOUNTING MANAGER'S OFFICE OFFICE
ACCOUNTING DEPARTMENT OFFICE
HEADS' OFFICE OFFICE
5502 4100 3500 1900 3000 3000 1900 5100 4000 3000 4000
45000
62
Hospital: Department of Health
63
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-09B
BUDGET AND ACCOUNTING/
April 2016 ADMINISTRATIVE FINANCE MANAGER'S OFFICE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
64
18000
5500 4100 3500 1900 3000
7 14 7 7 11 14 4 D T 10 10 T D
D DT D 5 6 CH
3 9
9 3 9 3 9 3 SD 8 14
2
13 13 SD 7
14 1
7
7 12 7 7 7
6000
7 SD
14 7 SD SD
10
7 7 13 10
2 DT
SD
13
9 3 9 3 9 3 9 3 9 3
9 8 2 8
7 4
D DT D D D D 14 4 D T 10
7 14 7 7 7 14 7 3 7 14
65
Hospital: Department of Health
66
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
OFFICE OF THE CHIEF OF
April 2016 ADMINISTRATIVE HOSPITAL 250B-AD-RDS-10B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
67
11000
3000 2000 6000
13 7 7 2 16
D T
2100
13 1 5
16 SD
13
4 12
13 7 7
6
T
9
D 3 15 14
6000
CH
2200
7 SD SD 11
8 SD 16 11
7
11 10
11
11
1700
9 8 9
68
Hospital: Department of Health
69
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE IHOMP 250B-AD-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
70
6000
7 2 2 5
3 1 3 1
7
2
3
2
1 3
1
6000
SD
5 4
4
6 3 1
7 DT
2
71
Hospital: Department of Health
72
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE CONFERENCE ROOM 250B-AD-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
73
3600
3 3 2
4 1
5
3 3
1 1
3 FO 3
6000
SD
3 3
1 1
3 3
1
3 3
2
74
Hospital: Department of Health
75
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-13B
OFFICE OF THE
April 2016 ADMINISTRATIVE ADMINISTRATIVE OFFICER
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
76
4900
3000 1900
6 CH 11 10
12
1 9
3900
5 SD
5
T
6000
D 2 SD
4 8
3
12 7
2100
7
7
1 AO OFFICE 9 PANTRY
2 Desk, 750 x 1200mm 10 Counter, with cabinet above
3 Desk, extension, 400 x 1800mm and below
4 Chair, junior executive 11 Sink, stainless steel
5 Chair, visitor 12 Waste bin
6 Sofa, two-seater
7 Cabinet, filing, 500 x 700mm 13 TOILET
8 Cabinet, with shelves,
400 x 1200mm
77
Hospital: Department of Health
78
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-14B
OFFICE OF THE CHIEF OF
April 2016 ADMINISTRATIVE CLINICS
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
79
7000
3000 1500 2500
9 7 11 11 11
1900
8
6000
SD SD
6
4100 6 1 4
9
6 T
T 6 D
D
2 8 12
5
3 10
12
80
Hospital: Department of Health
81
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-15B
HUMAN RESOURCE
April 2016 ADMINISTRATIVE DEVELOPMENT OFFICE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
82
15000
3000 1900 10100
7 3 D 7D T 7D 7D 7D
T 15
7D 7D
2100
15 7 15
9
7 3 9 3 9 3 9 3 9 3 9 3 9
3600
4
T 8 SD
D 2 15
6000
7
10 SD SD
7 7 12
10 7
3900
1
SD
15 15
3 9
2400
3 9 3 9 SD SD
9 14
13 5 CH 6 3 D7D 7
D
11
83
Hospital: Department of Health
84
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-AD-RDS-16B
OFFICE OF THE CHIEF
April 2016 ADMINISTRATIVE NURSE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
85
15000
4100 1900 9000
7 13
DT
7 13 D
7 1111 1111 7 D 13 7 D
2100
13 7 10 2 10 2 2 10 2 10
3 7
9
T
1
6000
D 8
11 11 SD SD SD
11 11 8
3900
SD
13 10 2 10 2 2 10 2 10
12 6 CH DT D D D
4 5 7 13 7 7 13 7
86
Hospital: Department of Health
87
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE AUDITING OFFICE 250B-AD-RDS-17B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
88
6000
2300 3700
7 8 8
7
2500
D 8 SD 4 8
2
6 8 8
6000
D SD
2 7
6 7
7 1 D
3500
T
D D SD
2 2 T
6
6 6 3
3
5 5 5 5 9
89
Hospital: Department of Health
90
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE LIBRARY 250B-AD-RDS-18B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
91
8000
13 4 4 13
10
5
4 4
12
13 4 4
6000
12 SD
1 4 4
2 10 4 4
3
9 11 11 11 11
6
9 8 8 8 8
92
Hospital: Department of Health
Smoke Detector 1
93
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE STAFF LOUNGE 250B-AD-RDS-19B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
94
3000
2 1 2
6000
SD
2 2
8
7 9
4 5 CH 6
95
Hospital: Department of Health
96
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE PUBLIC TOILETS 250B-AD-RDS-20B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
97
3000 3000
2 2
6000
3
1 4
3
1 FEMALE TOILET
2 Slop sink
3 Waste bin
4 MALE TOILET
98
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE OFFICE (TYPICAL) 250B-AD-RDS-21A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Hospital office workers read, write and use Computer 3-5
telephone and/or computer in their work stations Printer 2-3
b. Performance of clerical, filing and office work ACU 1
c. Use of office equipment Telephone 1-3
d. Office worker attends to visitor/client , patient Waste bin 2 with black lining
and/or other hospital office worker/medical staff Note:
1) provide other equipment and accessories necessary to
specific office type
2) number of equipment and accessories depend on requirement
and not necessarily 1:1 ratio per staff
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Desk, 600 x 1200mm 5
Chair, swivel 5
Chair, visitor 2
Cabinet, steel, filing 2
People Involved: Note:
5 x Hospital office workers 1) provide other furniture and fixture necessary to
2 x Visitors specific office type
2) number of furniture and fixture depend on requirement
and not necessarily 1:1 ratio per staff
ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
ENGINEERING TERMINALS
Outlet, 10A,2P,240V, duplex 7 grounding type,
universal slots
Outlet, 10A,2P,240V, single 1 for emergency light
Outlet, data 7
Planning Relationships: Outlet, telephone 4
a. May be close to or adjacent to hospital area being Smoke detector 1
served Cubicle curtain rail 1
b. May be grouped with other administrative offices Note:
1) provide additional equipment and engineering terminals
necessary to specific office type
2) number of additional equipment and engineering terminals
depend on requirement and not necessarily 1:1 ratio per staff
99
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE OFFICE (TYPICAL) 250B-AD-RDS-21B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
100
3000
4
4
T
1 D
2 3
2
6000
SD
T
1 1 D
3
T 3
D
5
1 1
3 3
TD D
5
KEY
101
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE BAC OFFICE 250B-AD-RDS-22A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Procurement Department - Bids and Awards Computer 3-5
Committee (BAC) office workers read, write and use Printer 2-3
telephone and/or computer in their work stations ACU 1
b. Performance of clerical, filing and office work Telephone 1-3
c. Use of office equipment Waste bin 2 with black lining
d. Office worker attends to bidder/visitor/client Note:
and/or other hospital office worker/medical staff 1) provide other equipment and accessories as required by
BAC end-user
2) number of equipment and accessories depend on requirement
and not necessarily 1:1 ratio per staff
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Desk, 600 x 1200mm 5
Chair, swivel 5
Chair, visitor 2
Cabinet, steel, filing 2
People Involved: Note:
5 x BAC office workers 1) provide other furniture and fixture as required by
5 x Visitors BAC end-user
2) number of furniture and fixture depend on requirement
and not necessarily 1:1 ratio per staff
ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
ENGINEERING TERMINALS
Outlet, 10A,2P,240V, duplex 7 grounding type,
universal slots
Outlet, 10A,2P,240V, single 1 for emergency light
Outlet, data 7
Planning Relationships: Outlet, telephone 4
a. May be grouped with other administrative offices Smoke detector 1
Cubicle curtain rail 1
Note:
1) provide additional equipment and engineering terminals
as required by BAC end-user
2) number of additional equipment and engineering terminals
depend on requirement and not necessarily 1:1 ratio per staff
102
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 ADMINISTRATIVE BAC OFFICE 250B-AD-RDS-22B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
103
4000
5 9
8
SD
10
1
2
6
T 4
D
6000
2
3
4
D SD 3
7
2 2 2
4 4 4
TD D D
7
KEY
104
SCALE 1:300 M
15800
2300
FT MT STAFF
PANTRY
3700
LOCKERS DUMB
WAITER
JAN UP
CLO
2100
15000
WAITING AREA
4400
STAFF
ADMIN COMPLETION OFFICE
RECORDS ROOM
2500
HEAD'S RECEIVING/
OFFICE RELEASING
21000
36000
RECORDS
DUMB ROOM
WAITER
DN
15000
F I L E S
S T O R A G E A R E A
9000
105
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
WAITING AREA 250B-HIMS-RDS-01A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Visitors wait for receiving and issuance of medical/ Emergency light 1
medico-legal certificates, birth and death certificates Queuing numbering system 1
Waste bin - black or colorless 1
lining
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Chair, gang-type, waiting 3 4-seater
People Involved: 3 5-seater
Client / Visitor 3 7-seater
Planning Relationships:
a. Adjacent to Administrative Department
b. Accessible to Out Patient Department ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
c. Accessible to Receiving/Releasing Area ENGINEERING TERMINALS
Outlet, 10A,2P,240V, duplex 4 grounding type,
universal slots
Outlet, 10A,2P,240V, single 1 emergency light
Smoke detector 2
106
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
WAITING AREA 250-HIMS-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
107
6000
2 2 2
SD
1 1 1
15000
3 3 3
SD
108
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION STAFF OFFICE &
April 2016
MANAGEMENT SYSTEMS RELEASING/ RECEIVING 250B-HIMS-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. HIMS staff and other authorized users conduct Computer 1 w/ printer & scanner
medical studies, read, write, and retrieve Calculator 1
records Photocopier machine 1
b. Processing and filing of OPD, ER, and OR records Risograph machine 1
c. Transcription of birth and death certificates Emergency light 1
d. HIMS staff assemble/input inpatient charts Facsimile machine 1
and updated death registry UPS and AVR 1
e. Receiving and issuance of medical/medico- Waste bin - black or colorless 1
legal certificates, birth and death certificates lining
PA & BGM system 1
Airconditioning unit 1 window/split type
LCD optional
Electric typewriter 1
People Involved: Paper shredder 1
1 x Statistician
1 x Data Controller
2 x HIMS Clerks FURNITURE AND
QUANTITY REMARKS
Researchers / Doctors FIXTURE CHECKLIST
Desk, 600 x 1200mm 12
Chair, clerical 12
Counter, transaction 1
Cabinet, steel, filing 5
Stool, adjustable 3
109
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION STAFF OFFICE &
April 2016
MANAGEMENT SYSTEMS RELEASING/ RECEIVING
250-HIMS-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
110
6000
SD
3
FO
2
3 2 2 3
2
FO
6
FO 3
3 2 2 3
3
9000
FO
2T
SD 2
7
FO 3
3 2 2 3
FO 4
FO
3 3 CH
2 2
4
FO 1
CH
4
5 5 5 8 9 5 5
111
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
COMPLETION AREA 250B-HIMS-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Researchers / Doctors and other authorized users Computer 1 w/ printer & scanner
112
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
COMPLETION AREA 250-HIMS-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
113
4100
2 2
4
4400
2 1 2
SD
2 2
CH
3 3 DT
1 Table, conference
2 Chair, conference
3 Counter, 900mm high, with
shelves below
4 White board, 1200 x 2400mm
5 Waste bin
114
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
HEAD'S OFFICE 250B-HIMS-RDS-04A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Health Information Management (HIM) Officer reads, Computer 1 w/ printer & scanner
FURNITURE AND
QUANTITY REMARKS
People Involved: FIXTURE CHECKLIST
1 x HIMS Officer (Administrative Officer V) Desk, 750 x 1200mm 1
Researchers Desk extension, 400 x 850mm 1
Clients/Visitors Cabinet, filing, 500 x 700mm 2
Chair, junior executive 1
Chair, visitor 2
Sofa, two-seater 1
115
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
HEAD'S OFFICE 250-HIMS-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
authorized users
116
4100
8 2 T D 5
7 4
1
2500
SD
3 3 6
117
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
ADMIN RECORDS 250B-HIMS-RDS-05A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. HIMS staff stores/files administative records Calculator 1
for easy access PA & BGM system 1
b. HIMS staff retrieves records on file Exhaust fan 2
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
People Involved: Shelving, steel, open 8
HIMS staff Cabinet, with shelves 2
Researchers / Doctors Ladder, aluminum or wooden 1
118
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
ADMIN RECORDS 250-HIMS-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
119
4900
1
1
SD
1
1
13500
1
1
SD
1
1
3
2
120
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
RECORDS ROOM 250B-HIMS-RDS-06A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. HIMS staff stores/files OPD, ER, and OR/DR records, Calculator 1
birth and death certificates for easy access PA & BGM system 1
b. HIMS staff retrieves records on file for request/ Exhaust fan 2
follow-up of patients/relatives and researchers/
doctors and refiles them
c. HIMS staff records individual charts by patient's
data for complete inventory control
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
People Involved: Shelving, steel, open 4
HIMS staff Cabinet, with shelves 2
Researchers / Doctors Ladder, aluminum or wooden 1
121
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
RECORDS ROOM 250-HIMS-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
122
6000
6000
2 SD
1 1 1 1 2
123
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
FILES STORAGE AREA 250B-HIMS-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of inactive files that have passed the
ten- to thirty-year filing period PA & BGM system 1
b. Storage of files to ensure protection from fire, Exhaust fan 3
flood and theft
c. Periodic evaluation of inactive health
records/files
d. To keep medical records accessible as many
years as possible
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
People Involved: Shelving, steel, open 102
HIMS staff Ladder, aluminum or wooden 5
124
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION
April 2016
MANAGEMENT SYSTEMS
FILES STORAGE AREA 250-HIMS-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
infestation; moisture
125
27000
2 2
6000
1
1 1 SD1 1 1 1 1 SD1 1 1 1 1 SD1
1
DN
15000
2
1 1 1 1 1 1 1 1 1 1 1 1 1 1
1 1 1 1 1
SD SD SD SD
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
2 2
36000
126
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION STAFF PANTRY, LOCKERS
April 2016
MANAGEMENT SYSTEMS AND TOILETS
250B-HIMS-RDS-08A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Lounging area for HIMS staff Refrigerator 1
b. HIMS staff stores personal belongings Water dispenser 1
c. HIMS staff uses toilet facilities Waste bin 1
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Table, dining 1
Chair, dining 4
Counter, with cabinets above 1
and below
People Involved: Sink, stainless steel 1
HIMS staff Concealed floor drain 1
Locker, steel, 300 x 500 mm 7
Slop sink with faucet 1
Shelf, open 1
127
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH INFORMATION STAFF PANTRY, LOCKERS
April 2016
MANAGEMENT SYSTEMS AND TOILETS 250-HIMS-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
128
6800
9 9 8
3 3 5
2300
15 9 16
CH
2 SD
4
3 3
7
4750
1
6
6000
2100 SD
11
10
12
1600
13 SD
14
129
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
131
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 EMERGENCY 250B-ER-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
EMERGENCY 566.00 250B-ER-DDS-01 134
Waiting Area & Triage 138.00 250B-ER-RDS-01 135
Decontamination Room 19.00 250B-ER-RDS-02 138
Resuscitation Bay 41.00 250B-ER-RDS-03 141
Respiratory Unit 16.00 250B-ER-RDS-04 144
Staff Pantry/Lockers, T&B 38.00 250B-ER-RDS-05 147
Isolation Room 20.00 250B-ER-RDS-06 150
VAWC Room 23.00 250B-ER-RDS-07 153
Treatment Cubicle (PEDIA) 10.00 250B-ER-RDS-08 156
Treatment Cubicle (MEDICAL) 10.00 250B-ER-RDS-09 159
Treatment Cubicle (OB-GYNE) 10.00 250B-ER-RDS-10 162
Treatment Cubicle (SURGERY) 10.00 250B-ER-RDS-11 165
Nurse Station 21.00 250B-ER-RDS-12 168
Delivery Room 24.00 250B-ER-RDS-13 171
Scrub-Up / Sub-Sterile 9.00 250B-ER-RDS-14 174
Minor Operating Room 31.00 250B-ER-RDS-15 177
HEM Office and Supply Room 44.00 250B-ER-RDS-16 180
ER Head Office 28.00 250B-ER-RDS-17 183
Doctors' On Call Room 36.00 250B-ER-RDS-18 186
Ambulatory Care 29.00 250B-ER-RDS-19 189
Observation Bay 9.00 250B-ER-RDS-20 192
133
SCALE 1:400 M
51000
3000 2100 18900 3000 2600 2100 2100 4000 4300 5900 3000
CLEAN WASTE
4300
6000
MT ON-CALL
STO ROOM ROOM
DIRTY RM ROOM
ROOM
LINEN
UP
UP
3000
FT ROOM
OBSERVATION BAY
3000
NURSE
STATION
4500
STAFF
HEMS PANTRY
6000
AMBULATORY ER HEAD HEMS OPCEN /
CARE OFFICE OFFICE SUPPLY
3200
ELECTRICAL
DIRTY ROOM
ROOM STAFF
T JANLINEN
CLO
5000
36000
OPERATING
6000
NURSE
ROOM
OPEN COURT STATION OPEN COURT
2000
6000
5900
SURGICAL MEDICINE
3000
2100
UP
UP
UP
OB-GYNE PEDIA
6000
6000
DELIVERY ISOLATION VAWC
ROOM ROOM ROOM
