Professional Documents
Culture Documents
IMO Katalog 2015 Web Low
IMO Katalog 2015 Web Low
IMO Katalog 2015 Web Low
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
2
CONTENTS
Materials 3
Custom made signs 3
How to order / size codes 4
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
3
MATERIALS
20 60
Switch Board
1
Offshore signage
3 mm sandwich plates
Offshore signage
3 mm sandwich plates 2 Fire plan
1
ensure accuracy of personal details). Platform Alarm(PAPA) visual lamp frequency over PAGA speakers. • OIM to initiate PAPA alarm and start crew Station.
Visitor and personnel who have not been on the platform within the past 6 months evacuation after muster completed.
will be directed to the HSE Officer to receive Platform Safety induction. 6. PREPARE TO ABANDON PLATFORM
General Platform Yellow flashing light or rotating intermittent audible signal of constant • Fire/gas leak or other serious situation
Upon hearing the Prepare to Abandon Platform Alarm all personnel shall
2. MUSTER DUTIES Alarm(GPA) visual lamp frequency. (1s on, 1s off) • Go to Muster station
stop work and, leaving work site in a safe secure condition, proceed to the
Check with HSE Officer to find out if you have special duties in case of free fall life boat(FFLB) Station (unless otherwise directed) wearing PPE's,
emergencies. Details of such duties assigned to individuals are set out in the the Alert Two level audible tone on PA system • Important announcement to follow on PA and Lifejacket. If access to the FFLB is impossible then make your
Emergency Procedures Manual. system way to the nearest Liferaft available. DO NOT launch until ordered to
In particular, the following persons are responsible for the following tasks: abandon platform by the OIM.
PLATFORM The Designated Muster Checker shall make a check of the Living Quarters
a) Closing of production wells OIM and Field production Supervisor NORTH to make sure all personnel are alerted and Quarters vacated.
2
to drilling would be responsibility of LIFEBOAT AT If you see a "Man Overboard" throw a Lifebuoy to him and shout "Man
Drilling Supervisor and Drill Crew) DRILLING DECK Overboard" Activate a Manual Alarm Callpoint. Point at him all the
time and get others to ring TEL: _____to start the rescue procedure. Keep
f) Extinction of fire Emergency Response Team pointing at the man to keep him in sight and TELL others to do the same.
j) Helicopter Operation Helicopter Landing Officer 11. PROTECTIVE CLOTHING AND EQUIPMENT
Outside the Accomodation Module all personnel will wear approved safety
CAPPING BEAM
k) Medical/First Aid First Aiders glasses, safety helmets and safety boots and coveralls.
In addition extra approved safety equipment may be specified in certain
l) Rescue Duties Emergency Response Team areas for certain tasks by your supervisor or the HSE Officer.
4. LIFEJACKETS
UP
Lifejackets are located near Liferafts and in the Muster Area. Familiarise yourself
with the instructions for wearing the Lifejacket. DN
DN
1
Denfoil Maritime Denfoil Safety
Skovalleen 24 Knapstadveien 24
4800 Nykøbing Falster 1550 Hølen
Phone: +45 5485 9692
post@denfoil.com
Denmark
2 Phone: +47 2164 1000
post@denfoil.no
Norway
Every care has been taken in preparing this publication. However, in the interests of product development and compliance with the latest regula-
tions we reserve the right to alter the design and specification of the products as necessary. Many of the products shown in this publication and
the catalogue it self are coveres by copyright and may not be reproduced in part or in whole without the written permission of Nordic DENFOIL
ApS. - Copyright Nordic DENFOIL ApS.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
4
HOW TO ORDER
1. Choose material V
2. Choose design 106.225 Wear
3. Choose sign size HR helmet
MATERIALS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
5
IMO SYMBOLS
2 3
depend on the type of survival
Photoluminescent vinyl 103.022 PV MM Photoluminescent vinyl 103.023 PV MM
Photoluminescent rigid 103.022 PR MM Photoluminescent rigid 103.023 PR MM
Station number Station number craft and lauching appliances
provided on board the ship.
103.024 NON-IMPA 103.025 NON-IMPA
Materials Item no. Materials Item no.
4 5 RECOMMENDED SYMBOLS
Photoluminescent vinyl 103.024 PV MM Photoluminescent vinyl 103.025 PV MM
Photoluminescent rigid 103.024 PR MM Photoluminescent rigid 103.025 PR MM
Station number Station number INDICATING THE
LOCATIONS OF EMERGENCY
103.026 NON-IMPA 103.027 NON-IMPA
EQUIPMENT AND MUSTER AND
Materials Item no. Materials Item no.
