Professional Documents
Culture Documents
RGB Nqa-2400
RGB Nqa-2400
Connect the RGB output cable to display the video on the external monitor.
Items to be prepared
y External monitor connection cable
y Monitor connected
[Required tools]
y A Phillips screwdriver for 3 mm screws
Note:
The video is not displayed with the JRC's monitor NWZ-146.
Currently, we have confirmed that the video is displayed with NWZ-164 and
NWZ-173.
[Mounting]
1 Refer to the Field Service Manual to remove the display unit cover and
the I/F circuit CMH-2235.
2 Remove the following 4 screws that secure the operation circuit
CCK-991.
3 Remove the cable between the processing circuit CDC-1346BR and
the I/F circuit CQC-1262.
3. Disconnect the
cable
2. Remove the
screws
1/10 7ZPRD0893
4 Fix the plate for securing board as shown in the figure with the 4
supplied tapping screws.
5. Longer cable.
Connect the end close to
the bending position to
the processing circuit.
5. Shorter cable.
Connect the end close
to the bending position
to the I/F circuit.
2/10 7ZPRD0893
6 Fix the I/F circuit CMH-2383 to the plate using the 4 supplied screws.
7 Connect the cable which has been connected to the LCD_I/F circuit to
the connector on the edge side of the I/F ciucuit CMH-2383 board.
8 Connect the cable which has been connected to the processing circuit
to the middle connector of the I/F circuit CMH-2383 board, and fix the
cable to the LCD fixing plate using the supplied tape.
Note:
The cable is easily disconnected. Therefore, check if the connector is firmly locked
and the cable is securely connected.
3/10 7ZPRD0893
9 Reassemble the I/F circuit CMH-2235 following the disassembly
procedure in the reverse order.
4/10 7ZPRD0893
11 Drag the RGB cable out through the hole for fuse replacement.
5/10 7ZPRD0893