EQPT
STORAGE
6000
ROOM
13900 3300 3800 3000
UP
3000
3100
5100
RESPIRATORY
UNIT
8100
RESCUSCITATION
BAY
4100
33000
SUPPLY
ROOM
TRIAGE
4100
RECORDS
ROOM
12800
WAITING
7500
AREA
DECONTAMINATION
3100
3100
ROOM
12000
134
Hospital: Department of Health
135
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY WAITING AREA & TRIAGE 250B-ER-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
136
9000
8
T D3 7 2
6 4 5
6
4 4
5300
1
SD
6 6 6
6 6
8 6 6
7500
SD 6 SD 6
6 6 6
6 6 6
9
6 6
12000
137
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY DECONTAMINATION ROOM 250B-ER-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive Exhaust fan 1
b. Patient may arrive on wheelchair/ stretcher Electric fan 1
c. Patient is decontaminated with chemical solutions Airconditioning unit 1
d. Patient undergoes screening for possible or suspected Thermometer 1
with any biological or chemical contamintion Sphygmomanometer 1
Weighing scale 1
Stethoscope 1
IV stand 1
Suction machine 1
Gooseneck lamp 1
Linen Hamper 1
People Involved: Stretcher 1
1 x Resident Physician Waste bin 1
Patient
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Water closet w/ spray hose 1
Lavatory 1
Shower 1
Cubicle curtain and rod 1
138
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
DECONTAMINATION
April 2016 EMERGENCY ROOM 250B-ER-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
139
6000
TD
3100
SD 4
2 6
1
3 5
1 Stretcher
2 DRESS CUBICLE
140
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY RESUSCITATION BAY 250B-ER-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient may arrive on foot Defibrillator 1
b. Patient may arrive on wheelchair/ stretcher E-cart w/ complete emergency 1
c. Use of diagnostic equipment medicines
ECG or cardiac monitor 1
Pulse oxymeter 1
Sphygmomanometer 1
Stethoscope 1
Thermometer, digital 1
Suction machine 1
Cardiac board 1
IV stand w/ IV fluid 1
People Involved: Laryngoscope w/ endotracheal tube 1
1 x Resident Physician Indwelling poly catheter 1
1 x Patient Bag valve mask or respirator 1
1 x Nurse Nebulizer 1
1 x Nursing Attendant Waste bin 1
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table 1
Table, instrument 1
Resuscitating apparatus 1
Counter, with cabinets below 1
Sink, stainless steel 1
Examination light 1
Medical gas console 1
Cubicle curtain and rod 1
Concealed floor drain 1
Portable X-Ray Machine 1
Planning Relationships ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
a. Close to Emergency suite entrance ENGINEERING TERMINALS
b. Adjacent to Nurse Station and Minor Operating room Outlet, 10A,2P,240V, duplex 3 grounding type,
universal slots
Outlet, 15A,2P,240V, single 1 for emergency light
Smoke detector 1
Outlet, DATA 1
Outlet, Telephone 1
Outlet, Aircon 1
Outlet for various equipment
141
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY RESUSCITATION BAY 250B-ER-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
142
5050
11 3
4
1
2750
5
7
CH
2
8 6 10 9
2700
8200
SD
CH
2750
CH
TD
143
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY RESPIRATORY UNIT 250B-ER-RDS-04A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive Waste bin w/ yellow lining 1
b. Patient may arrive on wheelchair/ stretcher Bed 1
c. Patient is triaged and brought to the Respiratory unit Stethoscope 1
d. Holding area of patient prior to admission or referral for Sphygmomanometer 1
laboratory tests Thermometer, non-medical 1
e. Collection of specimen by nasopharyngeal swab Nebulizer 1
IV stand 1
Suction machine 1
Pulse Oxymeter 1
Ventilator 1
144
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY RESPIRATORY UNIT 250B-ER-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
145
3050
7 2
TD
4
1
5
3
6
5100
SD
146
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY STAFF PANTRY/ LOCKERS, T&B 250B-ER-RDS-05A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Lounging area for Emergency Room staff Waste bin w/ black lining 2
b. Emergency Room staff stores personal belongings
c. Emergency Room staff uses toilet facilities
147
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
STAFF PANTRY/
April 2016 EMERGENCY LOCKERS, T&B 250B-ER-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
148
6200
1700 4500
1300
12 11
13 3 3
2
3900
1 SD
3 3
6000
8
9 4
4700
6 7 CH
5
GFCI
10
14
2100
SD
149
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY ISOLATION ROOM 250B-ER-RDS-06A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. ER patient is triaged and brought to Isolation Room Exhaust fan 1
b. ER attendant bathes patient Electric fan 1
c. Patient is decontaminated with chemical solutions Airconditioning unit 1
d. Patient undergoes screening for possible or suspected Thermometer 1
biological or chemical contamination Sphygmomanometer 1
e. Consultation/ examination/ treatment of patients Weighing scale 1
f. Holding area of patients prior to admission or referral Stethoscope 1
to other hospitals IV stand 1
Suction machine 1
Gooseneck lamp 1
Linen Hamper 1
People Involved: Stretcher 1
1 x Medical Doctor Waste bin w/ black lining 1
1 x Nurse Waste bin w/ yellow lining 1
Patient
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table/bed 1
Table, side, 400 x 400mm 1
Footstool 1
Cabinet, for PPE; with PPE 1
Lavatory, wall-hung 1
Hamper, for soiled linen 1
Concealed floor drain w/ 1
waterless trap
150
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY ISOLATION ROOM 250B-ER-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
151
3300
1800 1500
8
11
2500
7 SD 9 12
10
6 6
6000
TD
1
3
3500
SD
2
4
5 6
152
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY VAWC ROOM 250B-ER-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
Examination table/bed 1
VAWC - Violence Against Women & Children Speculum set 1
a. Patient arrives on foot, wheelchair, or stretcher Examination light 1
b. Social Worker/Family Physician interviews and Waste bin, w/ black or 2
records information from/about patient colorless lining
c. Family Physician examines patient and/or
refers patient to diagnostic/laboratory service
153
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY VAWC ROOM 250B-ER-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
154
3800
1500 2300
10 11
T
2500
D 9
13
7
6
8
7 6
12
6000
SD 6
6
3
3500
2 1
5 7
155
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY TREATMENT CUBICLE (PEDIA) 250B-ER-RDS-08A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive on foot Laryngoscope w/ endotracheal tube 1
b. Patient may arrive on wheelchair/ stretcher (different sizes)
c. Use of diagnostic equipment Examining light 1
d. Patient is treated for minor injuries and illness Nebulizer 1
e. Transfer of patient from examining table to stretcher Sphygmomanometer w/ pediatric 1
cuffs
trolley, to go to observation rooms or pediatric wards Weighing scale, infant 1
f. Patient is assisted by Nurse/ Nursing Attendant to Heavy-duty weighing scale 1
move out from examining table and be discharged Stethoscope 1
IV stand 1
Suction machine 1
Gooseneck lamp 1
People Involved: Waste bin w/ black lining 1
1 x Resident Physician Oxygen tank set 1
1 x Patient Bag valve mask 1
1 x Nurse Cervical collar 1
1 x Nursing Attendant
FURNITURE AND QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table/bed 1
Table, side, 400 x 400mm 1
Footstool 1
Chair, upright 1
Lavatory, wall-hung 1
Cubicle curtain and rod 1
156
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (PEDIA) 250B-ER-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
157
2350
7
4
3650
3 1
5
6 2
158
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (MEDICAL) 250B-ER-RDS-09A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive on foot Laryngoscope w/ endotracheal tube 1
b. Patient may arrive on wheelchair/ stretcher Pulse Oxymeter 1
c. Use of diagnostic equipment Examining light 1
d. Patient is treated for minor injuries and illness Nebulizer 1
e. Transfer of patient from examining table to stretcher Sphygmomanometer 1
trolley, to go to observation rooms or medical wards Weighing scale 1
f. Patient is assisted by Nurse/ Nursing Attendant to Stethoscope 1
move out from examining table and be discharged IV stand w/ IV fluid 1
Suction machine 1
ECG cardiac monitor 1
Waste bin w/ black lining 1
People Involved: Oxygen tank set 1
1 x Resident Physician Bag valve mask 1
1 x Patient Cervical collar 1
1 x Nurse E-cart w/ complete ER meds 1
1 x Nursing Attendant Thermometer, digital 1
Electric fan 1
Glucometer 1
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table/bed 1
Table, side, 400 x 400mm 1
Footstool 1
Chair, upright 1
Lavatory, wall-hung 1
Cubicle curtain and rod 1
159
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (MEDICAL) 250B-ER-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
160
2650
2 6
5
3 1
3650
4
7
161
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (OB-GYNE) 250B-ER-RDS-10A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive on foot IV stand w/ IV fluid 1
b. Patient may arrive on wheelchair/ stretcher Examining light 1
c. Use of diagnostic equipment Oxygen tank set 1
d. Patient is treated for minor injuries and illness Sphygmomanometer 1
e. Transfer of patient from examining table to stretcher Stethoscope 1
trolley, to go to observation rooms or ob-gyne wards Weighing scale 1
f. Patient is assisted by Nurse/ Nursing Attendant to Ortho Set 1
move out from examining table and be discharged Thermometer, digital 1
Suction apparatus 1
EENT diagnostic set 1
Neurological hammer 1
People Involved: Glucometer 1
1 x Resident Physician Pulse Oxymeter 1
1 x Patient Cervical collar 1
1 x Nurse Laryngoscope w/ ET tube 1
1 x Nursing Attendant E-cart w/ complete ER meds 1 set
ECG cardiac monitor 1
Bag valve mask 1
Electric fan 1
Waste bin w/ black lining 1
FURNITURE AND QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table/bed 1
Table, side, 400 x 400mm 1
Footstool 1
Chair, upright 1
Lavatory, wall-hung 1
Cubicle curtain and rod 1
Planning Relationships ADDITIONAL EQUIPMENT & QUANTITY REMARKS
a. Close to Emergency suite entrance ENGINEERING TERMINALS
b. Adjacent to Nurse Station and Minor Operating room Cubicle curtain rail 1
Outlet, 10A,2P,240V, duplex 3 grounding type,
universal slots
Outlet, 15A,2P,240V, single 1 for emergency light
Smoke detector 1 for entire area
162
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (OB-GYNE) 250B-ER-RDS-10B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
163
2350
7
4
3650
3 1
5
6 2
164
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (SURGERY) 250B-ER-RDS-11A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Ambulatory patient may arrive on foot IV stand w/ IV fluid 1
b. Patient may arrive on wheelchair/ stretcher Examining light 1
c. Use of diagnostic equipment Oxygen tank set 1
d. Patient is treated for minor injuries and illness Sphygmomanometer 1
e. Transfer of patient from examining table to stretcher Stethoscope 1
trolley, to go to observation rooms or surgery wards Weighing scale 1
f. Patient is assisted by Nurse/ Nursing Attendant to Ortho Set 1
move out from examining table and be discharged Thermometer, digital 1
g. Patient is given initial treatment and brought to the Suction apparatus 1
Minor Operating Room EENT diagnostic set 1
Neurological hammer 1
Glucometer 1
Pulse Oxymeter 1
People Involved: Cervical collar 1
1 x Resident Physician Laryngoscope w/ ET tube 1
1 x Patient Surgical set (minor) 1 set
1 x Nurse Waste bin w/ black lining 1
1 x Nursing Attendant
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Examination table/bed 1
Table, side, 400 x 400mm 1
Footstool 1
Chair, upright 1
Lavatory, wall-hung 1
Cubicle curtain and rod 1
165
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
TREATMENT CUBICLE
April 2016 EMERGENCY (SURGERY) 250B-ER-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
166
2650
2 6
5
3 1
3650
4
7
167
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY NURSE STATION 250B-ER-RDS-12A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Nurse receives patient Instrument sterilizer 1
b. Nurse makes inquiries and records necessary information Waste bin w/ yellow lining 3
from/about patients rushed to ER Cart, supply 1
c. Nurse performs other medical monitoring activities Cart, emergency 1
d. Physician aided by nurses and nursing attendants, Lockers for staff 4
monitor and perform diagnostic activities and administers Filing cabinet 1
proper treatment to patient rushed to ER Cabinet for dangerous medicines 1
Whiteboard 1
Electric fan 1
Exhaust fan 1
GENT diagnostic set 1
People Involved: Weighing scale 1
1 x Nurse Defribrillator 1
1 x Nursing Attendant Ambu bag (Adult/Pedia) 1
Suction machine 1
Puncture-proof container 1
Clock 1
Refrigerator 1
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Counter, 2-level 2
Counter, with cabinets above 1
& below
Sink, stainless steel 2
Chair, stacking, upright 1
Stool, adjustable 1
Concealed floor drain 1
Planning Relationships Shelf, open 2
a. Close to Emergency entrance Water closet w/ spray hose 1
b. Adjacent to Treatment and Minor Operating Room Lavatory 1
168
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY NURSE STATION 250B-ER-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
169
4033
1267 2767
12 10 11
4 3 6
1265
20 2
1412 1
3
3998
4 SD T
8 9 D
13
2733
SD D5 12
9 2
16
15
17
1270
18 7
2473
17
6
1203 19
2008
KEY SCALE 1:100 M
1 NURSE STATION 12 Waste bin
2 Counter, 2-level
3 Counter, with cabinets above 13 MEDICINE PREP. ROOM
and below 14 Concealed floor drain
4 Sink, stainless steel 15 Refrigerator, for medicine
5 Desk
6 Cart, supply 16 SUPPLY ROOM
7 Cart, emergency 17 Shelf, open
8 Chair, stacking, upright
9 Stool, adjustable 18 CLEAN LINEN ROOM
10 Whiteboard 19 DIRTY LINEN ROOM
11 Clock 20 STAFF TOILET
170
Hospital: Department of Health
171
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY DELIVERY ROOM 250B-ER-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
172
3900
13 6
14
T
D
11
7
5 8
7
6000
9 1 SD 2 12
3 16
15
10
4
173
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY SCRUB-UP/SUB-STERILE 250B-ER-RDS-14A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
SCRUB-UP Clock 1
a. Physician and nurses rinse arms and hands with water Soap Dispenser 1
and soap prior to and/or after surgical operation Hand Dryer 1
SUB-STERILE Small instrument sterilizer 1
a. Preparation of packed and surgical instruments from cabinets Waste bin w/ yellow lining 2
b. Storing and retrieving of instruments from cabinets Airconditioning unit 1
c. Minor sterilizing works
d. Handwashing and other clean-up activities
174
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY SCRUB-UP/SUB-STERILE 250B-ER-RDS-14B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
175
2300 1500
6 7 4
13
9
2000
SD 5
2600
8 SD
10 11 CH 12 2
1
86
3
176
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY MINOR OPERATING ROOM 250B-ER-RDS-15A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a stretcher trolley IV Stand 1
b. Patient is transferred from a stretcher trolley to Operating light 1
operating table Oxygen tank set 1
c. Clinical Handwashing Sphygmomanometer 1
d. Anesthesia is administered Stethoscope 1
e. Use of diagnostic equipment Suction apparatus 1
f. Patient is surgically operated EENT diagnostic & surgical set 1
Surgical set 1
Clock 1
Double-film Negatoscope 1
Double X-ray film illuminator 1
UV Light 1
Telephone 1
People Involved: Airconditioning Unit 1
2 x Resident Physician Anesthesia Unit 1
1 x Patient Puncture-proof container 1
1 x Nurse Waste bin w/ yellow lining 1
1 x Nursing Attendant FURNITURE AND QUANTITY REMARKS
FIXTURE CHECKLIST
Aspirator 1
Footstool 2
Instrument table 1
Double basin stand 1
Single basin stand 1
Anesthetist's stool 1
Anesthetist's table 1
Kick bucket 1
Concealed floor drain 1
Planning Relationships Shelving; adjustable, 500mm deep 1
a. Adjacent to Sub-sterilizing Room Door with vision panel 1
b. Adjacent to Scrub-Up ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
c. Close to treatment cubicles ENGINEERING TERMINALS
d. Close to Nurse station Outlet, 10A,2P,240V, duplex 9 grounding type,
universal slots
Outlet, 15A,2P,240V, single 1 for emergency light
Smoke detector 1
Outlet, Telephone 1
Outlet, DATA 1
Grounding terminal 3
177
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY MINOR OPERATING ROOM 250B-ER-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
178
6000
5
14
4 7
10
5100
2 1 9
SD
6
4 8
T
D
11 12 15 13
179
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH EMERGENCY MGMT.
April 2016 EMERGENCY OFFICE & SUPPLY RM. 250B-ER-RDS-16A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of supplies for public health emergency Personal Protective Equipment (PPE)
preparedness and response unit Gloves
b. Distribution of said supplies Gown
Goggles
Facial Guards
N95 Respirator or Surgical Mask
Waste bin 2
180
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HEALTH EMERGENCY MGMT.