6 7 EMBARKATION STATIONS
Photoluminescent vinyl 103.026 PV MM Photoluminescent vinyl 103.027 PV MM
Photoluminescent rigid 103.026 PR MM Photoluminescent rigid 103.027 PR MM
Station number Station number
8 9
Photoluminescent vinyl 103.028 PV MM Photoluminescent vinyl 103.029 PV MM Photoluminescent vinyl 103.030 PV MM
Photoluminescent rigid 103.028 PR MM Photoluminescent rigid 103.029 PR MM Photoluminescent rigid 103.030 PR MM
Station number Station number Station number
Lifebuoy with line Lifebuoy with light Lifebuoy with light and line
Lifebuoy with smoke and light Lifebuoy with smoke, light and Lifejacket
line
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
6
Childs lifejacket Medical locker Infants lifejacket Survival craft distress signal
EXIT
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
7
IMO SYMBOLS
IMO SYMBOLS
103.001 IMPA 33.5105 103.002 IMPA 33.5103 103.003 IMPA 33.5104
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 103.001 PV MM Photoluminescent vinyl 103.002 PV MM Photoluminescent vinyl 103.003 PV MM
Photoluminescent rigid 103.001 PR MM Photoluminescent rigid 103.002 PR MM Photoluminescent rigid 103.003 PR MM
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
8
AES
Photoluminescent vinyl 103.081 PV MM Photoluminescent vinyl 103.082 PV MM Photoluminescent vinyl 103.084 PV MM
Photoluminescent rigid 103.081 PR MM Photoluminescent rigid 103.082 PR MM Photoluminescent rigid 103.084 PR MM
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
9
Exit
103.124 PR MM Photoluminescent rigid
Scramble net
103.126 PR MM
VDR Photoluminescent rigid
VDR
103.127 PR MM
SL
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 103.132 PV MM Photoluminescent vinyl 103.133 PV MM SAFETY Photoluminescent vinyl 104.330 PV MM
RESCUE BOAT Photoluminescent rigid 103.132 PR MM Photoluminescent rigid 103.133 PR MM Photoluminescent rigid 104.330 PR MM
Max. 2 persons
during lowering
and recovery Rescue boat max. 2 persons Safety Locker PLAN Safety Plan
NEED A
CUSTOM
MADE SIGN?
Handflare
CALL US
DENMARK NORWAY
+45 5485 9692 +47 2164 1000
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
10
EMERGENCY SIGNS
EMERGENCY SIGNS SOLAS, Chapter ll-2 Regulation 28.1.10
requires that all escape route signs and fire
equipment location markings shall be of pho-
toluminescent material or marked by lighting.
102.001 IMPA 33.4171 102.002 IMPA 33.4173
102.004 IMPA 33.4188 102.005 IMPA 33.4181 102.006 IMPA 33.4177 102.007 IMPA 33.4182
102.008 IMPA 33.4178 102.009 IMPA 33.4179 102.010 IMPA 33.4176 102.011 IMPA 33.4172
102.012 IMPA 33.4183 102.013 NON-IMPA 102.016 IMPA 33.4174 102.017 IMPA 33.4184
102.018 IMPA 33.4185 102.019 IMPA 33.4186 102.020 IMPA 33.4187 102.021 NON-IMPA
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.018 PV HR Photoluminescent vinyl 102.019 PV HR Photoluminescent vinyl 102.020 PV HR Photoluminescent vinyl 102.021 PV HR
Photoluminescent rigid 102.018 PR HR Photoluminescent rigid 102.019 PR HR Photoluminescent rigid 102.020 PR HR Photoluminescent rigid 102.021 PR HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
11
EMERGENCY
EMERGENCY SIGNS
102.026 NON-IMPA 102.027 NON-IMPA 102.028 NON-IMPA 102.029 NON-IMPA
Lifejacket Medical
Defibrillator Hospital
SIGNS
under seats Grab Bag AED
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.026 PV HR Photoluminescent vinyl 102.027 PV HR Photoluminescent vinyl 102.028 PV HR Photoluminescent vinyl 102.029 PV HR
Photoluminescent rigid 102.026 PR HR Photoluminescent rigid 102.027 PR HR Photoluminescent rigid 102.028 PR HR Photoluminescent rigid 102.029 PR HR
102.200 IMPA 33.4175 102.201 IMPA 33.4180 102.202 NON-IMPA 102.203 IMPA 33.4193
First aiders
Safe for Drinking
entry
Resuscitator
water
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.200 PV HR Photoluminescent vinyl 102.201 PV HR Photoluminescent vinyl 102.202 PV HR Photoluminescent vinyl 102.203 PV HR
Photoluminescent rigid 102.200 PR HR Photoluminescent rigid 102.201 PR HR Photoluminescent rigid 102.202 PR HR Photoluminescent rigid 102.203 PR HR
Medical grab bag Medical grab bag Hospital Hospital General alarm General alarm
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
12
DIRECTION SYMBOLS
100.001 NON-IMPA 100.002 IMPA 33.4411 100.003 NON-IMPA 100.004 IMPA 33.4401
100.005 IMPA 33.4402 100.006 IMPA 33.4403 100.007 IMPA 33.4404 100.008 IMPA 33.4405
100.009 IMPA 33.4406 100.010 IMPA 33.4407 100.011 NON-IMPA 100.012 IMPA 33.4409
100.111 IMPA 33.4340 100.113 NON-IMPA 100.114 IMPA 33.4342 100.117 IMPA 33.4343
FIRE EXIT
Escape route Keep clear
Escape hatch Escape door
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.111 PV MS Photoluminescent vinyl 100.113 PV MS Photoluminescent vinyl 100.114 PV MS Photoluminescent vinyl 100.117 PV MS
Photoluminescent vinyl 100.111 PV HR Photoluminescent vinyl 100.113 PV HR Photoluminescent vinyl 100.114 PV HR Photoluminescent vinyl 100.117 PV HR
