Professional Documents
Culture Documents
Diagnostic Test in Crop Production
Diagnostic Test in Crop Production
Department of Education
REGION III
DIVISION OF BATAAN
City of Balanga
Kto12 Technology and Livelihood Education
Diagnostic Test in
AGRICULTURAL CROP PRODUCTION
I. MULTIPLE CHOICE
Directions: Read the following questions carefully and encircle the best answer.
4. What equipment is used to pull a plow and horrow large area of land?
A. Tiller C. Hand Tractor
B. Truck D. Hand Drill
5. A type of tractor used to pull disc plow and disk horrow in preparing much bigger land?
A. Hand Tractor C. Excavator
B. Jeep D. Four Wheel Tractor
8. An open container with a single wheel at the front and two handles at the back used to
transport things
A. Hand tractor C. Basket
B. Tractor D. Wheel barrow
II. TRUE OR FALSE: Directions: Read and analyze each statement below .Write True if the statement
is correct; False if the statement is incorrect on the space provided for.
______12. The best way to use the stone is to find a way to stabilize the tool that you want to work on.
______13. Clean accumulated rust and dirt off all metal surfaces with a wire brush.
III. Find the area: Directions: Using the given data below, compute the total land area in hectare.
IV. Convert: Directions: Using the given data below, convert the following
17. 1m=____cm
18. 400cm=_____m
19. 5km=______m
28. It is the potential for harm, or adverse effect on an employee’s health. Anything which
may cause injury or ill health to anyone at or near a workplace
a. .Chemicals
b. Exposure
c. Risk
d. Hazard
29. It is the likelihood that a hazard will cause injury or ill health to anyone at or near a
workplace.
a. Risk
b. Exposure
c. Hazard
d. .Chemicals
30. This occurs when a person comes into contact with a hazard.
a. Risk
b. Exposure
c.. Hazard
d. . Chemicals
Read the questions carefully and select the best answer by writing only the letter of your choice on
a separate sheet of paper.
4. What equipment is used to pull a plow and horrow large area of land?
A. Tiller
B. Truck
C. Hand Tractor
D. Hand Drill
5. A type of tractor used to pull disc plow and disk horrow in preparing much bigger land?
A. Hand Tractor
B. Jeep
C. Excavator
D. Four Wheel Tractor
6. What equipment is used to draw irrigation water from a source?
A. Water tank
B. Water pumps
C. Water hose
D. Sprinkler
7. Which of the following tools is used to harvest crops?
A. Knife
B. Plow
C. Spade
D. Basket
8. An open container with a single wheel at the front and two handles at the back used to
transport things
A. Hand tractor
B. Tractor
C. Basket
D. Wheel barrow
KEY TO CORRECTION
C, D, B, A, D
TRUE OR FALSE: Read and analyze each statement below .Write True if the statement is correct;
False if the statement is incorrect on the space provided for.
______10. Tools that are worn out should be separated and be fixed immediately to avoid accident.
(T)
______ 11. When sharpening tools, try to maintain the original factory bevel or angle.(T)
______12. The best way to use the stone is to find a way to stabilize the tool that you want to
work on.(T)
______13. Clean accumulated rust and dirt off all metal surfaces with a wire brush.(T)
17. 1m=____cm
18. 400cm=_____m
19. 5km=______m
KEY TO CORRECTION
CONVERT
17. 100 CM
18. 4 m
19. 5000 m
28. It is the potential for harm, or adverse effect on an employee’s health. Anything which
may cause injury or ill health to anyone at or near a workplace
a. .Chemicals
b. Exposure
c. Risk
d. Hazard
29. It is the likelihood that a hazard will cause injury or ill health to anyone at or near a
workplace.
a. Risk
b. Exposure
c. Hazard
d. .Chemicals
30. This occurs when a person comes into contact with a hazard.
a. Risk
b. Exposure
c.. Hazard
d. . Chemicals
KEY TO CORRECTION
28. d
29. a
30. b