April 2016 EMERGENCY OFFICE & SUPPLY RM. 250B-ER-RDS-16B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
181
3200 4000
9
10
5 8
5 1
T
D 9 9 9
2
5 4
3
6000
SD
5 SD
7
9
9 9 9
7 4
6 5
6
6
182
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY ER HEAD OFFICE 250B-ER-RDS-17A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Reads, writes, and uses telephone in his work station Waste bin w/ black lining 3
b. Receives visitors
c. Consulted by patients
d. Stores, files and retrieves records
e. Supervises/ monitors clinical activities
f. Use of toilet facilities
183
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY ER HEAD OFFICE 250B-ER-RDS-17B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
184
1700 4000
6 T 7
6
4 7
7
10
1
11
6000
6
1900
SD
6
2 T
9 9 D
8 5
3
9 9
10
185
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY DOCTORS ON CALL ROOM 250B-ER-RDS-18A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Doctor on duty reads, writes, and uses mobile Waste bin w/ black lining 1 non-bidoegradable
phone at his table Waste bin w/ green lining 1 biodegradable
b. Doctor on duty rests while awaiting emergency calls
c. Doctor on duty uses toilet facilities
d. Doctor on duty stores personal belongings
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Sofa, 2-seater 2
Desk, 600 x 1200mm 1
People Involved: Chair, swivel 1
2 x Resident Physician Cabinet, steel, filing 2
2 x Nurse Table, side, 400 x 400mm 2
2 X Nursing Attendant Table, dining, 4-seater 1
Chair, dining 4
Counter, with cabinets above 1
and below
Sink, stainless steel 1
Water dispenser 1
Refrigerator 1
Concealed floor drain 1
Closet 1
Lavatory 1
Urinal 1
Water closet 1
186
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY DOCTORS ON CALL ROOM 250B-ER-RDS-18B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
187
5900
1700 4200
11 10 CH 12 13
14
5
16 5
4300
9 8 8
7 4 3
6000
SD
8 8
9
2
1
1700
15 D
T
6 2 6
188
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY AMBULATORY CARE 250B-ER-RDS-19A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient is transferred to Ambulatory Care Examination table/bed 2
after physician declares patient fit to be Waste bin, w/ black or 2
moved from Emergency to a patient room colorless lining
b. Patient stays at Ambulatory Care until a
patient room is available
189
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY AMBULATORY CARE 250B-ER-RDS-19B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
190
3650 1700
2200
9
3000
4
1
2 6
3
5
SD
5
3
3000
7 8
4
1900
9 6
TD 6
191
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY OBSERVATION BAY 250B-ER-RDS-20A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient is transferred to ER Observation from Emergency light 1
other ER areas: either from Rescusitation Bay, Volume respirator 1
Respiratory Unit, Treatment Cubicle, VAWC Room, Pulse oximeter 1
Delivery Room, or Operating Room Nebulizer 1
b. Patient is transferred to bed and vice versa Sphygmomanometer 1
c. Nurses and nursing attendants monitor vital Stethoscope 1
signs of patient at regular intervals IV stand with IV fluid 1
Thermometer, digital 1
Electric fan 1
192
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 EMERGENCY OBSERVATION BAY 250B-ER-RDS-20B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
193
2700
3 1
3000
4
5
194
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
195
Hospital: Department of Health
250-Bed (Level 3)
SERVICE FACILITY SHEET INDEX
Hospital HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 OUTPATIENT 250B-OPD-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
OUTPATIENT 839.00 250B-OPD-DDS-01 199
Lobby & Waiting Area 297.00 250B-OPD-RDS-01 201
Registration/ Admitting Area 18.00 250B-OPD-RDS-02 204
OPD Records Room 36.00 250B-OPD-RDS-03 207
Office of the Family Medicine Chief 30.00 250B-OPD-RDS-04 210
Conference Room 43.00 250B-OPD-RDS-05 213
Consultation Room (Medicine) 18.00 250B-OPD-RDS-06 216
Consultation Room (OB-GYNE) 54.00 250B-OPD-RDS-07 219
Consultation Room (Pedia/ Under Six) 36.00 250B-OPD-RDS-08 222
Consultation Room (Surgery) 18.00 250B-OPD-RDS-09 225
Consultation Room (Dental) 55.00 250B-OPD-RDS-10 228
Consultation Room (ENT) 36.00 250B-OPD-RDS-11 231
Consultation Room (Ophtha) 36.00 250B-OPD-RDS-12 234
Consultation Room (TB-DOTS) 90.00 250B-OPD-RDS-13 237
Staff Pantry & Lounge 18.00 250B-OPD-RDS-14 240
Public Toilets 36.00 250B-OPD-RDS-15 243
Clinic (Typical) 18.00 250B-OPD-RDS-16 246
197
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 OUTPATIENT 250B-OPD-SFSI-02
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
PHYSICAL REHABILITATION 144.00 250B-PR-DDS-01 279
Waiting & Reception 20.00 250B-PR-RDS-01 280
Consult/ Exam Room 9.00 250B-PR-RDS-02 283
Treatment/ Gym Area 94.00 250B-PR-RDS-03 286
Toilets, Dress Cubicles & Soiled Linen Area 21.00 250B-PR-RDS-04 289
198
15000
SCALE 1:300 M
18000
OPD LOBBY
RAMP
WAITING AREA
UP
3000
OPD
REGISTRATION/
ADMITTING
COUNTER
PUBLIC
FEMALE
TOILET
6000
OPD
RECORDS
ROOM
PUBLIC
MALE
TOILET
UP
UP
PUBLIC
MALE
6000
OILET STAFF/
PANTRY/
LOUNGE
TB DOTS CLINIC
199
SCALE 1:300 M
51000
3000 3000 6000 9000 3000 3000 3000 3000 3000 2500 6000 3500 3000
STERILE
CLEAN INSTRUMENT,
UP SUPPLY,
STORAGE
6000
RECEPTION/
ELECTRICAL AFFILIATES' OB-GYNE RECORDS/ OR
ROOM ROOM CLINIC WAITING
AREA SUB- DRESS
WAITING STERILIZATION
SCRUB ROOM
AREA
DN
DN
DN
UP
3000
FEMALE MALE
STAFF STAFF
TOILET TOILET
DRESS
6000
FM
CONFERENCE SURGERY/
CHIEF WELLNESS WELLNESS OPHTHA OPHTHA
ROOM MEDICINE
OFFICE
FEMALE MALE
PEDIA DENTAL STAFF STAFF
TOILET TOILET
3000
FEMALE MALE
DN
DN
PUBLIC PUBLIC
TOILET TOILET
6000
3000 3000 6000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000
200
Hospital: Department of Health
201
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT LOBBY & WAITING AREA 250B-OPD-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
202
15000
3 3 3
2 2
2 2 2 2 2
SD SD
2 2
2 2 2 2 2
18000
SD
3
2 2 2 2 2 SD
2 2 2
2 SD 2
2 2
2 2
2 2
3 2 SD 2
1
2 2
3000
2 2
3
9000
1 Counter, 2-level
2 Chair, gang
3 Waste bin
203
Hospital: Department of Health
204
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
ADMITTING/
April 2016 OUTPATIENT REGISTRATION COUNTER 250B-OPD-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
205
6000
1
T
D
3 3 3
3000
SD
4 2
206
Hospital: Department of Health
207
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT RECORDS ROOM 250B-OPD-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
208
6000
1 1
6000
1 1 2
1 1
209
Hospital: Department of Health
210
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT OFFICE OF THE FM CHIEF 250B-OPD-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
211
4300 1700
9 CH 8
12 11
4
4 2
5
4
1 T
6000
SD D
6
3
6
11
1900
10 7 10
212
Hospital: Department of Health
213
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT CONFERENCE ROOM 250B-OPD-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
214
1700 6000
4 7 6
CH 3 3
6
1
5
8 3 3
1 1
3 3
6000
SD
3 3
7 1 1
3 3
1
3 3
7 2
215
Hospital: Department of Health
216
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (MEDICINE) 250B-OPD-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
217
3000
D 1 2
T
2
16
5 4
15
6 7
6000
9 SD
8
13
10
14
16 3 17
11 CH 12
218
Hospital: Department of Health
Planning Relationships:
a. Close to OPD Consultation Room (Pedia/ Under six) ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
b. Close to other Ancillary Services ENGINEERING TERMINALS
c. Close to toilet facilities
Outlet, 10A,2P,240V, duplex 17 grounding type,
This activity space provides facilities needed for universal slots
the delviery of general patient care Outlet, 10A,2P,240V, single 1 emergency light
Outlet, DATA 2
Outlet, Telephone 2
Smoke detector 4
219
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (OB-GYNE) 250B-OPD-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
220
9000
3000 3000 3000
3 DT 4 5 4 TD 3
2500
4 1 SD SD 1 4
4500
10 SD 4 10
6
6000
4
1
8 4 8
3500
7 SD 10 2 SD 7
1500
10 10
9 11 11 9
221
Hospital: Department of Health
222
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (PEDIA/ UNDER SIX) 250B-OPD-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
223
6000
3100 2900
18 8 9 6 13
12 CH
19
5 15 17
11
3000
SD 7 SD
18
10 16 14
6000
10 16
2
1 DT
3000
SD 7 SD
2
11 4
5
3
18 8 9 6 2 2
224
Hospital: Department of Health
225
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (SURGERY) 250B-OPD-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
226
3000
12 CH 11
17 3 16
14
10
13
8
6000
SD
9
7 6
15
4 5
16
2
T
2 1 D
227
Hospital: Department of Health
Planning Relationships:
a. Close to OPD Consultation Rooms ADDITIONAL EQUIPMENT & QUANTITY REMARKS
b. Close to other Ancillary Services ENGINEERING TERMINALS
This activity space provides facilities needed for Outlet, 10A,2P,240V, duplex 18 grounding type,
the delivery of general patient care universal slots
Outlet, 10A,2P,240V, single 1 emergency light
Outlet, DATA 1
Outlet, Telephone 1
Smoke detector 4
Outlet: Gas, Air, Electic 1
Electronic queuing machine, optional 1
228
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (DENTAL) 250B-OPD-RDS-10B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Acceptable sound level (db) 50 Accessible hot surface: heat generating instrument
Quality which cannot be tonal impact Domestic hot water: at sink and lavatory
Other risks NA
229
9075
3900 2200 2975
9 10 11 22 5 7 21 17
4 CH 8
4 20 SD
13 14 CH
3000
17 6 22
SD 4 SD 18
15 12
16
6000
9 10 11 2 DT
4
2
13 14
3000
1
17 SD SD
15 12 CH
4
16 22 5 2 2 2 2 2 3 3 3
230
Hospital: Department of Health
231
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (ENT) 250B-OPD-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
232
6000
3000 3000
19 17
2
10
1
2
T 7
6000
3 3 D
SD SD
11 12
12 9
4 13
1 T
D 18 16
5
2 14
5 CH
6
15 21
5 20 8 20
233
Hospital: Department of Health
This activity space provides facilities needed for ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
the delivery of general patient care ENGINEERING TERMINALS
Window curtain rail 1
Outlet, 10A,2P,240V, duplex 9 grounding type,
universal slots
Outlet, 10A,2P,240V, single 1 emergency light
Outlet, DATA 1
Outlet, Telephone 1
Smoke detector 2
234
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (OPHTHA) 250B-OPD-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
235
6000
16 5
12 CH 11
5 17 4 16
2
T 5 15
D 1
6 7
2
2 2 9
6000
SD SD
2 2 3
2 2 4 8
13
2 2
10
14
236
Hospital: Department of Health
Planning Relationships:
a. Close to other Ancillary Services ADDITIONAL EQUIPMENT & QUANTITY REMARKS
b. Within the OPD Department but with separate ENGINEERING TERMINALS
entrance for patients Window curtain rail 2
Outlet, 10A,2P,240V, duplex 20 grounding type,
This activity space provides facilities needed for universal slots
the delivery of general patient care Outlet, 10A,2P,240V, single 1 emergency light
Outlet, DATA 1
Outlet, Telephone 1
Smoke detector 4
Exhaust fan 1
237
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CONSULTATION ROOM
April 2016 OUTPATIENT (TB-DOTS) 250B-OPD-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
238
14900
4300 4400 3100 3100
17 15 17 15 18 178 8 8
14 14
11 18 11 18 5
4 4 18 17
10 16 10 16
SD SD
6
12 12 2
13 13
6000
9 9 7 DT 2
SD
2 2 CH 2 CH 2
SD
7 2 7 2 2 2
3 3 2
1
19
19 Storage/Supply Room
239
Hospital: Department of Health
240
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT STAFF PANTRY & LOUNGE 250B-OPD-RDS-14B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
241
3000
4 1
2 3 2
6000
SD
2 2
8
5 7
6
242
Hospital: Department of Health
243
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT PUBLIC TOILETS 250B-OPD-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
244
3100 3100
10 6 3 2 3
11
4
8
5
SH 7 9
4 8
5 9
6000
4 5
5 4
SH 5
1 4
11
3 3
2 10 6
245
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT CLINIC (TYPICAL) 250B-OPD-RDS-16A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient may arrive on foot Examination light 1
b. Patient may arrive on wheelchair Sphygmomanometer 1
c. Transfer patient to/from wheelchair to examining Examination bed 1
table and vice versa Gooseneck lamp 1
d. Clinical handwashing Stethoscope 1
e. Use of monitoring/diagnostic equipment IV stand with IV fluid 1
f. Medical, surgical, nursing and first aid Sharps collector, puncture- 1
activities proof container
Footstool 1
Waste bin, black lining 1
Waste bin, yellow lining 1
Note: provide other equipment and accessories necessary to
specific clinic type
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Desk 1
People Involved: Chair, upright, stacking 3
1 x Physician Cabinet, steel, filing 2
1 x Nurse or secretary Counter, 900mm high, cabinets 1
1 x Patient above and below
Sink, w/ gooseneck faucet 1
Concealed floor drain 1
Note: provide other furniture and fixture necessary to
specific clinic type
ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
ENGINEERING TERMINALS
Outlet, 10A,2P,240V, duplex 6 grounding type,
Planning Relationships: universal slots
a. Close to other Ancillary Services Outlet, 10A,2P,240V, single 1 for emergency light
Outlet, data 1
This activity space provides facilities needed for Outlet, telephone 1
the delivery of general patient care Smoke detector 1
Cubicle curtain rail 1
Note: provide terminals and related accessories necessary to
specific clinic type
246
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OUTPATIENT CLINIC (TYPICAL) 250B-OPD-RDS-16B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
247
3000
12 9
8 7 CH
13 10
4
5
6
6000
11 SD 2
3
3
12
2
T
2 1 D
248
Hospital: Department of Health
249
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
RECEPTION/
April 2016
AMBULATORY
SURGERY CLINIC WAITING AREA 250B-ASC-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
250
3000
6 5
5
2 5
T
D 1
6000
SD
251
Hospital: Department of Health
252
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
TREATMENT ROOM 250B-ASC-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
253
6000
3000 3000
8 8
7 7
6000
SD SD
4 4
9 1 9 1
3 3
5 5
6 2 6 2
254
Hospital: Department of Health
255
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
CONSULT/ EXAM 250B-ASC-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
256
3000
T 1 3
D
2
15 13
11
6000
SD
10
7
6
12
5
4 14
15 16 8 CH 9
17
257
Hospital: Department of Health
258
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
PATIENT DRESS/ TOILET 250B-ASC-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
259
4000
2
1
4
4500
SD
5
2 3
1
1500
260
Hospital: Department of Health
261
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
SCRUB-UP AREA 250B-ASC-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at scrub sink
Other risks NA
262
2500
6
57
2700
SD
4
1
2
3
263
Hospital: Department of Health
Sharps container 1
Clock 1
264
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
CLEAN-UP AREA 250B-ASC-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at scrub sink
Other risks NA
265
2500
6 4 5 7
3300
SD CH
266
Hospital: Department of Health
267
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
RECOVERY ROOM 250B-ASC-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at toilet lavatory
Other risks NA
268
7000
2000 5000
5 4 4
2
6
T
11 1 D
10
12 9 3
6000
SD
3
7
8
6 6
9
5 5
269
Hospital: Department of Health
270
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
OPERATING ROOM 250B-ASC-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 700 - 1,000
SOUND SAFETY
Other risks NA
271
6000
5
13
7
14
3
15
4 4
6000
2 SD
12
9 1 16
9 6
10
8 11
18 DT 17
272
Hospital: Department of Health
273
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
AMBULATORY
SURGERY CLINIC
STERILIZATION ROOM 250B-ASC-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
274
3500
3 6
CH
4 5
CH
3400
7 SD
1
2
9 10
8
275
Hospital: Department of Health
276
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ASC-RDS-10B
AMBULATORY STERILE INSTRUMENT
April 2016 SUPPLY & STORAGE ROOM
SURGERY CLINIC
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
277
3500
2 3
2600
2
SD
4
2 1
278
SCALE 1:300 M
12000
INFO/
SUPPLY
RECEPTION
GYM
AREA
WAITING
AREA
279
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB RECEPTION & WAITING 250B-PR-RDS-01A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Reception/waiting area for patients, relatives, and White board 1
visitors.