100.118 IMPA 33.4344 100.090 NON-IMPA 100.091 NON-IMPA 100.092 IMPA 33.4341
100.093 IMPA 33.4825 100.094 IMPA 33.4824 100.095 IMPA 33.4345 100.125 IMPA 33.4821
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
13
DIRECTION SIGNS
100.050 NON-IMPA 100.055 IMPA 33.4321 100.060 NON-IMPA 100.065 IMPA 33.4301
ASSEMBLY ASSEMBLY
STATION STATION LIFEBOAT LIFEBOAT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.050 PV HR Photoluminescent vinyl 100.055 PV HR Photoluminescent vinyl 100.060 PV HR Photoluminescent vinyl 100.065 PV HR
100.051 IMPA 33.4322 100.056 IMPA 33.4323 100.061 IMPA 33.4302 100.066 IMPA 33.4303
ASSEMBLY ASSEMBLY
STATION STATION LIFEBOAT LIFEBOAT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.051 PV HR Photoluminescent vinyl 100.056 PV HR Photoluminescent vinyl 100.061 PV HR Photoluminescent vinyl 100.066 PV HR
100.052 IMPA 33.4324 100.057 IMPA 33.4325 100.062 IMPA 33.4304 100.067 IMPA 33.4305
ASSEMBLY ASSEMBLY
STATION STATION LIFEBOAT LIFEBOAT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.052 PV HR Photoluminescent vinyl 100.057 PV HR Photoluminescent vinyl 100.062 PV HR Photoluminescent vinyl 100.067 PV HR
100.053 IMPA 33.4326 100.058 IMPA 33.4327 100.063 IMPA 33.4306 100.068 IMPA 33.4307
ASSEMBLY ASSEMBLY
STATION STATION LIFEBOAT LIFEBOAT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.053 PV HR Photoluminescent vinyl 100.058 PV HR Photoluminescent vinyl 100.063 PV HR Photoluminescent vinyl 100.068 PV HR
100.054 NON-IMPA 100.059 IMPA 33.4329 100.064 NON-IMPA 100.069 IMPA 33.4309
ASSEMBLY ASSEMBLY
STATION STATION LIFEBOAT LIFEBOAT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.054 PV HR Photoluminescent vinyl 100.059 PV HR Photoluminescent vinyl 100.064 PV HR Photoluminescent vinyl 100.069 PV HR
100.122 IMPA 33.4480 100.121 IMPA 33.4481 102.014 IMPA 33.4483 102.015 IMPA 33.4482
100.031 NON-IMPA 100.030 NON-IMPA 100.126 IMPA 33.4415 100.127 IMPA 33.4417
EXIT
EXIT For
emergency
use only
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.031 PV MR Photoluminescent vinyl 100.030 PV MR Photoluminescent vinyl 100.126 PV MR Photoluminescent vinyl 100.127 PV MR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
14
DIRECTION SIGNS
109.030 NON-IMPA
Materials Item no.
Photoluminescent alu 109.030 PA NN
WANT TO ORDER
ONLINE?
Visit our website here
www.denfoil.com
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
15
DIRECTION SIGNS
100.040 IMPA 33.4200 100.041 IMPA 33.4201 100.042 IMPA 33.4202
0 1 2
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.040 PV ME Photoluminescent vinyl 100.041 PV ME Photoluminescent vinyl 100.042 PV ME
Photoluminescent rigid 100.040 PR ME Photoluminescent rigid 100.041 PR ME Photoluminescent rigid 100.042 PR ME
Photoluminescent vinyl 100.040 PV RM Photoluminescent vinyl 100.041 PV RM Photoluminescent vinyl 100.042 PV RM
Photoluminescent rigid 100.040 PR RM Photoluminescent rigid 100.041 PR RM Photoluminescent rigid 100.042 PR RM
3 4 5
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.043 PV ME Photoluminescent vinyl 100.044 PV ME Photoluminescent vinyl 100.045 PV ME
Photoluminescent vinyl 100.043 PR ME Photoluminescent rigid 100.044 PR ME Photoluminescent rigid 100.045 PR ME
Photoluminescent vinyl 100.043 PV RM Photoluminescent vinyl 100.044 PV RM Photoluminescent vinyl 100.045 PV RM
Photoluminescent rigid 100.043 PR RM Photoluminescent rigid 100.044 PR RM Photoluminescent rigid 100.045 PR RM
6 7 8
Photoluminescent vinyl 100.046 PV ME Photoluminescent vinyl 100.047 PV ME Photoluminescent vinyl 100.048 PV ME
Photoluminescent rigid 100.046 PR ME Photoluminescent rigid 100.047 PR ME Photoluminescent rigid 100.048 PR ME
Photoluminescent vinyl 100.046 PV RM Photoluminescent vinyl 100.047 PV RM Photoluminescent vinyl 100.048 PV RM
Photoluminescent rigid 100.046 PR RM Photoluminescent rigid 100.047 PR RM Photoluminescent rigid 100.048 PR RM
A B
Materials Item no. Materials Item no. Materials Item no.
9
Photoluminescent vinyl 100.049 PV ME Photoluminescent vinyl 100.075 PV ME Photoluminescent vinyl 100.076 PV ME
Photoluminescent rigid 100.049 PR ME Photoluminescent rigid 100.075 PR ME Photoluminescent rigid 100.076 PR ME
Photoluminescent vinyl 100.049 PV RM Photoluminescent vinyl 100.075 PV RM Photoluminescent vinyl 100.076 PV RM
Photoluminescent rigid 100.049 PR RM Photoluminescent rigid 100.075 PR RM Photoluminescent rigid 100.076 PR RM
C D E
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 100.077 PV ME Photoluminescent vinyl 100.078 PV ME Photoluminescent vinyl 100.079 PV ME
Photoluminescent rigid 100.077 PR ME Photoluminescent rigid 100.078 PR ME Photoluminescent rigid 100.079 PR ME
Photoluminescent vinyl 100.077 PV RM Photoluminescent vinyl 100.078 PV RM Photoluminescent vinyl 100.079 PV RM
Photoluminescent rigid 100.077 PR RM Photoluminescent rigid 100.078 PR RM Photoluminescent rigid 100.079 PR RM
F
Materials Item no.
