Professional Documents
Culture Documents
Adhesive Brochure PDF
Adhesive Brochure PDF
Disclaimer:
No part of this material may be reproduced or
copied in any form or by any means (graphics,
electronic or mechanical, including photocopying,
recording, taping or information storage retrieval
system) or reproduced in any disc, tape, perforated
media or other information storage device etc.
without the written permission of Asian Paints Ltd.
All rights reserved. Copyright Asian paints Ltd.
All disputes are subject to Mumbai jurisdiction only.
Loctite is a registered trademark of Henkel and/or
its affiliates in the U.S., Germany or elsewhere.
KAAM
PE R F ECT TOH
NAAM PE R F ECT.
At Asian Paints, we believe in a
job done to perfection. This is why
we’ve carefully designed our range
of adhesives to help carpenters
and contractors achieve perfection
in their craft. With more working
time, water and heat resistance
and high bond strength at hand,
these adhesives ensure they never
risk delivering shoddy work.
After all, ours is a business where
the work speaks for itself.
CONSUMERS
MASONS
PLASTICS GLASS RUBBER
Clean and dry surfaces Screw the nozzle clockwise Apply adhesive
to be bonded. to pierce the metal seal. to one surface only.
SHELF LIFE : 6 months from the date of manufacture for 0.5 gm, and 12 months for rest of the SKUs.
Conditions for safe storage, including any incompatibilities - 18 C to 25 C.
GLASS WORKERS
CARPENTERS
STONE WOOD METAL
STONE WORKERS
PLUMBERS
PLASTICS GLASS
Push plunger to dispense Apply to both surfaces and Reseal syringe with stopper after use.
both parts and mix together. clamp together tightly to set. Avoid reverse fitting the stopper.
GLASS WORKERS
STONE WORKERS
PLASTICS GLASS
Push plunger to dispense Apply to both surfaces and Reseal syringe with stopper after use.
both parts and mix together. clamp together tightly to set. Avoid reverse fitting the stopper.
CARPENTERS
PLASTICS GLASS
Press the two surfaces together Re-seal the syringe and Avoid interchange of resin
and clamp them tightly to set. the resin-hardener jars and hardener jar lids to
with the stopper and prevent contamination.
lids respectively.
CARPENTERS
Press/clamp both surfaces After use, cover the jar with the lid
with sufficient pressure to set. and store in a cool dry place.
Additional : Freshly applied TruGrip can be cleaned with lukewarm water. Dried TruGrip can be cleaned
with acetone.
CARPENTERS
24
HOURS
Wait for the adhesive Apply to both surfaces and Cure for 24 hrs
to get touch dry clamp together tightly to set. at ambient temperature
FLEX WORKERS
PLASTICS RUBBER
Clean and dry surfaces Sand the substrate Twist the cap to open nozzle.
to be bonded with emery paper Tilt bottle and squeeze
to dispense adhesive
Apply adhesive on the After use, tap the bottle to allow Store in a cool, dry
corners of the frame the adhesive in nozzle to settle down place in an upright
in the bottle before replacing the cap position
CONSUMERS
PAINTERS
Clean and dry the surface Apply the tape on the edges of After painting, gently remove
where the tape has to be used. the surface to be painted so that the tape and dispose.
the tape acts as a border for
the surface.
Once stuck together, secure both the After drying, gently remove
substrates with masking tape. Optionally, the tape and dispose.
place a heavy object on the surface.
TESTED & CERTIFIED