Waste bin, w/ black or 2
colorless lining
280
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB RECEPTION & WAITING 250B-PR-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
281
4
2 TD
CH
2
1
6600
SD
3 3
3000
282
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB CONSULT/EXAM ROOM 250B-PR-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient may arrive on foot. Sphygmomanometer, non-mercurial 1
d. Clinical handwashing
e. Use of monitoring/diagnostic equipment
f. Medical, nursing, and related activities FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Desk, 600 x 1200mm 1
People Involved:
1 x Physician
1 x Nurse
1 x Patient, relatives, and visitor
283
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB CONSULT/EXAM ROOM 250B-PR-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
284
2100
4
5
3
7
4000
SD
6
1 2
T
D
2
2
285
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB TREATMENT/GYM AREA 250B-PR-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
Ultrasound 3
a. Patient may arrive on foot. Exercise bike 2
b. Patient may arrive on wheelchair or stretcher Parallel bar, adjustable 1
trolley Stair exerciser 1
c. Patient is transferred to/from wheelchair or Pulley system, wall mounted 1
stretcher trolley to plinth, or therapy equipment Waste bin, general 2
and vice versa FURNITURE AND
QUANTITY REMARKS
d. Use of therapeutic equipment FIXTURE CHECKLIST
e. Therapeutic activities Chair, upright, stacking
Table, side, with cabinet below 3
Counter, with sink, and cabinets 1
above and below
Lavatory, wall-mounted 1
People Involved: Concealed floor drain 1
5-7 x Physical Therapists Plinth 3
5-7 x Patients
relatives, visitors
286
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHYSICAL REHAB TREATMENT/GYM AREA 250B-PR-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
287
6100 2900
4 3 4 3 4 3
2 2 2
5400
1
5 5 5
CH SD
7
8 6
17 T
12000
D
16
1700
SD
3 10 18
3
10
14
4900
15
3 SD 3
3 12
11 14
3 16 9 13
288
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-PR-RDS-04A
TOILETS, DRESS CUBICLES & SOILED
April 2016 PHYSICAL REHAB LINEN AREA
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient makes use of toilet facilities Waste bin, general 2
b. Patient makes use of dressing cubicles Hamper, linen 1
c. Soiled/used linen is placed in hamper
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Water closet w/ spray hose 2
Lavatory 2
People Involved: Floor strainer 2
Physical Rehab patients and staff Grab bar, wall-mounted 2
Curtain rail with rod 2
289
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-PR-RDS-04B
TOILETS, DRESS CUBICLES &
April 2016 PHYSICAL REHAB SOILED LINEN AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
290
250B-PR-RDS-04C
1900 1900
2 2
1900
1 3
2150
SD
5 5 5
1350
6
4 4
7
1 MALE TOILET
2 Waste bin
3 FEMALE TOILET
4 DRESS CUBICLE
5 Cubicle curtain and rod
291
SCALE 1:300 M
18000 6000
TOILET
WAITING STORAGE
UP
AREA
ISOLATION
PANTRY
12000
INFORMATION/
ADMITTING DIALYSIS TREATMENT AREA
6000
WATER
TREATMENT
RE-
ROOM
PROCESSING
CONSULT ROOM
292
Hospital: Department of Health
293
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
INFORMATION, ADMITTING &
April 2016 DIALYSIS WAITING AREA 250B-DIA-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
294
3
3 3
SD
7 7
8900
SD
1
2
T D
2 2
6 4 4
5
3700
295
Hospital: Department of Health
296
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DIALYSIS CONSULT ROOM 250B-DIA-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
297
3700
2 2 T
1 D
2
3100
SD
5
4
6 3
298
Hospital: Department of Health
299
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIA-RDS-03B
DIALYSIS TREATMENT
April 2016 DIALYSIS AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Quality which cannot be Tonal Impact Domestic hot water: at sink & lavatory
Other risks NA
300
8300 3800
4 2 4 2 4 2 9 11
5 5 5
6000
8 8 8
SD
12
CH 10
12000
13
T 11 9
7 2CH2 2 D
3 1 CH
6000
SD SD
8 8 8 8 8
5 5
6 6 6
4 2 4 2 4 2
4 2 4 2
12100
KEY SCALE 1:200 M
301
Hospital: Department of Health
302
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DIALYSIS ISOLATION ROOM 250B-DIA-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
303
3000
3 2
4000
SD
5 4
304
Hospital: Department of Health
305
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
JAN CLO., SOILED LINEN &
April 2016 DIALYSIS WASTE HOLDING AREA 250B-DIA-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
306
3000
800
8 9 10 11
1700
SD
4100
7
6
5
1600
SD
4
CH 1 2 3
307
Hospital: Department of Health
308
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DIALYSIS PANTRY 250B-DIA-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
309
3100
3000
SD
2
1
CH
6 5
310
Hospital: Department of Health
311
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DIALYSIS REPROCESSING ROOM 250B-DIA-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-1000
SOUND SAFETY
Other risks NA
312
2300
CH
3
4100
4
SD 1
4 2
6
313
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
315
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 ANCILLARY 250B-AN-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
PHARMACY 243.00 250B-PHAR-DDS-01 319
Chief Pharmacist's Office 18.00 250B-PHAR-RDS-01 320
Counseling Room 9.00 250B-PHAR-RDS-02 323
Dispensing Area & Drug Information 36.00 250B-PHAR-RDS-03 326
Receiving/ Breakout/ Inspection Area 36.00 250B-PHAR-RDS-04 329
Bulk Storage 108.00 250B-PHAR-RDS-05 332
Staff Pantry/ Lounge 18.00 250B-PHAR-RDS-06 335
Parenteral Admixture Room 9.00 250B-PHAR-RDS-07 338
Extemporaneous Preparation Area 9.00 250B-PHAR-RDS-08 341
317
Hospital: Department of Health
250-Bed (Level 3)
SERVICE FACILITY SHEET INDEX
Hospital HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 ANCILLARY 250B-AN-SFSI-02
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
BLOOD STATION 124.00 250B-BS-DDS-01 396
Waiting Area 27.00 250B-BS-RDS-01 397
Screening & Assessment 12.00 250B-BS-RDS-02 400
Component Preparation Room 14.00 250B-BS-RDS-03 403
Testing Room 13.00 250B-BS-RDS-04 406
Blood Component Storage 20.00 250B-BS-RDS-05 409
Blood Collection Room 24.00 250B-BS-RDS-06 412
Staff Lockers, Pantry and T&B 14.00 250B-BS-RDS-07 415
318
SCALE 1:300 M
12000
BULK
9000
STORAGE
ROOM
21000
RECEIVING/
BREAKOUT/
INSPECTION
AREA CHIEF
OFFICE
3000
COUNSELING EXTEMPORANEOUS
PARENTERAL
ROOM PREPARATION
ADMIXTURE
AREA
3000
DISPENSING DISPENSING
AREA AREA
319
Hospital: Department of Health
320
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-PHAR-RDS-01B
CHIEF PHARMACIST'S
April 2016 PHARMACY OFFICE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
SOUND SAFETY
Other risks NA
321
6000
7 7 DT 2 8
9
4 1
6
3000
SD
3 5
322
Hospital: Department of Health
323
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY COUNSELING ROOM 250B-PHAR-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
324
3000
3000
3 SD
D
T 1
2
4
325
Hospital: Department of Health
326
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
DISPENSING AREA &
April 2016 PHARMACY DRUG INFORMATION 250B-PHAR-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
SOUND SAFETY
Other risks NA
327
12000
9 10
1
CH
3000
8 SD SD 8
2
4
2
CH CH CH 5 7 TD 3 10
8 8 1 8 6
2
328
Hospital: Department of Health
329
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-PHAR-RDS-04B
RECEIVING/ BREAKOUT/
April 2016 PHARMACY INSPECTION AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
SOUND SAFETY
Other risks NA
330
6000
CH
2
1
6 3
CH
6000
SD
4
5
331
Hospital: Department of Health
332
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY BULK STORAGE 250B-PHAR-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
333
12000
2 SD
1 SD
9000
1
1
1
SD SD
34 2 2
1 1
334
Hospital: Department of Health
335
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY STAFF PANTRY/ LOUNGE 250B-PHAR-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
336
6000
6
4 4 7
3000
SD 3 CH
5 4 4 1
10 5
5 2
5 89
337
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY PARENTERAL ADMIXTURE 250B-PHAR-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Pharmacist and pharmacist's assistant Pharmaceutical refrigerator 1
perform admixture activities inside the room Cabinet, IV visual clarity 1
b. Finished items/products are stored and/or inspection
placed in cart for release to nursing wards and Scanner, laser 1
other hospital units Compounding machine, high 1
speed
Counting machine, for tablet 1
and capsule
Cart, stainless steel; with 1
casters
Waste bin 2
People Involved: FURNITURE AND
QUANTITY REMARKS
1 x Pharmacist FIXTURE CHECKLIST
1 x Pharmacist's assistant Counter, work; with overhead 1
cabinets
Sink, stainless steel 1
Chair, upright 2
Dispenser, soap and paper 1
towel
Clock 1
338
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
PARENTERAL
April 2016 PHARMACY ADMIXTURE 250B-PHAR-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
339
3000
4 98 7 6
2 1
3
12
3000
SD
T
11 10
5
13
340
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY EXTEMPORANEOUS PREP 250B-PHAR-RDS-08A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Pharmacist and pharmacist's assistant Counting machine, for tablet 1
perform extemporaneous preparation and and capsule 1
compounding of medication as required Unit dose packing machine 1
b. Activities include preparation. Assembly, labeling Computer with printer 1
patient medications Waste bin 2
c. Clerical work is performed (documentation,
inventory, etc.)
341
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PHARMACY EXTEMPORANEOUS PREP 250B-PHAR-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
342
3000
3 4 5
2 1
3000
SD
8
6
7
T
D 10
343
12000 SCALE 1:300 M
3900 2100 6000
UP
JAN
2100 2100 2900
AUTOCLAVE
GLASS
WASHING/
STORAGE
ROOM STORAGE PANTRY
3700
7300
MICROSCOPY
HISTOPATHOLOGY
5200
MICROBIOLOGY/
BACTERIOLOGY
1900
ANTE
STREAKING
ROOM
ROOM
11200
CHEMISTRY
3700
SEROLOGY/
IMMUNOLOGY
48000
4100
BLOOD TYPING,
CROSS MATCHING, POST
BTR INVESTIGATION
1500 3100
CHIEF PATHO
OFFICE
3700
HEMATOLOGY
2500
CMT
OFFICE
5900
PATHOLOGY
OFFICE
3700
AFFILIATES'
ROOM
2500
RECORDS
3700
ROOM
CONFERENCE
ROOM
4200
EXTRACTION
(2) RECEPTION/
RECEIVING/
RELEASING
7600
5200
WAITING
AREA
3000
2500 3900
344
Hospital: Department of Health
Planning Relationships:
a. Close to Blood Donor's Room
b. Close to Pathologist's Office
345
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY WAITING AREA 250B-LAB-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
346
12000
3 3 3 3 3 1
5200
SD 3 SD
3 3
3 3 3 3
4 3 3
3000
4
5
6
4
2500 3900
347
Hospital: Department of Health
348
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-02B
RECEPTION/ RECEIVING/
April 2016 LABORATORY RELEASING
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
349
6000
5 4 4 4 4 4 2
CH
2450
SD
T
3 3 D
CH CH
1
350
Hospital: Department of Health
351
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY EXTRACTION AREA 250B-LAB-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
352
3900
8 9 7
2100
4
2
6
5 1 3
4200
SD 10
8 9 7
2100
4
2
6
5 1 3
353
Hospital: Department of Health
354
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY CONFERENCE ROOM 250B-LAB-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
355
6000
2 2 2 2
T
D
3700
2 1 SD 2
2 2 2 2
5 3
356
Hospital: Department of Health
357
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-05B
PATHOLOGY OFFICE/
April 2016 LABORATORY LIBRARY
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
358
1950
10
1500
10 8
5 5
5 5 10
9
5 5 D
2 4
1
5900
SD
4 D
6 6 1
3
4 D
6 6 1
4 D
7 7 1
3900
359
Hospital: Department of Health
360
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-06B
CHIEF PATHOLOGIST'S
April 2016 LABORATORY OFFICE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
361
3900
6 6 2 TD 4
3
5 1
3100
CH SD
8 7
1500
8
1950
362
Hospital: Department of Health
363
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY CHEMISTRY 250B-LAB-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
364
3900
CH 9 D 5
7 6
CH
1
11
SD
FO
2
4
10
CH
11200
FO
CH
2 FO
4
SD
10
CH
7 7
3 CH11 8 121314
365
Hospital: Department of Health
366
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY HEMATOLOGY 250B-LAB-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
367
6000
12 13 11 CH 3 CH
7 CH
3700
SD 4
6 10 CH
5 9 1 CH
D 8
368
Hospital: Department of Health
369
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY SEROLOGY/ IMMUNOLOGY 250B-LAB-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
370
6000
12 3 8
13 14 15 CH 11 CH
1
7 CH
3700
SD 4
CH
6 7 10
5 D 9 9 CH
371
Hospital: Department of Health
372
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-10B
MICROBIOLOGY/
April 2016 LABORATORY BACTERIOLOGY
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
373
6000
7 7 7 8 8
5200
CH SD CH
D 9 9
T 3
7100
5
4
10
CH CH
3 12 13 14 CH
11 6
2
1900
SD
5 10 SD 9
1 3 16
CH 17 CH 19
15 18
374
Hospital: Department of Health
375
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY MICROSCOPY 250B-LAB-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
376
6000
5 D 12 13 9 8 CH
6 7 CH
3700
SD 4
10 CH
15 16 17 3 1 CH
14 11
377
Hospital: Department of Health
378
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY HISTOPATHOLOGY 250B-LAB-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
379
3900
3 6 CH 9 11
CH CH
12
13
14 5 5 10
CH CH
10
5500
2
4
8
16
1 SD
15
17
18
1800 19
7 20
2700
KEY SCALE 1:100 M
1 Counter, laboratory, with cabinets 10 Microtome
above & below 11 Hot plate
2 Sink, utility, with drainboard and 12 Hot air oven
wall-mounted pegboard 13 Analytical balance
3 Sink, cup 14 Microscope
4 Exhaust air grille 15 Immunohistochemistry analyzer
5 Stool, adjustable height 16 Concealed floor drain
6 Gross cutting cabinet 17 Sharps container, wall-mounted
7 Refrigerator 18 Waste bin, infectious
8 Cryostat 19 Waste bin, pathological & anatomical
9 Centrifuge, table-top 20 Waste bin, chemical
380
Hospital: Department of Health
381
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-13B
BLOOD TYP, CROSS MATCH.,
April 2016 LABORATORY POST-BRT INVEST.
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
382
6000
13
14 15 16
11 11
4100
SD
4
2
6 7 CH
12
5 D 3 CH
10 9 CH
8
383
Hospital: Department of Health
384
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY GLASS WASHING 250B-LAB-RDS-14B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
385
3900
3 2 CH
4 1
5
2100
SD
386
Hospital: Department of Health
387
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY AUTOCLAVE 250B-LAB-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
388
3900
CH 4
2100
1 SD
2
3
389
Hospital: Department of Health
390
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LAB-RDS-16B
STAFF LOCKER ROOM AND
April 2016 LABORATORY T&B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
391
12000
3900 1300 1900 4900
6 9
5
4
3300
SD 7
1 8 3
2 2
4 JANITOR'S CLOSET
5 Slop sink, with faucet
6 Shelf, open
392
Hospital: Department of Health
393
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LABORATORY STAFF PANTRY 250B-LAB-RDS-17B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
394
3900
3 3 8
2
3300
SD 1 CH
4 3 3 5
6
7 1011
395
SCALE 1:300 M
15000
2600 3600 3100 3200 2500
TESTING
ROOM
5900
6400
BLOOD BLOOD
COLLECTION COMPONENT
ROOM STORAGE
BLOOD
ISSUANCE
12400
AREA
2600
2100
RECORDS
ROOM
3900
3900
COMPONENT STAFF
WAITING SCREENING/ PREPARATION LOCKERS
AREA ASSESSMENT ROOM & PANTRY
396
Hospital: Department of Health
397
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BLOOD STATION WAITING AREA 250B-BS-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
398
4500
5 4
3300
3
4 4
1
3
6000
SD TD
6 2
6
2700
4
3000 1500
KEY SCALE 1:100 M
399
Hospital: Department of Health
400
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BLOOD STATION SCREENING & ASSESSMENT 250B-BS-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
401
3000
6
4
1 D
3
3900
6 5
SD
2
5
1
3
4 4 TD
402
Hospital: Department of Health
403
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-BS-RDS-03B
COMPONENT PREPARATION
April 2016 BLOOD STATION ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400
SOUND SAFETY
404
3500
9 10
4
3900
SD CH
3
7
8 CH
5 CH 1 CH
2
405
Hospital: Department of Health
406
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BLOOD STATION TESTING ROOM 250B-BS-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400
SOUND SAFETY
407
3200
5 1
CH
3900
SD 3 CH
6
7 2
408
Hospital: Department of Health
409
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-BS-RDS-05B
BLOOD COMPONENT
April 2016 BLOOD STATION STORAGE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
410
3100
6400
SD 1
2 D
3
4
3
411
Hospital: Department of Health
412
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BLOOD STATION BLOOD COLLECTION ROOM 250B-BS-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
413
3600
4 1
2
3 D
10 5
11
9
8
4 6
6400
3 SD
10 7
11
9
3
10
11
9
414
Hospital: Department of Health
415
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-BS-RDS-07B
STAFF LOCKERS, PANTRY &
April 2016 BLOOD STATION TOILET
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
416
4000
1100
7 7 7 7
9 4 4
3900
SD 3
2800
4 4
9
8
2 CH 1 6 5
1500 2500
417
11900
6500 2400 3000
UP
3000
CONFERENCE/
2200 3100
TRAINING
ROOM
T CONTROL
3900
PANTRY &
LOCKERS
3000
7100
CT-SCAN
STAFF
FT
1900 3000
STAFF
MT
JAN
T
CLO
5300
R/F
X-RAY
4100
RAD
HEAD
OFFICE
1550
DARK
T
ROOM CONTROL
4200
6700
X-RAY 2
READING
ROOM
3000
T DARK
51000
CONTROL
ROOM
T
FILM
3900
FILE
STORAGE
4200
X-RAY 1
SUB-
4500
3150
WAITING
MAMMOGRAPHY AREA
3400 1600
2100 3100
ULTRA T
SOUND 3
DRESS
SUPPLY DRESS
ULTRA ULTRA
SOUND 1 SOUND 2
WAITING
AREA
12000
6100
CONTROL TECHNICAL
CLERICAL
4400
ROOM ROOM
ROOM MRI
RECEPTION/ MAGNET
INFO ROOM
3000
2900
FT
MT
418
Hospital: Department of Health
People Involved:
1 x X-Ray Clerk
Patients
Companion/ Watchers
419
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
SUB-LOBBY/ WAITING
April 2016 RADIOLOGY AREA 250B-RAD-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
420
5500
2
1 1 1
4600
SD
1 1 1
1
12000
7400
SD
4
1 1 1
3
8950
421
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY CLERICAL ROOM 250B-RAD-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Clerk receives request of patients to be x-rayed Computer 1
b. X-ray Technician/ Technologist schedules patient Waste bin w/ black lining 3
and special radiographic procedures Airconditioning Unit 1
c. Clerk types results, files and retrieves records. Uninterrupted Power Supply 1
d. Clerk issues results of radiographic procedures done Automatic Voltage Regulator 1
422
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY CLERICAL ROOM 250B-RAD-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
423
4200
9 2 TD 6 9
5
5
1 3 T
D
4400
SD
D 3 4
5
7
8 8 8 8 9
424
Hospital: Department of Health
425
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
CHIEF RADIOLOGIST'S
April 2016 RADIOLOGY OFFICE 250B-RAD-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
426
1500
1900
12
11
8
4
2 6
T 1
D
4100
7 SD
5
7 11
3
6
D
10 9
3000
KEY SCALE 1:100 M
427
Hospital: Department of Health
428
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY CONFERENCE ROOM 250B-RAD-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
429
6500
7 5 6
SH
3 3 3 3
3100
2 3 1 SD 3
CH 3 3 3 3
4 TD
1 Table, conference
2 Cabinet, low
3 Chair, conference
4 Projection screen
5 Negatoscope
6 Whiteboard
7 Waste bin
430
Hospital: Department of Health
431
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY READING ROOM 250B-RAD-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
432
3000
9
71 3 3 2 7
71 3
3 2 7
71 3
3 2 7
6700
T
D SD
10
5 4
D
6 8
433
Hospital: Department of Health
434
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY FILES ROOM 250B-RAD-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
435
3000
3900
SD
1 Shelf, open
2 Ladder, aluminum
436
Hospital: Department of Health
437
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY ULTRASOUND ROOM 250B-RAD-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
438
1900 4600
16 3 4 2 15 TD
12 7 5
6 1
14
3100
SD 7
8
CH
9 13
10 11 SH
439
Hospital: Department of Health
People Involved
1 x Patient
1 x Technologist
440
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY MAMMOGRAPHY ROOM 250B-RAD-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
441
6500
TD 10 8
1 6
2 4
7
3150
SD
9
9
11
SH
3 5
442
Hospital: Department of Health
Footstool 1
Cabinet, storage 1
Indicator light (above door, 1
exterior side)
Water Closet 1
Lavatory 1
443
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-RAD-RDS-09B
RADIOGRAPHIC X-RAY
April 2016 RADIOLOGY ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
444
6350
2
3
3600
4200
5 SD 9
6
7
TD
8 4
13
10
(SHARED)
11 12
4200
3000
445
Hospital: Department of Health
446
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-RAD-RDS-10B
RADIOGRAPHIC X-RAY
April 2016 RADIOLOGY CONTROL ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
447
2550
6
1
5
3
4200
SD
2
2
3
5
1
6
448
Hospital: Department of Health
449
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-RAD-RDS-11B
RAD-FLUOROSCOPIC X-RAY
April 2016 RADIOLOGY ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
450
6350
1 15
4650
9 6
5250
12 SD
16
6800
7
10
TD
14
4 CH
5 3
13 11
2150
1550
17 19 18
451
Hospital: Department of Health
452
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY CT-SCAN 250B-RAD-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
453
1650 4800
2200
17 18