Photoluminescent vinyl 100.080 PV ME
Photoluminescent rigid 100.080 PR ME Materials Size codes
Photoluminescent vinyl 100.080 PV RM
Photoluminescent rigid 100.080 PR RM PV : Photoluminescent self adhesive vinyl E : 75 mm.
PR : Photoluminescent rigid PVC H : 100 mm.
M : 200 mm.
N : 150 mm.
R : 300 mm.
S : 400 mm.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
16
Fire Fire
extinguisher extinguisher
EXIT EXIT
EXIT EXIT
EXIT EXIT
60 x 60 mm. 130.038
60 x 60 mm. 130.039
IMPA 33.2386
60 x 60 mm. 130.040 Materials Item no.
60 x 60 mm. 130.041 150 x 50 mm. 130.057
60 x 60 mm. 130.042
I
60 x 60 mm. 130.043
60 x 60 mm. 130.044
IMPA 33.2387
Materials Item no.
150 x 50 mm. 130.058
I
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
17
DIRECTION SIGNS
FIRE EQUIPMENT / FIRE FIGHTING
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
18
IMO FIRE CONTROL SYMBOLS
CO2 Fire hose and nozzle Carbon W Monitor Water P Monitor Powder
dioxide
Fire hydrant Water Fire hydrant Foam Fire main section valve
Fixed fire extinguishing Fixed fire extinguishing Water Fixed fire extinguishing Powder
Inergen battery bottle, placed in protected area bottle, placed in protected area
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
19
Fixed fire extinguishing Foam Fixed fire extinguishing Carbon Fixed fire extinguishing Nitrogen
dioxide bottle, placed in protected dioxide bottle, placed in protected bottle, placed in protected area
area area
Fixed fire extinguishing Halon bot- Fixed fire extinguishing Inergen Fixed fire extinguishing bottle,
tle, placed in protected area bottle, placed in protected area placed in protected area
Fixed fire extinguishing Fixed fire Halon extinguishing High expansion foam supply trunk
Nitrogen installation installation (outlet)
FL FE
Photoluminescent vinyl 104.175 PV MM Photoluminescent vinyl 104.176 PV MM Photoluminescent vinyl 104.177 PV MM
SPACE PROTECTED BY
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
20
IMO FIRE CONTROL SYMBOLS
IMO FIRE CONTROL SYMBOLS
Water system spray valve Water fog applicator Space protected by Drenching
Space protected by Water mist Space protected by Foam Space protected by CO2
Water fog valve Water fog valve Remote release station Water
Remote control for fire doors Remote control for fire doors Emergency stop
Main engine
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
21
FIRE DOORS
A class self closing A class self closing sliding fire A class self closing
watertight sliding fire door door semi-watertight sliding fire door
B class self closing B class self closing sliding fire B class self closing
watertight sliding fire door door semi-watertight sliding fire door
B class watertight sliding fire door B class sliding fire door B class semi-watertight sliding
fire door
A class watertight fire door A class fire door A class semi-watertight fire door
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
22
IMO FIRE CONTROL SYMBOLS
B class watertight fire door B class fire door B class fire door
104.254 NON-IMPA
Materials Item no.
Photoluminescent vinyl 104.254 PV MM
VENTILATION
Closing device for ventilation inlet Closing device for ventilation inlet Closing device for ventilation inlet
or outlet or outlet or outlet
Remote control for closing Remote control for closing Remote control for closing
device(s) for ventilation intel and device(s) for ventilation intel and device(s) for ventilation intel and
outlet outlet outlet
FIRE PUMPS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
23
Remote control for emergency fire Remote control for bilge pump(s) Remote control for emergency
pump or fire pump supplied by the bilge pump
emergency source of power
ALARM DEVICES
Push button / switch for general Manually operated call point Sprinkler horn
alarm
PA - speaker for alarms and F Combined beacon and sounder Emergency light
information
104.314 NON-IMPA
Materials Item no.
Photoluminescent vinyl 104.314 PV MM
CO2 CO2 alarm with rotating light
Heat detector
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
24
MISC
IMO FIRE CONTROL SYMBOLS
IG
Photoluminescent vinyl 104.320 PV MM Photoluminescent vinyl 104.321 PV MM Photoluminescent vinyl 104.322 PV MM
Emergency switchboard Air compressor for breathing Control panel for fire detection
devices and alarm system
FB
Photoluminescent vinyl 104.332 PV MM Photoluminescent vinyl 104.333 PV MM FIRE Photoluminescent vinyl 104.328 PV MM
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
25
F
Photoluminescent vinyl 104.28 PV MM Photoluminescent vinyl 104.29 PV MM Photoluminescent vinyl 104.30 PV MM
D
Space protected by drenching Section valves drenching system Fire station
D system
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
26
IMO FIRE CONTROL SYMBOLS
P Powder monitor (gun) P Powder hose and handgun Powder release station
Emergency telephone station Foam release station Fire main with fire valves
Hose box with spray/jet fire nozzle W Water fog applicator Portable fire extinguishers
9
Closing application for exterior Remote ventilation shutoff MVZ Main vertical zone
ventilation inlet or outlet
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
27
FIRE SIGNS
0 1 2
Photoluminescent vinyl 105.090 PV MM Photoluminescent vinyl 105.091 PV MM Photoluminescent vinyl 105.092 PV MM
3 4 5
Photoluminescent vinyl 105.093 PV MM Photoluminescent vinyl 105.094 PV MM Photoluminescent vinyl 105.095 PV MM
6 7 8
Photoluminescent vinyl 105.096 PV MM Photoluminescent vinyl 105.097 PV MM Photoluminescent vinyl 105.098 PV MM
9
Photoluminescent vinyl 105.099 PV MM Photoluminescent vinyl 105.001 PV MM Photoluminescent vinyl 105.002 PV MM
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
28
FIRE SIGNS
Fire
extinguisher Fire alarm
Fire
Fire point Fire phone hose reel
Wrapping around
someone whose
DO NOT USE ON DO NOT USE ON
clothes are burning. Flammable metal fires. Flammable metal fires.
