Professional Documents
Culture Documents
Vehicle Ignition Using Rfid and Finger Print
Vehicle Ignition Using Rfid and Finger Print
Objective:
The objective of our project is RFID and finger print based Vehicle
ignition control system.
Brief methodology:
This project is based on
Micro controller
RFID Reader
Finger print sensor
RS 232
Lcd display
Relay driver unit
Mechanical model
In this system, Microcontroller will control all the section in the system.
Fingerprint sensor is used to sense the Finger thump impression which is
connected to the Microcontroller. RFID Reader is used to read the information
stored in the RFID Tag. RS232 is used for serial communication which is interface
between the Fingerprint sensor and the Microcontroller. The thump impression
should be register in the Sensor. Then impression will be scanned by the sensor
and also RFID Reader will read the stored information, if it is matched the
controller will control the ignition with the help of Relay driver unit which is
connected with the Microcontroller. If the verification is mismatch, the Buzzer will
get alarmed for indication which is connected to the Relay driver unit. LCD
Display is used to display the information about the system which is connected
directly to the Microcontroller.
Advantages:
This system is very useful to avoid the Theft for Vehicles.
Easy to implement.
Application:
It is very useful for Apartments, Office, Public Sectors etc.,
BLOCK DIAGRAM:
LCD Display
Display Driver
Finger
RS232 RELAY VEHICLE
print
DRIVER
Scanner
Microcontroller
RELAY BUZZER
DRIVER
RFID
READER