15
2 8
9
7080
1
SD
D
T
4
10
12 6 16
13
14 CH
3 11 5 7
6350
KEY SCALE 1:150 M
1 Radiographic unit, Computerized 11 Sharps disposal unit
Tomography 12 Clock
2 Transformer & power distribution unit 13 Waste bin
3 Counter, with cabinets above and below 14 Concealed floor drain
4 Cabinet, mobile 15 Medical gas console : Air,
5 Sink, stainless steel Oxygen, Vacuum)
6 IV stand 16 Indicator light (above door,
7 Lead apron rack exterior side)
8 Footstool 17 TOILET
9 Negatoscope 18 CONTROL ROOM
10 CT injector unit
454
Hospital: Department of Health
455
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY CT-SCAN CONTROL ROOM 250B-RAD-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
456
4800
2280
SD
3
3
1 2
6 TD 4
1 Control console
2 Desk, with computer & printer
3 Chair, swivel
4 Clock
5 Whiteboard
6 Waste bin
457
Hospital: Department of Health
People Involved:
1 x Patient
1 x Technologist
458
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY MRI MAGNET ROOM 250B-RAD-RDS-14B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
459
7300
8
2
5900
3
4
5 6 7
460
Hospital: Department of Health
461
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY MRI CONTROL ROOM 250B-RAD-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
462
5500
1
3
T
D
9000
SD
5 2 4
6
463
Hospital: Department of Health
464
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-RAD-RDS-16B
MRI SYSTEM COMPONENT
April 2016 RADIOLOGY ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
465
2200
2
3 2
6100
SD
466
Hospital: Department of Health
People Involved:
X-ray Radiologic Technologist
Radiology Department Staff
X-ray Interns FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Film loading counter 1
Counter, with cabinets above and 1
below
Sink, stainless steel 1
Concealed floor drain 1
467
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY DARK ROOM 250B-RAD-RDS-17B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
468
1800
3
1 2
7
3000
SD
T
D 10
8 9
5CH
6 4
469
Hospital: Department of Health
470
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 RADIOLOGY STAFF LOUNGE/ T&B 250B-RAD-RDS-18B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
471
3000
9 CH
3
2 2
1 8 4
3900
2 2
SD 5
6
77 77 7
3000
11800
10
11
3000
14 13
1900
12
472
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
473
Hospital: Department of Health
250-Bed (Level 3)
SERVICE FACILITY SHEET INDEX
Hospital HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 NURSING WARDS 250B-NU-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
NURSING WARDS 178.00 250B-NU-DDS-01 476
Nurse Station 42.00 250B-NU-RDS-01 477
Treatment Area 12.00 250B-NU-RDS-02 480
Department Head's Office 21.00 250B-NU-RDS-03 483
Conference Room 31.00 250B-NU-RDS-04 486
Patient Room (Typical) 18.00 250B-NU-RDS-05 489
4-Bed Ward (Typical) 36.00 250B-NU-RDS-06 492
Isolation Room (Typical) 18.00 250B-NU-RDS-07 495
475
476
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS NURSE STATION 250B-NU-RDS-01A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Nurse makes plan of her activities and determines Nurse call console 1
priorities Rack, chart 1
b. Nurse makes proper inventory of available resources: E-cart 1
supplies, medicine, etc.; to determine requisitions Whiteboard 1
c. Nurse prepares for admission of patient Clock 1
d. Nurse enters name of patient in admission book, Sharps container 1
ward directory, and diet work book Hamper, dirty linen 1
e. Nurse makes phones calls to coordinate with other Computer 1
hospital units regarding admitted patient Waste bin w/ yellow lining 1 infectious
f. Nurse entertains queries from visitors of patient Waste bin w/ black lining 1 general
g. Nurse records and reports patient care activities and
observations made
h. Nurse receives endorsements
i. Nurse carries out doctor's orders FURNITURE AND QUANTITY REMARKS
j. Nurse prepares and gives out medication FIXTURE CHECKLIST
k. Nurse conducts health education Counter, 2-level 1
l. Nurse transfers patient to examining table Table, 6-seater 1
m. Physician/Nurse administers necessary medical and Chair, upright; stacking 6
surgical treatment to patient Stool, adjustable height 2
Counter, with cabinets above 1
and below
Sink 2
People Involved: Concealed floor drain 1
1 x Chief Nurse Desk, 600 x 1200mm; with 1
2 x Staff Nurse computer and printer
1 x Nursing Attendant Chair, swivel 1
Physicians Shelf 1
Cabinet 1
Sink, deep 1
Stretcher / wheelchair nook 1
Lavatory 1
Water closet 1
477
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS NURSE STATION 250B-NU-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General Illumination (LUX) 750
SOUND SAFETY
Quality which cannot be Tonal Impact Domestic hot water: at medical preparation sink
Other risks NA
478
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS NURSE STATION 250B-NU-RDS-01C
TECHNICAL DESIGN DATA: LAYOUT OF ROOM AND SPACE COMPONENTS:
DIRECT SERVICES DESIGN DATA 4000 2000
3000
Cold Water required at sink & toilet fixtures 22
Compressed Air NA
11
4300
CH
Steam NA
10 SD 2 3 CH
4
CH
1
Others NA
1513
14
DT 20
Loading NA 1700
17 16
19 21 7
Spillage SLIGHT:occasional:frequent
18
Wheel Traffic NA
1 Counter, 2-level 14 Waste bin, infectious
2 Table, 6-seater 15 Sharps container
3 Chair, upright; stacking
Impacts NA
OFFICE:
4 Stool, adjustable height
16 Desk, 600 x 1200mm; with
5 Rack, chart
Abrasion NA
6 Nurse call console computer and printer
7 E-cart 17 Chair, swivel
Internal Glazing NA
Space Components Minimum Space Required/Component (sq.m.)
Work Area
Medicine Preparation
Toilet
479
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS TREATMENT AREA 250B-NU-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on foot, in wheelchair or on a Footstool 1
stretcher trolley from ward Table, instrument 1
b. Transfer of patient from wheelchair or stretcher Table, Mayo 1
trolley to examining table Cart, dressing 1
c. Physician or nurse administers necessary medical, Examination lamp 1
surgical and/or first-aid treatment to patient IV / Irrigator stand 1
Negatoscope 1
Nurse call 1
Whiteboard 1
Kick bucket 1
Sharps container 1
Waste bin w/ yellow lining 1 infectious
Waste bin w/ black lining 1 general
480
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS TREATMENT AREA 250B-NU-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Quality which cannot be tonal Impact Domestic hot water: at sink & toilet lavatory
Other risks NA
481
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS TREATMENT AREA 250B-NU-RDS-02C
TECHNICAL DESIGN DATA: LAYOUT OF ROOM AND SPACE COMPONENTS:
DIRECT SERVICES DESIGN DATA
Disposal hospital solid waste type: A,B,G
Hot Water required at sink
4000
3000
16 SD
17 1
Steam NA
Others 1 Nurse Call (to Nurse Station)
Impacts NA
4 Counter, with cabinets above 13 Whiteboard
and below 14 Cubicle curtain and rod or
Abrasion NA
5 Table, instrument PVC folding partition
6 Table, Mayo 15 Kick bucket
Easy Maintenance ESSENTIAL:desirable:unnecessary 7 Cart, dressing 16 Concealed floor drain
chair & stretcher access SPACE DEMANDS (Total Minimum Space Required in sq.m.) :
Windows clear, solar control, Space Components Minimum Space Required/Component (sq.m.)
privacy control Treatment Area
Internal Glazing NA
482
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS DEPARTMENT HEAD'S OFFICE 250B-NU-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Department Head reads, writes and uses telephone Waste bin w/ black lining 2 general
on his desk
b. Department Head receives visitors
c. Department Head is consulted by patients/relatives
d. Secretary stores, files and retrieves records
e. Department Head supervises the nursing
department's activities
483
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS DEPARTMENT HEAD'S OFFICE 250B-NU-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
484
NA
485
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS CONFERENCE ROOM 250B-NU-RDS-04A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Department Head receives visitors Whiteboard / projection screen 1
b. Department Head is consulted by patients/relatives Waste bin w/ black lining 1
c. Department Head conducts staff meetings and LCD Projector 1
special lectures Sound System 1
486
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS CONFERENCE ROOM 250B-NU-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 400-500
SOUND SAFETY
Other risks NA
487
NA
488
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS PATIENT ROOM (TYPICAL) 250B-NU-RDS-05A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on foot, in wheelchair or on a stretcher Television 1
trolley Console, bedhead 1
b. Transfer of patient to a hospital bed from a Waste bin w/ yellow lining 1 infectious
wheelchair or a stretcher trolley and vice versa Waste bin w/ black lining 2 non-biodegradable
c. Patient undresses/dresses in the vicinity of Water Heater 1
hospital bed, with or without assistance
d. Patient takes meal in bed or in sitting area FURNITURE AND
QUANTITY REMARKS
e. Patient receives visitors FIXTURE CHECKLIST
f. Patient stores clothing and other personal Hospital bed, adjustable; with 1
belongings adjustable side rails
g. Patient requires privacy Chair, upright; stacking 1
h. Patient uses toilet and bath Footstool 1
i. Use of monitoring/ diagnostic equipment on the patient Bench, cushioned 1
j. Physicians and nurses check on patients Table, side; with cabinet 1
k. Handwashing and other clean up activities Table, overbed 1
l. Nurse gives medication to patient Closet, wardrobe 1
m. Nurse may feed or wash patient, in the absence of Lavatory, wall-hung 1 at strategic locations
a relative or watcher along corridor
Concealed floor drain 1
Water Closet w/ spray hose 1
Lavatory 1
People Involved: Shower Set 1
1 x Patient
2 x Visitors ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
1 x Resident Physician/ Medical Specialist ENGINEERING TERMINALS
1 x Nurse or Nursing Aide Window curtain rail 1
Bedhead light w/ night lamp 1 fluorescent, 20W
w/ pendant switch
Outlet, 10A,2P,240V, duplex 6 grounding type,
Planning Relationships: universal
a. Close to Nurse Station Outlet, 10A,2P,240V, single 1 for emergency light
b. Close to Medical/Surgical Services Nurse call station, normal 1 w/ pendant switch
c. Distant from Out-patient Department Nurse call station, emergency 1 w/ pendant switch
Outlet, antenna/Cable 1
Smoke Detector 1
489
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS PATIENT ROOM (TYPICAL) 250B-NU-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
490
491
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS 4-BED WARD (TYPICAL) 250B-NU-RDS-06A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on foot, in wheelchair or on a stretcher Television 1
trolley Console, bedhead 4
b. Transfer of patient to a hospital bed from a Waste bin w/ yellow lining 1 infectious
wheelchair or a stretcher trolley and vice versa Waste bin w/ black lining 2 non-biodegradable
c. Patient undresses/dresses in the vicinity of Water Heater 1
hospital bed, with or without assistance
d. Patient takes meal in bed or in sitting area FURNITURE AND
QUANTITY REMARKS
e. Patient receives visitors FIXTURE CHECKLIST
f. Patient stores clothing and other personal Hospital bed, adjustable; with 4
belongings adjustable side rails
g. Patient requires privacy Chair, upright; stacking 4
h. Patient uses toilet and bath Footstool 4
i. Use of monitoring/ diagnostic equipment on the patient Cubicle curtain and rod 4
j. Physicians and nurses check on patients Table, side; with cabinet 4
k. Handwashing and other clean up activities Table, overbed 4
l. Nurse gives medication to patient Closet, wardrobe 4
m. Nurse may feed or wash patient, in the absence of Lavatory, wall-hung 1 at strategic locations
a relative or watcher along corridor
Concealed floor drain 2
Water Closet w/ spray hose 1
Lavatory 1
People Involved: Shower Set 1
4 x Patient
4 x Visitors ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
1 x Resident Physician/ Medical Specialist ENGINEERING TERMINALS
1 x Nurse or Nursing Aide Window curtain rail 1
Bedhead light w/ night lamp 4 fluorescent, 20W
w/ pendant switch
Outlet, 10A,2P,240V, duplex 16 grounding type,
Planning Relationships: universal
a. Close to Nurse Station Outlet, 10A,2P,240V, single 1 for emergency light
b. Close to Medical/Surgical Services Nurse call station, normal 1 w/ pendant switch
c. Distant from Out-patient Department Nurse call station, emergency 1 w/ pendant switch
Outlet, antenna/Cable 1
Smoke Detector 1
492
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS 4-BED WARD (TYPICAL) 250B-NU-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
493
494
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS ISOLATION ROOM (TYPICAL) 250B-NU-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on foot, in wheelchair or on a stretcher Television 1
trolley Waste bin w/ yellow lining 1 infectious
b. Transfer of patient to a hospital bed from a Waste bin w/ black lining 1 general
wheelchair or a stretcher trolley and vice versa Water Heater 1
c. Patient undresses/dresses in the vicinity of Console, bedhead 1
hospital bed, with or without assistance
d. Patient takes meal in bed or in sitting area FURNITURE AND QUANTITY REMARKS
e. Patient receives visitors FIXTURE CHECKLIST
f. Patient stores clothing and other personal Hospital bed, adjustable; with 1
belongings adjustable side rails
g. Patient requires privacy Chair, upright; stacking 1
h. Patient uses toilet and bath Footstool 1
i. Patient uses monitoring/diagnostic equipment Bench, cushioned 1
j. Physicians and nurses check on patients Table, side; with cabinet 1
k. Handwashing and other clean up activities Table, overbed 1
l. Nurse gives medication to patient Closet, wardrobe 1
m. Nurse may feed or wash patient, in the absence of Lavatory, wall-hung 1
a relative or watcher Concealed floor drain 1
Cabinet, PPE 1
Water closet 1
Lavatory 1
People Involved: Shower set 1
1 x Patient
2 x Visitors ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
1 x Resident Physician/ Medical Specialist ENGINEERING TERMINALS
1 x Nurse or Nursing Aide Window curtain rail 1
Bedhead light w/ night lamp 1 fluorescent, 20W
Outlet, 10A,2P,240V, duplex 7 grounding type,
universal
Planning Relationships: Outlet, 10A,2P,240V, single 1 for emergency light
a. Acessible to Nurse Station Nurse call station, emergency 1 w/ pendant switch
b. Located at end portion of Nursing Ward Outlet, antenna/Cable 1
c. Close to medical/surgical services Smoke Detector 1
495
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NURSING WARDS ISOLATION ROOM (TYPICAL) 250B-NU-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
496
497
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
499
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 BURN UNIT 250B-BU-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
BURN UNIT 39.00 250B-BU-DDS-01 502
Nurse Station 15.00 250B-BU-RDS-01 503
Patient Cubicle 13.00 250B-BU-RDS-02 506
Whirlpool Bath 11.00 250B-BU-RDS-03 509
501
SCALE 1:300 M
10600
DN
COUNSELLING COUNSELLING
ROOM ROOM
FAMILY
WAITING
ROOM
2400
WHIRLPOOL
BATH 4
DIRTY
2700
UTILITY/
LINEN
3
12000
1500 2100
CLEAN
UTILITY
2
T BURN UNIT
3300
VIEWING CORRIDOR
CHANGING 1
AREA
SURGICAL ICU
502
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
APRIL 2016 BURN UNIT NURSE STATION 250B-BU-RDS-01A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a wheelchair or stretcher trolley Emergency light 1
b. Patient is transferred to bed and vice versa Central monitor (cardiac) 1
c. Nurses and nursing attendants monitor vital E-cart 1
signs of patient at regular intervals EENT diagnostic set 1
d. Nurses and nursing attendants attend to patient's Computer, with monitor and 1
needs at regular intervals: cleaning and dressing printer
of wounds, application of medicine, etc. Clock 1
e. High level nursing and medical dependence Rack, chart 1
Waste bin w/ yellow lining 2 hazardous
Waste bin w/ black lining 2
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
Counter, nurse station 1
People Involved: Counter, work, with cabinets 1
Patients above and below
1 x Resident Physician / Medical Specialist Shelf, open 1
1 x Nurse Sink, stainless steel 1
1 x Nursing Attendant Sink, utility 1
Stool, adjustable height 2
Lavatory 1
Water closet 1
ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
ENGINEERING TERMINALS
Outlet, 10A,2P,240V, duplex 8 grounding type,
universal slots
Outlet, 10A,2P,240V, single 2 for emergency light
Outlet, data 1
Planning Relationships: Outlet, telephone 1
a. Close to patient cubicles Paging system 1
b. Visual control of main entrance and visitors' Nurse call console 1
changing room Split-type, ACU 3-ton 1
Smoke detector 2
503
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
APRIL 2016 BURN UNIT NURSE STATION 250B-BU-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
504
2250
9
T
D
4 1
5
3 2
6600
SD
8
505
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BURN UNIT PATIENT CUBICLE 250B-BU-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a wheelchair or stretcher trolley Emergency light 1
b. Patient is transferred to bed and vice versa Volume respirator 1
c. Nurses and nursing attendants monitor vital Sphygmomanometer, wall-mtd 1
signs of patient at regular intervals Ambu bag, adult/pedia 1
d. Nurses and nursing attendants attend to patient's Suction apparatus 1
needs at regular intervals: cleaning and dressing Oxygen gauge 1
of wounds, application of medicine, etc. Tracheostomy set 1
e. High level nursing and medical dependence Infusion pump 1
f. Nurses and nursing attendants screen potentially Respirator/defribrillator 2
FURNITURE AND
QUANTITY REMARKS
FIXTURE CHECKLIST
People Involved: Hospital bed, adjustable 1
1 x Patient Bedhead console, w/ med gas 1
1 x Resident Physician Table, overbed 1
1 x Nurse Counter, with storage 1
1 x Nursing Attendant Door, glass; w/ windows 1
506
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BURN UNIT PATIENT CUBICLE 250B-BU-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
507
4100
4 2
5
8
1
10
3000
7 SD 6
3
508
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BURN UNIT WHIRPOOL BATH 250B-BU-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Immersion tub is filled with sterile water Emergency light 1
b. Patient is gently placed in tub (using a transfer patient monitor 1
trolley) Clock 1
c. Nurse/nursing attendant perform initial evaluation
d. Nurse/nursing attendant perform debridement,
blisters and wounds area cleaned and cared for
e. After the hydrotherapy procedure, patient is
gently lifted out of the immersion tub
f. Patient is returned to his/her cubicle for
509
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 BURN UNIT WHIRPOOL BATH 250B-BU-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SAFETY
Quality which cannot be tonal impact Maximum temperature (°C) 70 (water temperature
510
4350
4
2
5
2400
SD 1
3
6
511
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
3.7.1 OR
3.7.2 ICU
3.7.3 CSSR
First Edition
DEPARTMENT OF HEALTH
Manila
2017
513
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX 250B-OR-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
OPERATING ROOM COMPLEX 390.00 250B-OR-DDS-01 516
Transfer Area 12.00 250B-OR-RDS-01 517
Pre-Operation Area 23.00 250B-OR-RDS-02 520
Nurse Station 36.00 250B-OR-RDS-03 523
Operating Room 36.00 250B-OR-RDS-04 526
Post-Anesthetic Care Unit (PACU) 78.00 250B-OR-RDS-05 529
Dress, Lockers, T&B 31.00 250B-OR-RDS-06 532
Lounge 24.00 250B-OR-RDS-07 535
Anesthesiologist's Office 30.00 250B-OR-RDS-08 538
Anesthesia Storage 7.00 250B-OR-RDS-09 541
Sterile Instrument and Supply Storage 9.00 250B-OR-RDS-10 544
Scrub-Up Area 18.00 250B-OR-RDS-11 547
Sub-Sterile Room 18.00 250B-OR-RDS-12 550
Clean-Up Room 18.00 250B-OR-RDS-13 553
Janitor's Closet 5.00 250B-OR-RDS-14 556
Family Waiting Room 18.00 250B-OR-RDS-15 559
Scope Room 27.00 250B-OR-RDS-16 562
Dirty / Trauma 27..00 250B-OR-RDS-17 565
515
516
Hospital: Department of Health
517
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX TRANSFER AREA 250B-OR-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
518
519
Hospital: Department of Health
People Involved:
3 x Anesthesiologist
3 x Nurse
3 x Nursing Attendant
3 x Patient
FURNITURE AND QUANTITY REMARKS
FIXTURE CHECKLIST
Hospital bed, adjustable 3
Footstool 3
Planning Relationships:
a. Close to Anesthesiologist's Office ADDITIONAL EQUIPMENT & QUANTITY REMARKS
b. With direct access to Transfer Area ENGINEERING TERMINALS
Window curtain rail 2
Cubicle curtain rail 1
Outlet, 10A,2P,240V, duplex 9 grounding type,
universal slots
Outlet, 10A, 2P, 240V, single 1 for emergency light
Outlet, telephone 1
Outlet, DATA 1
Airconditioning unit 1 window/ split type
Smoke Detector 1
520
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX PRE-OPERATION AREA 250B-OR-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
521
NA
522
Hospital: Department of Health
523
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX NURSE STATION 250B-OR-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
524
525
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-OR-RDS-04A
OPERATING ROOM
April 2016 COMPLEX OPERATING ROOM
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a stretcher trolley Double X-ray Film Illuminator 1
b. Patient is transferred from stretcher trolley to Anesthesia Unit 1 w/ scavenging sys.