B Not for:
Flammable
DO NOT USE ON
liquids
Photoluminescent vinyl 105.086 PV NH Photoluminescent vinyl 105.087 PV NF Wet chemical Photoluminescent vinyl 105.088 PV RH
Photoluminescent rigid 105.086 PR NH Photoluminescent rigid 105.087 PR NF Safe for
Photoluminescent rigid 105.088 PR RH
A on wood,
paper and
fabric fires.
MISSING
Safe for
use on
F cooking oils
and deep
fat fryers
USE FOR SMOTHERING FIRE
FIRE PLANS
Codes Gross Weight:
Main Supply N
Service/Inspect S
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
29
FIRE SIGNS
105.025 IMPA 33.6140 105.026 IMPA 33.6163 105.027 NON-IMPA 105.028 IMPA 33.6165
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.025 PV HR Photoluminescent vinyl 105.026 PV HR Photoluminescent vinyl 105.027 PV HR Photoluminescent vinyl 105.028 PV HR
Photoluminescent rigid 105.025 PR HR Photoluminescent rigid 105.026 PR HR Photoluminescent rigid 105.027 PR HR Photoluminescent rigid 105.028 PR HR
105.029 IMPA 33.6164 105.030 NON-IMPA 105.031 NON-IMPA 105.035 IMPA 33.6146
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.029 PV HR Photoluminescent vinyl 105.030 PV HR Photoluminescent vinyl 105.031 PV HR Photoluminescent vinyl 105.035 PV HR
Photoluminescent rigid 105.029 PR HR Photoluminescent rigid 105.030 PR HR Photoluminescent rigid 105.031 PR HR Photoluminescent rigid 105.035 PR HR
105.036 IMPA 33.6144 105.037 IMPA 33.6145 105.040 NON-IMPA 105.041 IMPA 33.6150
105.042 IMPA 33.6154 105.043 NON-IMPA 105.044 NON-IMPA 105.045 IMPA 33.6148
105.046 NON-IMPA 105.047 IMPA 33.6153 105.048 NON-IMPA 105.049 IMPA 33.6152
Sprinkler
Fire fighting
equipment
Sprinkler
control wave Halon stop valve
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.046 PV HR Photoluminescent vinyl 105.047 PV HR Photoluminescent vinyl 105.048 PV HR Photoluminescent vinyl 105.049 PV HR
Photoluminescent rigid 105.046 PR HR Photoluminescent rigid 105.047 PR HR Photoluminescent rigid 105.048 PR HR Photoluminescent rigid 105.049 PR HR
105.050 NON-IMPA 105.051 IMPA 33.6147 105.052 IMPA 33.6155 105.053 NON-IMPA
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.050 PV HR Photoluminescent vinyl 105.051 PV HR Photoluminescent vinyl 105.052 PV HR Photoluminescent vinyl 105.053 PV HR
Photoluminescent rigid 105.050 PR HR Photoluminescent rigid 105.051 PR HR Photoluminescent rigid 105.052 PR HR Photoluminescent rigid 105.053 PR HR
105.054 IMPA 33.6151 105.055 NON-IMPA 105.056 NON-IMPA 105.057 IMPA 33.6158
To be used Automatic
only in the fire alarm Fire door Firemans
case of fire control unit keep closed suit
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.042 PV HR Photoluminescent vinyl 105.043 PV HR Photoluminescent vinyl 105.044 PV HR Photoluminescent vinyl 105.057 PV HR
Photoluminescent rigid 105.042 PR HR Photoluminescent rigid 105.043 PR HR Photoluminescent rigid 105.044 PR HR Photoluminescent rigid 105.057 PR HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
30
FIRE SIGNS
105.058 IMPA 33.6160 105.059 IMPA 33.6149 105.060 IMPA 33.6141 105.061 IMPA 33.6142
105.062 IMPA 33.6143 105.065 IMPA 33.6157 105.070 NON-IMPA 105.053 NON-IMPA
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 105.062 PV HR Photoluminescent vinyl 105.065 PV HR Photoluminescent vinyl 105.070 PV HR Photoluminescent vinyl 105.053 PV HR
Photoluminescent rigid 105.062 PR HR Photoluminescent rigid 105.065 PR HR Photoluminescent rigid 105.070 PR HR Photoluminescent rigid 105.053 PR HR
Fire pump
start button
Materials Item no.
Photoluminescent vinyl 105.063 PV HR
Photoluminescent rigid 105.063 PR HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
31
MANDATORY SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
32
MANDATORY SIGNS
Fire door
2. Go immediately to your alloted
3.
assembly station and wait there quietly.
Help others to remain calm. Fire door
keep shut keep locked
4. Take further instructions from the
ships staff at the assembly station.
