Professional Documents
Culture Documents
SEKN5013 DT T Adp
SEKN5013 DT T Adp
SEKN5013 DT T Adp
1 of 2
Common Rail type engines are being equipped with sensors and solenoids characteristic to
common rail type engines such as the G. sensor, fuel pressure sensor and PCV solenoid. These
sensors and solenoids are important parts of the common rail system and if their terminal pins are
directly touched by the probe of a circuit tester when conducting trouble shooting, the terminal pin
may be deformed to cause imperfect contact. To repair such imperfect contacts, it becomes
necessary to replace the sensor or the solenoid themselves and, in some cases, it becomes
necessary to replace the fuel pump in whole.
This PARTS & SERVICE OPERATION TIPS will introduce the T-junction adaptor and socket newly
prepared and registered to prevent exertion of damages to the connector pins at times of conduct-
ing trouble shooting work and to facilitate the trouble shooting work itself.
1. Part numbers
799-601-9420
799-601-9430
3. How to use
Using method is same as that of the existing T-junction adaptors.
1) The photograph at right shows the status
being connected to the fuel pressure
sensor. Photograph of the status being
connected to the boost pressure sensor
is omitted here.
2) The photographs below and at right show the statuse being connected to the NE sensor
and the G. sensor.
G. sensor
NE sensor
3) The photograph shows the status being 4) The photograph shows the scene of
connected to the connector of the PCV making conduction checks using a circuit
solenoid. tester.
PCV solenoid
July 2001
Customer Support Division