operating table Clock 1
c. Anesthesia is administered Operating lamp 1
d. Clinical handwashing UV Light 1
e. Use of diagnostic equipment Oxygen Unit 1 w/ tank holder
f. Patient is surgically operated Nitrogen 1
g. Pre-operative care O2 tank holder 1
Double-film negatoscope 1
Footstool 2
Glass/ white board 1
Suction apparatus 1
Tracheostomy set 1
Laryngoscope 1
E-cart 1
Suction machine 1
Orthopedic instrument set 1
ACU 1
Cardial monitor w/ pulse oximeter 1
Sphygmomanometer, non-mercurial 1
Defibrillator 1
People Involved: FURNITURE AND
QUANTITY REMARKS
2 x Physicians FIXTURE CHECKLIST
1 x Circulatory Nurse Operating table 1
1 x Scrub Nurse Mayo table 1
1 x Patient Instrument table 2
1 x Anesthesiologist Double basin stand 1
Single basin stand 1
Anesthetist's stool 1
Adjustable stool 2
Anesthetist's table 1
Anesthesia unit 1
Kick bucket 1
Irrigator stand 1
Sponge rack 1
Shelving; adjustable, 500mm deep 1
Pack table 1
Floor clean-out 1
Planning Relationships: ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
a. Adjacent to Sub-Sterilizing Room ENGINEERING TERMINALS
b. Adjacent to Scrub-Up Shades, light-proof 1 light-proof for special
eye/ dark rm. surgery
Outlet, 10A,2P,240V, duplex 11 grounding type,
universal slots
Outlet, 10A, 2P, 240V, single 2 for emergency light
Isolation Monitor 1 1.6m above floor
Grounding terminal 4 duplex
Outlet, telephone 1
Outlet, DATA 1 wall-mounted
Heat Detector 1 hospital grade,
locking type
Door with vision panel 1
526
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX OPERATING ROOM 250B-OR-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 750-1000
SOUND SAFETY
Other risks NA
527
NA
528
Hospital: Department of Health
529
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-OR-RDS-05B
POST-ANESTHETIC CARE
April 2016 OPERATING ROOM COMPLEX UNIT
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
530
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-OR-RDS-05C
POST-ANESTHETIC CARE
April 2016 OPERATING ROOM COMPLEX UNIT
TECHNICAL DESIGN DATA: LAYOUT OF ROOM AND SPACE COMPONENTS:
DIRECT SERVICES DESIGN DATA 6000
1 1
12200
2 8 8 2
Steam NA 4 3
Others NA
1
Loading NA
7
1
7
Impacts NA
2100
13
Abrasion NA
11 12
531
Hospital: Department of Health
532
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX DRESS, LOCKERS, T&B 250B-OR-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at toilet and bath
Other risks NA
533
NA
534
Hospital: Department of Health
535
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX LOUNGE 250B-OR-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
536
NA
537
Hospital: Department of Health
538
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-OR-RDS-08B
ANESTHESIOLOGIST'S
April 2016 OPERATING ROOM COMPLEX OFFICE & STAFF OFFICE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
539
540
Hospital: Department of Health
541
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX ANESTHESIA STORAGE 250B-OR-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
542
NA
543
Hospital: Department of Health
544
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-OR-RDS-10B
STERILE INSTRUMENT &
April 2016 OPERATING ROOM COMPLEX SUPPLY STORAGE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
545
NA
546
Hospital: Department of Health
547
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX SCRUB-UP AREA 250B-OR-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at scrub sink
Other risks NA
548
NA
549
Hospital: Department of Health
550
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX SUB-STERILE ROOM 250B-OR-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
551
NA
552
Hospital: Department of Health
553
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX CLEAN-UP ROOM 250B-OR-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
554
NA
555
Hospital: Department of Health
556
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX JANITOR'S CLOSET 250B-OR-RDS-14B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
557
NA
558
Hospital: Department of Health
559
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
November 2015 OPERATING ROOM COMPLEX FAMILY WAITING ROOM 250B-OR-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
560
561
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX SCOPE ROOM 250B-OR-RDS-16A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient is assessed/scheduled to be brought to Endoscopic viewing monitor 1
Scope Room Light source and processor 1
b. Patient arrives on a stretcher trolley Diathermy recorder and printer 1
c. Patient is transferred from stretcher trolley to Monitoring equipment 1
procedure table Anesthesia unit 1
d. Anesthesia is administered Endoscope washer 1
e. Clinical handwashing Computer and printer 1
f. Use of scope/s equipment; necessary
procedure is done on patient
g. Patient is wheeled out to PACU for recover/ FURNITURE AND
QUANTITY REMARKS
observation FIXTURE CHECKLIST
Trolley/cart 1
Endoscope/scope storage 1
cabinet
Desk 1
Side table 1
People Involved: Chair, upright 1
1-2 x gastroenterologists/specialists Counter, w/ cabinets above and 1
1 x Nurse below
1 x Nursing Attendant Sink, stainless steel 1
1 x Patient
1 x Anesthesiologist ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
ENGINEERING TERMINALS
Planning Relationships: Outlet, 10A,2P,240V, duplex 9 grounding type,
a. Adjacent to Nurse Station universal slots
b. Near PACU Outlet, 10A,2P,240V, single 1 for emergency light
c. Accessible from sub-sterile corridor Outlet, data 1
d. Outside OR Complex sterile area Outlet, telephone 1
Smoke detector 1
562
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX SCOPE ROOM 250B-OR-RDS-16B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 750-1,000
SOUND SAFETY
Other risks NA
563
6000
DT CH
9 11 3 6
4 5 12
10 13
4500
SD 1 14
7
2
15 8
1 Stretcher 9 Desk
2 Endoscope viewing monitor 10 Side table, with computer and
3 Light source and processor printer
4 Diathermy / recorder and printer 11 Chair, upright
5 Trolley/cart 12 Counter, 900mm high; with
6 Monitoring equipment cabinets above and below
7 Endoscope washer 13 Sink, stainless steel with
8 Endoscope/scope storage gooseneck faucet
cabinet 14 Concealed floor drain
15 Door with vision panel
564
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX DIRTY/TRAUMA ROOM 250B-OR-RDS-17A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient is assessed to be brought to Trauma Room Double X-ray film illuminator 1
b. Patient arrives on a stretcher trolley Anesthesia unit 1 w/ scavenging sys.
c. Patient is transferred from stretcher trolley to Clock 1
operating table Operating lamp 1
d. Anesthesia is administered UV light 1
e. Clinical handwashing Oxygen unit 1 w/ tank holder
f. Use of diagnostic equipment, if necessary Nitrogen 1
g. Patient is surgically operated O2 tank holder 1
h. Pre-operative care Footstool 1
Glass/white board 1
Suction apparatus 1
Tracheostomy set 1
Laryngoscope 1
E-cart 1
Orthopedic instrument set 1
Cardiac monitor w/ pulse oximeter 1
Sphygmomanometer, non-merc. 1
Defibrillator 1
People Involved: FURNITURE AND QUANTITY REMARKS
2 x Surgeons FIXTURE CHECKLIST
1 x Circulation Nurse Operating table 1
1 x Scrub Nurse Mayo table 1
1 x Patient Instrument table 1
1 x Anesthesiologist Double basin stand 1
Single basin stand 1
Adjustable stool 1
Anesthesist's stool 1
Anesthesist's table 1
Kick bucket 1
Irrigator stand 1
Sponge rack 1
Shelving; adjustable, 500mm deep 1
Pack table 1
Floor clean-out 1
ADDITIONAL EQUIPMENT & QUANTITY REMARKS
Planning Relationships: ENGINEERING TERMINALS
a. Adjacent to Nurse Station Shades, light-proof 1 light-proof for
b. Accessible from sub-sterile corridor special dark rm
c. Outside OR Complex sterile area Outlet, 10A,2P,240V, duplex 8 grounding type,
universal slots
Outlet, 10A,2P,240V, single 2 for emergency light
Isolation Monitor 1 1.6m above floor
Grounding terminal 4 duplex
Outlet, Telephone 1
Outlet, Data 1 wall-mounted
Door with vision panel 1
565
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 OPERATING ROOM COMPLEX DIRTY/TRAUMA ROOM 250B-OR-RDS-17B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 750-1,000
SOUND SAFETY
Other risks NA
566
6000
DT
14
12 5
20 10
4 3
6
4500
8
18 SD 2 1
11 4
7
13 5
17 9 9 16 15 19
567
568
Hospital: Department of Health
569
Hospital: Department of Health
ROOM DATA SHEET
(250-Bed, Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT NURSE STATION 250B-ICU-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
570
571
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT PATIENT BAY 250B-ICU-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a stretcher trolley Volume respirator 1
b. Patient is transferred from a stretcher trolley to bed Sphygmomanometer, wall-mtd 5
and vice versa Cuffs, pediatric 1
c. Nurses and nursing attendants monitor vital signs of Ambu bag, pediatric 1
patient at regular intervals Ambu bag, adult/pediatric 1
d. Use of monitoring and diagnostic equipment Suction apparatus 5
e. High level nursing and medical dependence Oxygen gauge 5
O2 set 5
O2 tank holder 5
Tracheostomy set 1
Infusion pump 1
Respirator/defribrillator 1
Emergency light 5
Patient Monitor 5
People Involved:
5 x Patients
1 x Resident Physician/ Medical Specialist FURNITURE AND
QUANTITY REMARKS
1 x Nurse FIXTURE CHECKLIST
1 x Nursing Attendant Hospital bed, adjustable 5
Bedhead console, with medical 5
gas outlets, power outlets, and
bedhead light
Table, overbed 5
Footstool 5
572
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT PATIENT BAY 250B-ICU-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
573
574
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT ISOLATION ROOM 250B-ICU-RDS-03A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Patient arrives on a stretcher trolley Emergency light 1
b. Patient is assessed by physician and nurse to determine Volume respirator 1
isolation requirements Sphygmomanometer, wall-mtd 1
c. Patient is transferred from a stretcher trolley to bed Cuffs, pediatric 1
and vice versa Ambu bag, pediatric 1
d. Nurses and nursing attendants monitor vital signs of Ambu bag, adult/pediatric 1
patient at regular intervals Suction apparatus 1
e. Use of monitoring and diagnostic equipment Oxygen gauges 1
f. High level nursing and medical dependence O2 set 1
g. Nurses and nursing attendants screen potentially infectious O2 tank holder 1
visitors Tracheostomy set 1
Infusion pump 1
Respirator/defribrillator 1
ICU patient headwall 1
ICU IV track 1
Bedhead light/lamp 1
Patient Monitor 1
People Involved:
1 x Patient FURNITURE AND
QUANTITY REMARKS
1 x Resident Physician FIXTURE CHECKLIST
1 x Nurse Hospital bed, adjustable 1
1 x Nursing Attendant Bedhead console, with medical 1
gas outlets, power outlets, and
bedhead light
Table, overbed 1
Footstool 1
Planning Relationships Door, glass; with full windows 1
a. Close to Operating Room Complex ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
b. Visible from ICU Nurse Station ENGINEERING TERMINALS
c. At the end of ICU patient bays Window curtain rail 1
Outlet, DATA 1
Outlet, Telephone 1
Outlet, 10A,2P,240V, duplex 5 grounding type,
universal slots
Outlet, 15A,2P,240V, single 1 for emergency light
ACU, split-type; 1-ton 1
Fire alarm 1
Smoke detector 1
575
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT ISOLATION ROOM 250B-ICU-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
576
577
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT OFFICE 250B-ICU-RDS-04A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Resident Physician reads and writes in his work station Computer 1 w/ printer & scanner
b. Resident Physician records, stores and retrieves data Airconditioning unit 1
from data file Waste bin w/ black lining 1
578
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT OFFICE 250B-ICU-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) NA
SOUND SAFETY
Other risks NA
579
580
Hospital: Department of Health
581
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ICU-RDS-05B
FAMILY COUNSELING
April 2016 INTENSIVE CARE UNIT ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
582
583
Hospital: Department of Health
584
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT VISITOR'S DRESSING ROOM 250B-ICU-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
585
586
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT STAFF LOCKERS & TOILET 250B-ICU-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Resident Physician and nurses change clothes in staff Waste Bin w/ black lining 1
lockers room Hamper 1
b. Storing of clothings and personal effects Water Heater 1
c. Wearing of gowns, masks and gloves
d. Resident Physician and nurses wash hands
or use alcohol hand santizer
e. Resident Physician and nurses use toilet and bath
587
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 INTENSIVE CARE UNIT STAFF LOCKERS & TOILET 250B-ICU-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
588
589
590
Hospital: Department of Health
591
Hospital: Department of Health
ROOM DATA SHEET
(250-Bed, Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CSSR-RDS-01B
CENTRAL STERILIZING &
April 2016 SUPPLY ROOM RECEIVING ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-1000
SOUND SAFETY
592
NA
593
Hospital: Department of Health
594
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CSSR-RDS-02B
CENTRAL STERILIZING &
April 2016 SUPPLY ROOM WORK AREA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-1000
SOUND SAFETY
595
NA
596
Hospital: Department of Health
597
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CSSR-RDS-03B
CENTRAL STERILIZING &
April 2016 SUPPLY ROOM AUTOCLAVE ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
598
NA
599
Hospital: Department of Health
600
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CSSR-RDS-04B
CENTRAL STERILIZING &
April 2016 SUPPLY ROOM STORAGE ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
601
NA
602
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
603
Hospital: Department of Health
605
15000 SCALE 1:300 M
6000 3000 6000
DN
6000
6000
CS CS
DELIVERY DELIVERY
ROOM ROOM
SUB-
2000 3000
3000
TO NICU STERILIZATION
SCRUB ROOM
UP
NICU DR
RECEIVING RELEASING
AREA AREA
6000
DELIVERY
ROOM
9700
RECOVERY
ROOM 6000
DELIVERY
ROOM
3300
STERILE JANITOR'S
3000
UP STERILE SUPPLY
ISOLATION
ROOM
ROOM
51000
51000
2600
ESSENTIAL
INTRA-PARTUM
7300
NEWBORN
3500
NURSE
CARE
SUPPLY STATION
1700
2100
LABOR
ROOM
4000
HIGH RISK
6100
PREGNANCY
UNIT
3000
NURSES'
LOUNGE
2800
AFFILIATES' SEPTIC
ROOM DELIVERY
3000
DOCTORS'
9800
LOUNGE
SEPTIC
3000
F DR LABOR
DRESS
3000
M DR
2100
WHEELED
DRESS STRETCHER
AREA
606
Hospital: Department of Health
607
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX NURSE STATION 250B-DR-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at lavatory and sink
Other risks NA
608
NA
609
Hospital: Department of Health
610
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX LABOR ROOM 250B-DR-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
611
NA
612
Hospital: Department of Health
613
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX DELIVERY ROOM 250B-DR-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-750
SOUND SAFETY
Other risks NA
614
615
Hospital: Department of Health
616
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX
CAESARIAN
DELIVERY ROOM 250B-DR-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 750-1000
SOUND SAFETY
Other risks NA
617
NA
618
Hospital: Department of Health
619
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX RECOVERY ROOM 250B-DR-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
620
NA
621
Hospital: Department of Health
622
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DR-RDS-06B
HIGH-RISK
April 2016 DELIVERY ROOM COMPLEX
PREGNANCY UNIT
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at scrub sink
Other risks NA
623
NA
624
Hospital: Department of Health
625
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX SCRUB-UP AREA 250B-DR-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at scrub sink
Other risks NA
626
NA
627
Hospital: Department of Health
628
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX SUB-STERILIZING ROOM 250B-DR-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
629
NA
630
Hospital: Department of Health
631
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
STERILE INSTRUMENT &
April 2016 DELIVERY ROOM COMPLEX
SUPPLY STORAGE 250B-DR-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
632
NA
633
Hospital: Department of Health
634
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX DRESS, LOCKERS, T&B 250B-DR-RDS-10B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at toilet and bath
Other risks NA
635
NA
636
Hospital: Department of Health
637
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX LOUNGE 250B-DR-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
638
NA
639
Hospital: Department of Health
640
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX CLEAN-UP ROOM 250B-DR-RDS-12B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
641
NA
642
Hospital: Department of Health
643
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 DELIVERY ROOM COMPLEX JANITOR'S CLOSET 250B-DR-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
644
NA
645
Hospital: Department of Health
646
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DR-RDS-14B
WHEELED STRETCHER'S
April 2016 DELIVERY ROOM COMPLEX AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
647
NA
648
SCALE 1:300 M
25200
2300 2300 7300 3100 5100 5100
DN
SUPPLY
6000
LEVEL II
LEVEL III LEVEL 1
INTERMEDIATE/
SICK GROWERS
5700
ON- STEP-DOWN
STAFF NURSE
CALL
LOUNGE STATION
12000
ROOM
3000
13200
1500
SCRUB NICU
3000
F DRESS RECEIVING
DRESS/ AREA
6000
M
T&B ISOLATION
DRESS/ BREAST
T&B ROOM
FEEDING
ROOM
649
Hospital: Department of Health
650
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
NEONATAL INTENSIVE
CARE UNIT
NURSE STATION 250B-NICU-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at lavatory and sink
Other risks NA
651
NA
652
Hospital: Department of Health
653
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
NEONATAL INTENSIVE
CARE UNIT LEVEL III SICK ROOM 250B-NICU-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at sink and lavatory
Other risks NA
654
NA
655
Hospital: Department of Health
656
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
NEONATAL INTENSIVE
CARE UNIT
BREASTFEEDING ROOM 250B-NICU-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
657
NA
658
Hospital: Department of Health
659
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
NEONATAL INTENSIVE
CARE UNIT
LOUNGE 250B-NICU-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
660
2300
6 5 CH
8
7
4 4
3
5700
4 SD 4
D T2
661
Hospital: Department of Health
662
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016
NEONATAL INTENSIVE
CARE UNIT
DRESS, LOCKERS, T&B 250B-NICU-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Quality which cannot be tonal impact Domestic hot water: at toilet and bath
Other risks NA
663
NA
664
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NEONATAL INTENSIVE CARE UNIT ISOLATION ROOM 250B-NICU-RDS-06A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. An infant is brought to Isolation Room to separate Hot plate, single element 1
him/her from other infants (suspected and Instrument sterilizer 1
confirmed infectious diseases) Incubator 1
b. Doctor/Nurse observes proper isolation Patient monitor 1
precautions and protocols: hand washing, gowning, Linen hamper 1
PPE, storage of clean supplies, among others Waste bin 1 w/ yellow lining
c. Nurse administers nursing care and clinical Sharps container 1
procedures to infant
c. Nurse administers nursing care and clinical
procedures to infant FURNITURE AND
QUANTITY REMARKS
d. Nurse measures infant's height and head FIXTURE CHECKLIST
circumference Cabinet, for storage of gowns, 1
e. Nurse weighs infant PPEs, clean supplies, etc.