5. Report any problems.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
33
MANDATORY SIGNS
106.046 IMPA 33.5744 106.047 IMPA 33.5738 106.048 IMPA 33.5783
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.046 PV NM Photoluminescent vinyl 106.047 PV NM Photoluminescent vinyl 106.048 PV NM
Photoluminescent rigid 106.046 PR NM Photoluminescent rigid 106.047 PR NM Photoluminescent rigid 106.048 PR NM
Switch off Self adhesive vinyl 106.046 V NM Self adhesive vinyl 106.047 V NM Self adhesive vinyl 106.048 V NM
Utensil Food
when not Rigid 106.046 R NM Rigid 106.047 R NM Rigid 106.048 R NM
wash only wash only
in use
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
34
MANDATORY SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
35
MANDATORY SIGNS
106.168 IMPA 33.5641 106.169 IMPA 33.5656 106.170 IMPA 33.5649
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.168 PV MM Photoluminescent vinyl 106.169 PV MM Photoluminescent vinyl 106.170 PV MM
Photoluminescent rigid 106.168 PR MM Photoluminescent rigid 106.169 PR MM Photoluminescent rigid 106.170 PR MM
Self adhesive vinyl 106.168 V MM Self adhesive vinyl 106.169 V MM Self adhesive vinyl 106.170 V MM
Rigid 106.168 R MM Rigid 106.169 R MM Rigid 106.170 R MM
Protective clothing This hatch must This door must Oil spill
must be worn in be kept closed be kept closed equipment
this area at sea at sea stored inside
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.200 PV HR Photoluminescent vinyl 106.201 PV HR Photoluminescent vinyl 106.202 PV HR Photoluminescent vinyl 106.203 PV HR
Photoluminescent rigid 106.200 PR HR Photoluminescent rigid 106.201 PR HR Photoluminescent rigid 106.202 PR HR Photoluminescent rigid 106.203 PR HR
Self adhesive vinyl 106.200 V HR Self adhesive vinyl 106.201 V HR Self adhesive vinyl 106.202 V HR Self adhesive vinyl 106.203 V HR
Rigid 106.200 R HR Rigid 106.201 R HR Rigid 106.202 R HR Rigid 106.203 R HR
106.204 IMPA 33.5675 106.205 NON-IMPA 106.206 IMPA 33.5679 106.207 IMPA 33.5852
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.204 PV HR Photoluminescent vinyl 106.205 PV HR Photoluminescent vinyl 106.206 PV HR Photoluminescent vinyl 106.207 PV HR
Photoluminescent rigid 106.204 PR HR Photoluminescent rigid 106.205 PR HR Photoluminescent rigid 106.206 PR HR Photoluminescent rigid 106.207 PR HR
Self adhesive vinyl 106.204 V HR Self adhesive vinyl 106.205 V HR Self adhesive vinyl 106.206 V HR Self adhesive vinyl 106.207 V HR
Rigid 106.204 R HR Rigid 106.205 R HR Rigid 106.206 R HR Rigid 106.207 R HR
106.208 IMPA 33.5830 106.209 IMPA 33.5831 106.210 IMPA 33.5851 106.211 IMPA 33.5678
Personal protective
Emergency exit Escape route keep Accidents must
equipment is provided.
keep clear clear at all times be reported USE IT
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.208 PV MV Photoluminescent vinyl 106.209 PV MV Photoluminescent vinyl 106.210 PV HR Photoluminescent vinyl 106.211 PV HR
Photoluminescent rigid 106.210 PR HR Photoluminescent rigid 106.211 PR HR
Self adhesive vinyl 106.210 V HR Self adhesive vinyl 106.211 V HR
Rigid 106.210 R HR Rigid 106.211 R HR
106.216 NON-IMPA 106.217 NON-IMPA 106.220 IMPA 33.5753 106.221 IMPA 33.5755
MINCING/MIXING MACHINE DISHWASHING MACHINE
This area must Automatic Switch off/disconnect power supply at
mains before cleaning. Use only the
Switch off/disconnect power supply at
mains before cleaning. Avoid overloading
be kept clear fire door plunger provided to push food into the
mincing machine - spoons, food
machine. If machine jams or stops,
immediately switch off power and water
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.216 PV HR Photoluminescent vinyl 106.217 PV HR Photoluminescent vinyl 106.220 PV HR Photoluminescent vinyl 106.221 PV HR
Photoluminescent rigid 106.216 PR HR Photoluminescent rigid 106.217 PR HR Photoluminescent rigid 106.220 PR HR Photoluminescent rigid 106.221 PR HR
Self adhesive vinyl 106.216 V HR Self adhesive vinyl 106.217 V HR Self adhesive vinyl 106.220 V HR Self adhesive vinyl 106.221 V HR
Rigid 106.216 R HR Rigid 106.217 R HR Rigid 106.220 R HR Rigid 106.221 R HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
36
MANDATORY SIGNS
106.222 IMPA 33.5756 106.223 IMPA 33.5748 106.225 NON-IMPA 106.230 NON-IMPA
DEEP FAT FRYER
Wear Wear
WASTE DISPOSAL MACHINE
Switch off/disconnect power supply at mains
Switch off/disconnect power supply at before cleaning. Avoid filing pan beyond
recommended oil level. Ensure food is dried before
mains before cleaning. Ensure that immersing in oil to prevent frothing and subsequent
helmet goggles
cutlery, bones, string, etc are not mixed overflowing. Always return thermostat control to
zero when frying is complete.
with food waste. Switch off power When draining
supply if machine jams or stops. Follow 1. Ensure that receptacies used is large enough to
contain contents.
manufacturer's inspection instructions. 2. Maintain constant vigilance.
3. Clean up spillages immediately.
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.222 PV HR Photoluminescent vinyl 106.223 PV HR Photoluminescent vinyl 106.225 PV HR Photoluminescent vinyl 106.230 PV HR
Photoluminescent rigid 106.222 PR HR Photoluminescent rigid 106.223 PR HR Photoluminescent rigid 106.225 PR HR Photoluminescent rigid 106.230 PR HR
Self adhesive vinyl 106.222 V HR Self adhesive vinyl 106.223 V HR Self adhesive vinyl 106.225 V HR Self adhesive vinyl 106.230 V HR
Rigid 106.222 R HR Rigid 106.223 R HR Rigid 106.225 R HR Rigid 106.230 R HR
106.224 IMPA 33.5745 106.226 IMPA 33.5746 106.227 IMPA 33.5750 106.228 IMPA 33.5751
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.224 PV HR Photoluminescent vinyl 106.226 PV HR Photoluminescent vinyl 106.227 PV HR Photoluminescent vinyl 106.228 PV HR
Photoluminescent rigid 106.224 PR HR Photoluminescent rigid 106.226 PR HR Photoluminescent rigid 106.227 PR HR Photoluminescent rigid 106.228 PR HR
Self adhesive vinyl 106.224 V HR Self adhesive vinyl 106.226 V HR Self adhesive vinyl 106.227 V HR Self adhesive vinyl 106.228 V HR
Rigid 106.224 R HR Rigid 106.226 R HR Rigid 106.227 R HR Rigid 106.228 R HR
106.257 IMPA 33.5691 106.258 IMPA 33.5692 106.259 IMPA 33.5693 106.260 IMPA 33.5694
Marine garbage disposal regulations Marine garbage disposal regulations Marine garbage disposal regulations
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
37
MANDATORY SIGNS
106.261 IMPA 33.5695 106.262 IMPA 33.5696 106.263 IMPA 33.5853 106.264 IMPA 33.5754
Marine garbage disposal regulations No fire loop to be isolated without
Marine garbage disposal regulations Potato chipping machine
Compaction
the knowledge of the watch officer.
Glass only
No fire loop to be kept isolated for Switch off/disconnect power supply
longer than the period required. at mains before changing or
only Signed Master
attempting to dislodge blockages
5695 5695 5695
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.261 PV EN Photoluminescent vinyl 106.262 PV EN Photoluminescent vinyl 106.263 PV HR Photoluminescent vinyl 106.264 PV HR
Photoluminescent rigid 106.261 PR EN Photoluminescent rigid 106.262 PR EN Photoluminescent rigid 106.263 PR HR Photoluminescent rigid 106.264 PR HR
Self adhesive vinyl 106.261 V EN Self adhesive vinyl 106.262 V EN Self adhesive vinyl 106.263 V HR Self adhesive vinyl 106.264 V HR
Rigid 106.261 R EN Rigid 106.262 R EN Rigid 106.263 R HR Rigid 106.264 R HR
106.265 IMPA 33.5752 106.267 IMPA 33.5680 106.268 IMPA 33.5771 106.269 IMPA 33.5772
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.265 PV HR Photoluminescent vinyl 106.267 PV CM Photoluminescent vinyl 106.268 PV HN Photoluminescent vinyl 106.269 PV HN
Photoluminescent rigid 106.265 PR HR Photoluminescent rigid 106.267 PR CM Photoluminescent rigid 106.268 PR HN Photoluminescent rigid 106.269 PR HN
Self adhesive vinyl 106.265 V HR Self adhesive vinyl 106.267 V CM Self adhesive vinyl 106.268 V HN Self adhesive vinyl 106.269 V HN
Rigid 106.265 R HR Rigid 106.267 R CM Rigid 106.268 R HN Rigid 106.269 R HN
Cooked meat
106.272 IMPA 33.5774 106.273 IMPA 33.5775
Materials Item no. Materials Item no.
Raw fish
Photoluminescent vinyl 106.272 PV HH Photoluminescent vinyl 106.273 PV HH
Photoluminescent rigid 106.272 PR HH Photoluminescent rigid 106.273 PR HH
Raw meat Self adhesive vinyl 106.272 V HH Dairy products Self adhesive vinyl 106.273 V HH Salad & fruit
only Rigid 106.272 R HH only Rigid 106.273 R HH
Vegetables
106.274 IMPA 33.5777 106.275 IMPA 33.5778
Materials Item no. Materials Item no.
Photoluminescent vinyl 106.274 PV HH Photoluminescent vinyl 106.275 PV HH Bakery & diary
Photoluminescent rigid 106.274 PR HH Photoluminescent rigid 106.275 PR HH
This door must Self adhesive vinyl 106.274 V HH Raw food must be Self adhesive vinyl 106.275 V HH
stored below
be kept locked Rigid 106.274 R HH cooked meat Rigid 106.275 R HH
Company safety instructions must be Company safety instructions must be Company safety instructions must be
consulted before launching for drift. consulted before launching for drift. consulted before launching for drift.
Ensure a risk assessment has been Ensure a risk assessment has been Ensure a risk assessment has been
carried out and all control measures carried out and all control measures carried out and all control measures
are in place before launching. are in place before launching. are in place before launching.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
38
106.300 IMPA 33.5900 106.301 IMPA 33.5901
MANDATORY SIGNS
WHISTLE AND ALARM SYSTEM 2. ON HEARING THE GENERAL EMERGENCY ALARM SIGNAL
Proceed calmly to your allotted Assembly Station or the nearest
On hearing this alarm signal: Assembly Station if you are away from your cabin. If you are in your cabin
when you hear the alarm signal, dress warmly and follow direction signs to
1. If you are in your cabin, dress in warm clothing, collect your
your Assembly Station.