f. Nurse records data gathered Counter, 900mm high with 1
g. Nurse prepared baby, i.e. cleans and dresses cabinets above and below
baby, feeds baby, etc. Lavatory 1
h. Nurse places baby in incubator Sink, with gooseneck faucet 1
i. Nurse monitors infant's vital signs Cabinet, bedside 1
People Involved:
1 x Infant ADDITIONAL EQUIPMENT &
QUANTITY REMARKS
1 x Nurse ENGINEERING TERMINALS
1 x Nursing Attendant Outlet, 10A,2P,240V, duplex 5 grounding type,
universal slots
Outlet, 10A,2P,240V, single 1 for emergency light
Outlet, data 1
Planning Relationships: Outlet, telephone 1
a. Near Nurse Station Smoke detector 1
665
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NEONATAL INTENSIVE CARE UNIT ISOLATION ROOM 250B-NICU-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-700
SOUND SAFETY
Other risks NA
666
3200
7
4 1
1300
SD
3 2 5
6
12 7
9
11
10 8
16
4700
17 SD
T
D
13
15 14
667
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
APRIL 2016 NEONATAL INTENSIVE CARE UNIT LEVEL II STEP DOWN 250B-NICU-RDS-07A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. An infant is transferred from Level III Sick to Hot plate, single element 1
Level II Step Down/Intermediate Care upon Instrument sterilizer 1
observance of infant's progress/development Incubator 4
and/or growing stability Radiant warmer 1
b. Nurse administers nursing care and clinical Weighing scale 1
procedures to infant Linen hamper 1
c. Nurse measures infant's height and head Waste bin 2 w/ yellow lining
circumference w/ black lining
d. Nurse weighs infant Sharps container 1
e. Nurse records data gathered
f. Nurse prepared baby, i.e. cleans and dresses FURNITURE AND
QUANTITY REMARKS
baby, feeds baby, etc. FIXTURE CHECKLIST
g. Nurse places baby in incubator Counter, 900mm high with 1
h. Nurse monitors infant's vital signs cabinets above and below
Desk, 600 x 1000mm 1
Chair, stacking, upright 1
People Involved: Stool, adjustable height 1
4 x Infants Sink, with gooseneck faucet 1
1 x Nurse Cabinet, bedside 4
1 x Nursing Attendant Partition, 1700mm high, clear 3
glass upper panel
668
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
APRIL 2016 NEONATAL INTENSIVE CARE UNIT LEVEL II STEP DOWN 250B-NICU-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
669
5100
13 T D 2
8 3 8
11
12 12
CH
6000
8 10
SD
11 15
12 14
16
9
5
8
16
11 4 CH
17 17 7
670
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NEONATAL INTENSIVE CARE UNIT LEVEL I GROWERS 250B-NICU-RDS-08A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. An infant is transferred from Level II Step Down/ Hot plate, single element 1
Intermediate Care to Level I Growers upon Instrument sterilizer 1
observance of infant's progress/development Incubator 5
and/or growing stability Linen hamper 1
b. Nurse administers nursing care and clinical Waste bin 2 w/ yellow lining
procedures to infant w/ black lining
c. Nurse measures infant's height and head Sharps container 1
circumference
d. Nurse weighs infant
e. Nurse records data gathered FURNITURE AND
QUANTITY REMARKS
f. Nurse prepared baby, i.e. cleans and dresses FIXTURE CHECKLIST
baby, feeds baby, etc. Counter, 900mm high with 1
g. Nurse places baby in incubator cabinets above and below
h. Nurse monitors infant's vital signs Desk, 600 x 1000mm 1
Chair, stacking, upright 1
Stool, adjustable height 1
People Involved: Sink, with gooseneck faucet 1
5 x Infants Cabinet, bedside 5
1 x Nurse Partition, 1700mm high, clear 4
1 x Nursing Attendant glass upper panel
671
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NEONATAL INTENSIVE CARE UNIT LEVEL I GROWERS 250B-NICU-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
672
5100
TD 11
2
8 3 8
9 9
10 10
6000
8 8
SD
9 9
10 10
12
13
14
1 8
5
6 4 9
CH
7 15 15
673
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
675
Hospital: Department of Health
250-Bed (Level 3)
SERVICE FACILITY SHEET INDEX
Hospital HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 NUTRITION AND DIETETICS 250B-DIET-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
NUTRITION AND DIETETICS 609.00 250B-DIET-DDS-01 678
Hospital Staff Dining Room 216.00 250B-DIET-RDS-01 679
Cooking and Baking Area 78.00 250B-DIET-RDS-02 682
Food Preparation Area 37.00 250B-DIET-RDS-03 685
Blenderized and Tube Feeding Area 14.00 250B-DIET-RDS-04 688
Therapeutic Diet Preparation Area 3.00 250B-DIET-RDS-05 691
Serving and Food Assembly Area 20.00 250B-DIET-RDS-06 694
Food Conveyor Parking 22.00 250B-DIET-RDS-07 697
Cold Storage 14.00 250B-DIET-RDS-08 700
Dry Storage 14.00 250B-DIET-RDS-09 703
Storage for Utensils/ Silverware 7.00 250B-DIET-RDS-10 706
Delivery Receiving Area 18.00 250B-DIET-RDS-11 709
Dishwashing and Pots Washing Area 45.00 250B-DIET-RDS-12 712
Waste Holding Area 12.00 250B-DIET-RDS-13 715
Dietitian's Office/ Staff Office 41.00 250B-DIET-RDS-14 718
Nutrition Clinic 14.00 250B-DIET-RDS-15 721
Staff Dining Area 18.00 250B-DIET-RDS-16 724
Staff T&B/ Locker Room 36.00 250B-DIET-RDS-17 727
677
12000 SCALE 1:300 M
HOSPITAL
STAFF
DINING
HALL
18000
FOOD
ASSEMBLY
AREA
9000
3000
BAKING
AREA NUTRITION
CLINIC
6000
FOOD
PREPARATION STAFF
AREA OFFICE
3000
3000
TUBE
THERAPEUTIC
DIET PREP
FEEDING DIETITIAN'S
ROOM
AREA
OFFICE
3000
2050 3000
COLD
CONFERENCE
STORAGE
TRAYS IN
3000
RECEIVING FROM
DRY AREA
STORAGE WARDS
3000
DELIVERY
RECEIVING
AREA
POTS
WASHING
9900
STORAGE
3000
WASTE
ANTE FOR
HOLDING
ROOM UTENSILS/
AREA
SILVERWARE
DISH
FEMALE STAFF WASHING
3000
T&B/LOCKERS
3000
3000
STAFF
DINING
MALE STAFF
T&B/LOCKERS
678
Hospital: Department of Health
679
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
HOSPITAL STAFF
April 2016 NUTRITION & DIETETICS
DINING ROOM
250B-DIET-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Acceptable sound level (db) 70 Accessible hot surface: Baine Marie (food warmer)
Other risks NA
680
NA
681
Hospital: Department of Health
682
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-02B
COOKING AND
April 2016 NUTRITION & DIETETICS
BAKING AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
683
Others NA
684
Hospital: Department of Health
685
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS FOOD PREPARATION AREA 250B-DIET-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
686
NA
687
Hospital: Department of Health
688
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-04B
BLENDERIZED & TUBE
April 2016 NUTRITION & DIETETICS FEEDING AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
689
690
Hospital: Department of Health
691
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-05B
THERAPEUTIC DIET
April 2016 NUTRITION & DIETETICS PREPARATION AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
692
NA
693
Hospital: Department of Health
694
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-06B
SERVING AND FOOD
April 2016 NUTRITION & DIETETICS ASSEMBLY AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
695
NA
696
Hospital: Department of Health
697
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS FOOD CONVEYOR PARKING 250B-DIET-RDS-07B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
698
NA
699
Hospital: Department of Health
700
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS COLD STORAGE 250B-DIET-RDS-08B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
701
NA
702
Hospital: Department of Health
703
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS DRY STORAGE 250B-DIET-RDS-09B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
704
NA
705
Hospital: Department of Health
706
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-10B
STORAGE FOR UTENSILS/
April 2016 NUTRITION & DIETETICS SILVERWARE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
707
NA
708
Hospital: Department of Health
709
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS DELIVERY RECEIVING AREA 250B-DIET-RDS-11B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
710
NA
711
Hospital: Department of Health
712
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-12B
DISHWASHING & POTS
April 2016 NUTRITION & DIETETICS WASHING AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
713
NA
714
Hospital: Department of Health
715
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS WASTE HOLDING AREA 250B-DIET-RDS-13B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
716
NA
717
Hospital: Department of Health
718
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-14B
DIETITIAN'S OFFICE &
April 2016 NUTRITION & DIETETICS
STAFF OFFICE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
719
NA
720
Hospital: Department of Health
721
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS NUTRITION CLINIC 250B-DIET-RDS-15B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
722
NA
723
Hospital: Department of Health
724
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 NUTRITION & DIETETICS STAFF DINING AREA 250B-DIET-RDS-16B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250
SOUND SAFETY
Other risks NA
725
NA
726
Hospital: Department of Health
727
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-DIET-RDS-17B
STAFF T&B/
April 2016 NUTRITION & DIETETICS LOCKER ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
728
NA
729
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
731
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 ENGINEERING, MAINTENANCE & HOUSEKEEPING 250B-ENG-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
ENGINEERING, MAINTENANCE 429.00 250B-ENG-DDS-01 734
& HOUSEKEEPING
Garage, Work, and Parking Areas 135.00 250B-ENG-RDS-01 735
Drivers' Lounge 18.00 250B-ENG-RDS-02 738
Security Office 18.00 250B-ENG-RDS-03 741
Housekeeping Office 18.00 250B-ENG-RDS-04 744
Biomedical Engineering Workshop 36.00 250B-ENG-RDS-05 747
Carpentry Workshop 18.00 250B-ENG-RDS-06 750
Electrical and Mechanical Workshop 36.00 250B-ENG-RDS-07 753
Head's Office 18.00 250B-ENG-RDS-08 756
Staff Office 36.00 250B-ENG-RDS-09 759
Conference Room 18.00 250B-ENG-RDS-10 762
Staff Pantry 18.00 250B-ENG-RDS-11 765
Male Quarters & Lockers 23.00 250B-ENG-RDS-12 768
Male & Female Toilets, and Janitor's Closet 8.00 250B-ENG-RDS-13 771
Storage 18.00 250B-ENG-RDS-14 774
Plumbing Workshop 18.00 250B-ENG-RDS-15 777
733
SCALE 1:300 M
6000
6000
POWER
HOUSE
S E R V I C E Y A R D
7400
PUMP
ROOM
1600
CONFERENCE HEAD'S
6000
6000
CARPENTRY ROOM OFFICE STAFF
WORK MALE PANTRY
WORKSHOP OFFICE
AREA QUARTERS MT
MALE FT
LOCKERS
15000
15000
3000
3000
GARAGE
6000
6000
AMBULANCE DRIVERS' STORAGE HOUSE-
PARKING LOUNGE ROOM SECURITY
MECHANICAL & KEEPING
BIOMEDICAL OFFICE
ELECTRICAL OFFICE
ENGINEERING PLUMBING
WORKSHOP WORKSHOP WORKSHOP
36000
12000
734
Hospital: Department of Health
735
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
ENGINEERING AND GARAGE, WORK &
April 2016 MAINTENANCE PARKING AREAS 250B-ENG-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
736
NA
737
Hospital: Department of Health
738
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-02B
ENGINEERING AND
April 2016 MAINTENANCE DRIVERS' LOUNGE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
739
NA
740
Hospital: Department of Health
741
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-03B
ENGINEERING AND
April 2016 MAINTENANCE SECURITY OFFICE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
742
NA
743
Hospital: Department of Health
744
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-04B
ENGINEERING AND
April 2016 MAINTENANCE HOUSEKEEPING OFFICE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
745
NA
746
Hospital: Department of Health
747
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-05B
ENGINEERING AND BIOMEDICAL ENGINEERING
April 2016 MAINTENANCE WORKSHOP
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
748
NA
749
Hospital: Department of Health
750
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-06B
ENGINEERING AND
April 2016 MAINTENANCE CARPENTRY WORKSHOP
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
751
NA
752
Hospital: Department of Health
753
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-07B
ENGINEERING AND ELECTRICAL & MECHANICAL
April 2016 MAINTENANCE WORKSHOP
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
754
NA
755
Hospital: Department of Health
756
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-08B
ENGINEERING AND
April 2016 MAINTENANCE HEAD'S OFFICE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
757
NA
758
Hospital: Department of Health
759
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-09B
ENGINEERING AND
April 2016 MAINTENANCE STAFF OFFICE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
760
NA
761
Hospital: Department of Health
762
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-10B
ENGINEERING AND
April 2016 MAINTENANCE CONFERENCE ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500-700
SOUND SAFETY
Other risks NA
763
NA
764
Hospital: Department of Health
765
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-11B
ENGINEERING AND
April 2016 MAINTENANCE STAFF PANTRY
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
766
NA
767
Hospital: Department of Health
768
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-12B
ENGINEERING AND
April 2016 MAINTENANCE MALE QUARTERS
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
769
NA
770
Hospital: Department of Health
771
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-13B
ENGINEERING AND
April 2016 MAINTENANCE T&B AND JAN. CLO.
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
772
NA
773
Hospital: Department of Health
774
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-ENG-RDS-14B
ENGINEERING AND
April 2016 MAINTENANCE STORAGE
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
775
NA
776
777
778
3000
9
T
D
7
6000
SD
8 4
6
CH 2
3
779
VOLUME 3
DEPARTMENTAL PLANS and
TECHNICAL REQUIREMENTS
of a 250-BED HOSPITAL (LEVEL 3)
First Edition
DEPARTMENT OF HEALTH
Manila
2017
781
Hospital: Department of Health
SERVICE FACILITY SHEET INDEX
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Service Facility Title: Reference Sheet Number:
April 2016 SUPPORT SERVICE FACILITY 250B-SUP-SFSI-01
SPACE DEMAND TOTAL AREA REFERENCE SHEET
ROOM TITLE PAGE
(SQ. MTS.) (SQ. MTS.) NUMBER
LINEN AND LAUNDRY 172.00 250B-LL-DDS-01 784
Issuing, Office, Work Room, and Storage 68.00 250B-LL-RDS-01 785
Pressing and Ironing Room 41.00 250B-LL-RDS-02 788
Washing/ Drying Room 8.00 250B-LL-RDS-03 791
Receiving/ Sorting/ Disinfection Area 8.00 250B-LL-RDS-04 794
Staff Lockers and T&B 16.00 250B-LL-RDS-05 797
Sewing & Sorting Room 31.00 250B-LL-RDS-06 800
783
784
Hospital: Department of Health
785
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LL-RDS-01B
ISSUING, OFFICE, WORK
April 2016 LINEN AND LAUNDRY ROOM & STORAGE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
786
5200
13
14
3000
SD D
3000
A SD
7 1
2 12
13 11 8 10 8 10
9 9 9
3000
SD C SD B
5 5 7 4 3
7 7
13 14 DT 6 6
12
4000 2000
6000 6000
787
Hospital: Department of Health
788
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LL-RDS-02B
PRESSING AND
April 2016 LINEN AND LAUNDRY IRONING ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
789
NA
790
Hospital: Department of Health
791
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LINEN AND LAUNDRY WASHING/ DRYING ROOM 250B-LL-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
792
NA
793
Hospital: Department of Health
794
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-LL-RDS-04B
RECEIVING/ SORTING/
April 2016 LINEN AND LAUNDRY DISINFECTION AREA
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
795
NA
796
Hospital: Department of Health
797
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LINEN AND LAUNDRY STAFF LOCKERS AND T&B 250B-LL-RDS-05B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
798
5300
2000 3300
2 2 2 3
1500
4
3000
SD
4
1500
1
3
2 2 2 2 2 2
2600 2700
1 LOCKER AREA
2 Lockers, steel
799
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LINEN AND LAUNDRY SEWING & SORTING RM 250B-LL-RDS-06A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Laundry worker examines linen for repair and Trolley, linen 1
tallies number on linen list/inventory Sewing Machine 1
b. Laundry worker repairs torn/damaged linen
by hand and/or using sewing machine
c. Laundry worker folds repaired linen on work
table
d. Repaired linen is transferred to trolley
for transport to Pressing/Ironing Room
800
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 LINEN AND LAUNDRY SEWING & SORTING RM 250B-LL-RDS-06B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
801
5100
6000
SD
3
2
4
1 Table, sorting
2 Table, work
3 Stool, adjustable
4 Machine, sewing
5 Trolley, linen
802
SCALE 1:300 M
12000
6000 6000
12000
LOADING/ STORAGE/ WAREHOUSE
UNLOADING BAY
27000
3000
HAZARDOUS ITEMS
STORAGE
ROOM 6000
3000
TEMPERATURE-
CONTROLLED ISSUING
STORAGE
ROOM
3000
HEAD'S
OFFICE
6000
WORK AREA
3000
MEETING
ROOM
STAFF
3000
3000
803
Hospital: Department of Health
804
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PROPERTY AND SUPPLY STORAGE/ WAREHOUSE 250B-PS-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
805
NA
806
Hospital: Department of Health
807
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PROPERTY AND SUPPLY WORK AREA 250B-PS-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
SOUND SAFETY
Other risks NA
808
NA
809
Hospital: Department of Health
810
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PROPERTY AND SUPPLY HEAD'S OFFICE 250B-PS-RDS-03B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 250-500
Other risks NA
811
NA
812
Hospital: Department of Health
813
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 PROPERTY AND SUPPLY STAFF PANTRY 250B-PS-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
814
NA
815
Hospital: Department of Health
816
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-PS-RDS-05B
STAFF LOCKERS, T&B, AND
April 2016 PROPERTY AND SUPPLY JAN. CLO.
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
817
3000 3000 3000
4 4
1400
GFCI 3 1 3 GFCI
3000
SD
1600
5
6
2 7
1150
1725 1850
2775 1600
2400 1400
2100 1950
2925 1050
1575
818
SCALE 1:300 M
15000
9000 6000
LOCKER &
T&B
TISSUE
J.C. PROCESSING
MORGUE AREA
10000
AUTOPSY
AREA
FAMILY
GRIEVING
ROOM
819
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-MOR-RDS-01A
AUTOPSY & TISSUE
April 2016 MORGUE PROCESSING ROOM
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Pathologist performs autopsy procedure on Table, mayo 1
deceased patients Footstool 1
b. Pathologist performs toileting activites after Suction apparatus 1
procedure Scale 1
Kick bucket 1
Instrument sterilizer, with stand 1
Autotechnicon tissue processor 1
Waste bin w/ yellow lining 1 infectious
Waste bin w/ yellow lining 2 pathological
820
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-MOR-RDS-01B
AUTOPSY & TISSUE
April 2016 MORGUE PROCESSING ROOM
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
821
6000
1500 1500 3000
CH 1 2
3 14
2800
11
SD
1500
13
13
10000
5 6
4
8
9
5700
SD 7
12
3
14
CH 1 2 CH
10
822
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 MORGUE MORGUE 250B-MOR-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of deceased bodies awaiting claim by Refrigerator, mortuary 7
relatives Partition, foldable 2
Waste bin w/ black lining 1 general
823
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 MORGUE MORGUE 250B-MOR-RDS-02B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 500
SOUND SAFETY
Other risks NA
824
9000
2 2 2 2 2
SD SD
7400
10000
3
1
3
SD
2600
2 2
5 4
6 5
7
1 MORGUE
2 Refrigerator, mortuary
3 Partition, foldable
825
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-MOR-RDS-03A
STAFF LOCKERS, T&B
April 2016 MORGUE AND JAN. CLO.
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Morgue staff change clothes in Locker Room Waste bin w/ black lining 1
b. Storing of clothes and personal effects
c. Morgue staff perform toiletting activities in T&B
FURNITURE AND
QUANTITY REMARKS
People Involved: FIXTURE CHECKLIST
1 x Morgue Technician Locker, steel 1
1 x Pathologist Slop sink, with hose bibb faucet 1
1 x Medical Technologist Shelving, open 1
Lavatory 1
Water Closet 1
Shower 1
826
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-MOR-RDS-03B
STAFF LOCKERS, T&B AND
Jan-00 MORGUE JAN. CLO.
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
827
NA
828
829
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 CENTRAL WASTE STORAGE WORK AREA 250B-CWS-RDS-01A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Janitor places waste bins carts/trolleys Weighing scale 1
b. Janitor stores cleaning tools, supplies and PPEs Washer, high pressure 1
c. Janitor cleans/washes the waste bins and Waste bins / carts / trolleys 3
trolleys Fire extinguisher 1
d. Janitor weighs volume of waste
e. Janitor records volume of waste
f. Janitors performs hand washing
830
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 CENTRAL WASTE STORAGE WORK AREA 250B-CWS-RDS-01B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
831
NA
832
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 CENTRAL WASTE STORAGE HAZARDOUS WASTE ROOM 250B-CWS-RDS-02A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
Storage of the following hazardous waste before Waste bins / carts / trolleys 5 yellow
treatment : Exhaust fan 1 above door
a. Infectious Refrigerator 1
b. Sharps
c. Chemical
d. Pharmaceutical
e. Pathological / Anatomical
833
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CWS-RDS-02B
HAZARDOUS WASTE
April 2016 CENTRAL WASTE STORAGE ROOM
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
834
NA
835
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CWS-RDS-03A
MERCURY-CONTAINING
April 2016 CENTRAL WASTE STORAGE DEVICES/LAMPS
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of mercury-containing devices/lamps Exhaust fan 1 above door
before being collected by DENR-accredited TSD
(Treatment/Storage/Disposal) Facility
836
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CWS-RDS-03B
MERCURY-CONTAINING
April 2016 CENTRAL WASTE STORAGE DEVICES/LAMPS
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
837
NA
838
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 CENTRAL WASTE STORAGE BIODEGRADABLE WASTE 250B-CWS-RDS-04A
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of biodegradable waste before being Waste bins / carts / trolleys 3 black
picked up by the local waste transporter Exhaust fan 1 above door
839
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
April 2016 CENTRAL WASTE STORAGE BIODEGRADABLE WASTE 250B-CWS-RDS-04B
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
840
NA
841
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CWS-RDS-05A
NON-BIODEGRADABLE/
April 2016 CENTRAL WASTE STORAGE RECYLABLE WASTE
FUNCTIONAL DESIGN REQUIREMENTS:
This activity space provides facilities needed EQUIPMENT AND
QUANTITY REMARKS
for the following activities: ACCESSORY CHECKLIST
a. Storage of non-biodegradable/recyclable waste Waste bins / carts / trolleys 3 yellow
before being transfered to Material Recovery Facility Exhaust fan 1 above door
or before being subjected for recycling
842
Hospital: Department of Health
ROOM DATA SHEET
250-Bed (Level 3) HEALTH FACILITY
DEVELOPMENT BUREAU
Updated Reference: Department: Room Title: Reference Sheet Number:
250B-CWS-RDS-05B
NON-BIODEGRADABLE/
April 2016 CENTRAL WASTE STORAGE RECYLABLE WASTE
TECHNICAL DESIGN DATA:
ENVIRONMENTAL CONDITIONS DESIGN DATA ENVIRONMENTAL CONDITIONS DESIGN DATA
Outdoor air temperature (°C) ave. local station temp. reading General illumination (LUX) 150
SOUND SAFETY
Other risks NA
843
NA
844
MANUAL on TECHNICAL GUIDELINES for
HOSPITAL PLANNING and DESIGN
250-BED HOSPITAL
(LEVEL 3)
VOLUME 4
APPENDICES
First Edition
DEPARTMENT OF HEALTH
Manila
2017
845
VOLUME 4
APPENDICES
TABLE OF CONTENTS
PAGE
APPENDIX A - EXISTING HOSPITALS 849
847
APPENDIX A
EXISTING HOSPITALS
849
APPENDIX B
Department of Health
Administrative Order No. 2012-0012
“Rules and Regulations Governing the New Classification of Hospitals and
Other Health Facilities in the Philippines”
and
R.A. 4226
“Hospital Licensure Act”
a. ACCORDING TO OWNERSHIP
1. Government Hospital – created by law. A government health
facility may be under the national government, DOH, Local
Government Unit (LGU), Department of National Defense (DND),
Philippine National Police (PNP), Department of Justice (DOJ),
State Universities and Colleges (SUCs), Government Owned and
Controlled Corporations (GOCC) and others.
2. Private Hospital – owned, established and operated with funds
through donation, principal, investment or other means by any
individual, corporation, association or organization. A private
health facility may be a single proprietorship, partnership,
corporation, cooperative, foundation, religious, non-government
organization and others.
b. ACCORDING TO SCOPE OF SERVICES
1. General – a hospital that provides services for all kinds of
illnesses, diseases, injuries or deformities. A general hospital shall
provide medical and surgical care to the sick and injured,
maternity, newborn and childcare. It shall be equipped with the
service capabilities needed to support board certified / eligible
medical specialties and other licensed physicians rendering
services in, but not limited to, the following :
a) Clinical Services
1) Family Medicine
2) Pediatrics
3) Internal Medicine
850
4) Obstetrics and Gynecology
5) Surgery
b) Emergency Services
c) Outpatient Services
d) Ancillary and Support Services such as, Clinical
Laboratory, Imaging Facility and Pharmacy
2. Specialty – a hospital that specializes in a particular disease or
condition or in one type of patient. A specialized hospital may be
devoted to treatment of any of the following :
a) Treatment of a particular type of illness or for a particular
condition requiring a range of treatment
Examples : Philippine Orthopedic Center, National
Center for Mental Health, San Lazaro
Hospital, a hospital dedicated to the treatment
of cancer
b) Treatment of patients suffering from diseases of a
particular organ or group of organs
Examples : Lung Center of the Philippines, Philippine
Heart Center, National Kidney and
Transplant Institute, a hospital dedicated to
the treatment of eye disorders
c) Treatment of patients belonging to a particular group such
as children, women, elderly, and others.
Examples : Philippine Children’s Hospital, Dr. Jose
Fabella Memorial Hospital
c. ACCORDING TO FUNCTIONAL CAPACITY
1. General Hospital
a) Level 1
A Level 1 hospital shall have as a minimum the services
stipulated under Rule V.B.1.b.1. of this Order, including,
but not limited to, the following:
1) A staff of qualified medical, allied medical and
administrative personnel headed by a physician
duly licensed by the Professional Regulatory
Commission (PRC);
851
2) Bed space for its authorized bed capacity in
accordance with DOH Guidelines in the Planning
and Design of Hospitals;
3) An Operating Room with standard equipment and
provision for sterilization of equipment and
supplies in accordance with:
a. DOH Reference Plan in the Planning and
Design of an Operating Room/Theater (Annex
A)
b. DOH Guidelines on Cleaning, Disinfection
and Sterilization of Reusable Medical Devices
in Hospital Facilities in the Philippines
(Annex B)
4) A Post-Operative Recovery Room;
5) Maternity facilities, consisting of ward(s), room(s),
a Delivery Room, exclusively for maternity
patients and newborns;
6) Isolation facilities with proper procedures for the
care and control of infectious and communicable
diseases as well as for the prevention of cross
infections;
7) A separate dental section/clinic;
8) Provision for blood station;
9) A DOH licensed Secondary Clinical Laboratory
with the services of a consulting Pathologist;
10) A DOH licensed Level 1 Imaging Facility with the
services of a consulting Radiologist; and
11) A DOH licensed Pharmacy.
b) Level 2
A Level 2 hospital shall have as a minimum, all of Level 1
capacity, including, but not limited to, the following:
1) An organized staff of qualified and competent
personnel with Chief of Hospital/Medical Director
and appropriate board certified Clinical
Department Heads;
2) Departmentalized and equipped with the service
capabilities needed to support board
certified/eligible medical specialists and other
licensed physicians rendering services in the
specialties of Medicine, Pediatrics, Obstetrics and
Gynecology, Surgery, their subspecialties and
ancillary services;
852
3) Provision for general ICU (Intensive Care Unit) for
critically ill patients;
4) Provision for NICU (Neonatal Intensive Care
Unit);
5) Provision for HRPU (High-Risk Pregnancy Unit);
6) Provision for respiratory therapy services;
7) A DOH licensed Tertiary Clinical Laboratory;
8) A DOH licensed Level 2 Imaging Facility with
Mobile X-Ray inside the institution and with
capability for contrast examinations.
c) Level 3
A Level 3 hospital shall have as a minimum, all of Level 2
capacity, including, but not limited to, the following:
1) Teaching and/or training hospital with accredited
residency training program for physicians in the
four (4) major specialties namely: Medicine,
Pediatrics, Obstetrics and Gynecology, and
Surgery;
2) Provision for Physical Medicine and Rehabilitation
Unit;
3) Provision for Ambulatory Surgical Unit;
4) Provision for Dialysis facility;
5) Provision for Blood Bank;
6) A DOH licensed Tertiary Clinical Laboratory with
standard equipment/reagents/supplies necessary for
the performance of histopathology examinations;
7) A DOH licensed Level 3 Imaging facility with
interventional Radiology.
2. Specialty Hospital (refer to Rule V.B.1.b.2. of this Order)
3. Trauma Capability of Hospitals
The trauma capability of hospitals shall be assessed in accordance
with the guidelines formulated by the Philippine College of
Surgeons (PCS).
a) Trauma-Capable Facility – a DOH licensed hospital
designated as a Trauma Center.
b) Trauma-Receiving Facility – a DOH licensed hospital
within the trauma service area which received trauma
patients for transport to the point of care or a trauma center.
853
APPENDIX C
Patient care areas, classified as follows, shall be those areas designated by the
governing body of the health care facility in accordance with the type of patient
care anticipated:
854
APPENDIX D
“Health care Waste” (HCW) includes all the solid and liquid waste generated
as a result of any of the following :
“Healthcare Facilities” (HCF), for this purpose, are public, private and non-
governmental institutions/facilities that contribute to the improvement of the
health status of an individual.
A. Infectious
- All waste suspected to contain pathogens (or their toxins) in sufficient
concentration to cause diseases to a potential host.
- Discarded materials or equipment used for diagnosis, treatment and
prevention of disease of patients with infectious disease.
- Highly infectious waste include microbial cultures and stocks of
highly infectious agents from Medical Analysis Laboratories and
biofluids from patients with highly infectious diseases (these require
disinfection at source)
Examples : Solid wastes from patients with infectious disease (e.g.,
dressings, swabs, blood bag, urine bag, sputum cup); Liquid
wastes from patients with infectious disease (e.g., feces,
urine, blood or other body secretions); Food wastes (liquid
or solid) of patients with highly infectious disease.
B. Sharps
- Items that can cause cuts or puncture wounds.
Examples : Used or expired sharps (e.g., hypodermic, intravenous or
other needles, auto-disable syringes, syringes with attached
needles, infusion sets, scalpels, pipettes, knives, blades,
broken glass, wet ampoules); Except syringes and needles
used for antineoplastic purposes
855
C. Pathological and Anatomical
- Refers to tissue sections and body material derived from biopsies or
surgical procedures that are then examined in the laboratory.
- Anatomical waste is a subgroup of pathological waste. This type of
waste refers to recognizable human body parts such as amputated
limbs, etc.
Examples : Placenta, internal organs, tissues used for diagnostic
procedures such as biopsy, blood, fetus; Amputated body
parts like legs.
D. Pharmaceutical
- Refers to expired, spilt and contaminated pharmaceutical products,
drugs and vaccines. Also refers to discarded items used in handling
pharmaceuticals.
- Pharmaceuticals wastes include antineoplastic, cytotoxic, and
genotoxic waste. Drugs usually used in oncology (antineoplastic
drugs) or radiotherapy units have a high hazardous mutagenic or
cytotoxic effect.
Examples : Empty vials, bottles, connective tubing; Medical supplies
and containers of cytotoxic drugs or chemicals
E. Chemical
- Discarded chemicals (solid, liquid, or gaseous) generated during
disinfecting and sterilizing procedures
- Chemical wastes can be further classified into corrosive, reactive,
toxic and flammable
- Chemical wastes also include wastes with high content of heavy
metals and their derivatives
Examples : Laboratory reagents, film developer, disinfectants and
soaking solutions, solvents; Concentrated ammonia
solutions, concentrated hydrogen peroxide chlorine, silver
nitrate; Cadmium, mercury from broken thermometers,
sphygmomanometers
F. Radioactive
- Wastes exposed to radionuclide. Residues from shipment of
radioactive materials and unwanted solution of radionuclide intended
for diagnostic or therapeutic use.
856
- Liquids, gas and solids contaminated with radionuclide whose
ionizing radiations have genotoxic effects.
Examples : Cobalt (60 Co), Technetium (99 Tc), Iodine (131 I)), and
Iridium (192 Ir); Contaminated waste, patient’s excretion
and all materials used by patients exposed with radionuclide
within 48 hours
G. Non-Hazardous or General
- Waste that has not been in contact with communicable or infectious
agents, hazardous chemicals or radioactive substances, and does not
pose a hazard.
Examples : Paper, cardboard, empty bottle, tetra pack, scrap material,
pressurized containers, office waste, food waste and other
materials of patients with non-communicable disease, X-Ray
plates.
857
REFERENCES
CROSS-REFERENCES
859