ASSEMBLY
lifejacket and go to your allotted Assambly Station. STATION
2. If you are near an Assembly Station, go straight there. Assistance should be given to those who need help.
Do not return to your cabin.
Do not return to your cabin. Do not use lifts.
Study the evacuation plan provided.
On arrival at Assembly Station:
1. You will be met by a member of the crew. 3. ASSEMBLY STATION OR MUSTER STATION
An Assembly Station is an area where passengers must assemble in an
2. You will be issued with a lifejacket if you need one and emergency. Assembly Stations are marked with the sign shown below and a letter.
told how to put it on.
3. You will be given instructions on what to do next.
Remember
Stay calm and any instructions given to you by 4. ON ARRIVAL AT AN ASSEMBLY STATION
members of the crew. On arrival at an Assembly Station, you will be issued with a life jacket by a member
of the crew and instructed how to put it on. Childrens lifejackts are available
if required. Please study the accompanying instructions on donning a lifejacket.
1. Do NOT use elevators.
5. FURTHER ACTIONS
2. Do NOT collect bandages.
Stay calm and follow the instructions given to you by the ships crew.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
39
HAZARD SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
40
HAZARD SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
41
HAZARD SIGNS
107.080 IMPA 33.7660 107.010 NON-IMPA 107.081 IMPA 33.7670
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 107.080 PV NM Photoluminescent vinyl 107.010 PV NM Photoluminescent vinyl 107.081 PV NM
Photoluminescent rigid 107.080 PR NM Photoluminescent rigid 107.010 PR NM Photoluminescent rigid 107.081 PR NM
Self adhesive vinyl 107.080 V NM Self adhesive vinyl 107.010 V NM Self adhesive vinyl 107.081 V NM
Warning Rigid 107.080 R NM Danger Rigid 107.010 R NM Danger Rigid 107.081 R NM
Radiation Radioactive Ionizing
risk materials radiation
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
42
HAZARD SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
43
HAZARD SIGNS
107.059 IMPA 33.7542 107.060 IMPA 33.7545 107.061 IMPA 33.7547
Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 107.059 PV NM Photoluminescent vinyl 107.060 PV NM Photoluminescent vinyl 107.061 PV NM
Photoluminescent rigid 107.059 PR NM Photoluminescent rigid 107.060 PR NM Photoluminescent rigid 107.061 PR NM
Self adhesive vinyl 107.059 V NM Self adhesive vinyl 107.060 V NM Self adhesive vinyl 107.061 V NM
Danger Rigid 107.059 R NM Danger Rigid 107.060 R NM Rigid 107.061 R NM
Unmanned machinery
space, machinery may
You are entering a Warning
start without warning
CO2 protected area Under maintenance
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
44
HAZARD SIGNS
107.135 IMPA 33.7701 107.136 IMPA 33.7700 107.137 IMPA 33.7000 107.138 IMPA 33.7578
Acetylene Oxygen
toilet system.
Seat and cover must be lowered
earhted during cargo
before flushing. operations
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 107.135 PV HR Photoluminescent vinyl 107.136 PV HR Photoluminescent vinyl 107.137 PV HR Photoluminescent vinyl 107.138 PV HR
Photoluminescent rigid 107.135 PR HR Photoluminescent rigid 107.136 PR HR Photoluminescent rigid 107.137 PR HR Photoluminescent rigid 107.138 PR HR
Photoluminescent rigid 107.135 V HR Photoluminescent rigid 107.136 V HR Photoluminescent rigid 107.137 V HR Photoluminescent rigid 107.138 V HR
Photoluminescent rigid 107.135 R HR Photoluminescent rigid 107.136 R HR Photoluminescent rigid 107.137 R HR Photoluminescent rigid 107.138 R HR
107.139 IMPA 33.7569 107.140 IMPA 33.7577 107.141 IMPA 33.7579 107.142 IMPA 33.7598
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 107.139 PV HR Photoluminescent vinyl 107.140 PV HR Photoluminescent vinyl 107.141 PV HR Photoluminescent vinyl 107.142 PV HR
Photoluminescent rigid 107.139 PR HR Photoluminescent rigid 107.140 PR HR Photoluminescent rigid 107.141 PR HR Photoluminescent rigid 107.142 PR HR
Photoluminescent rigid 107.139 V HR Photoluminescent rigid 107.140 V HR Photoluminescent rigid 107.141 V HR Photoluminescent rigid 107.142 V HR
Photoluminescent rigid 107.139 R HR Photoluminescent rigid 107.140 R HR Photoluminescent rigid 107.141 R HR Photoluminescent rigid 107.142 R HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
45
PROHIBITON SIGNS
102.030 IMPA 33.8530 102.034 IMPA 33.8533 102.035 NON-IMPA 102.036 IMPA 33.8532
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.030 PV HR Photoluminescent vinyl 102.034 PV HR Photoluminescent vinyl 102.035 PV HR Photoluminescent vinyl 102.036 PV HR
Photoluminescent rigid 102.030 PR HR Photoluminescent rigid 102.034 PR HR Photoluminescent rigid 102.035 PR HR Photoluminescent rigid 102.036 PR HR
Rigid 102.030 R HR Rigid 102.034 R HR Rigid 102.035 R HR Rigid 102.036 R HR
Selfadhesive vinyl 102.030 V HR Selfadhesive vinyl 102.034 V HR Selfadhesive vinyl 102.035 V HR Selfadhesive vinyl 102.036 V HR
102.039 IMPA 33.8531 102.040 IMPA 33.8542 102.031 IMPA 33.8543 102.032 IMPA 33.8540
102.033 NON-IMPA 102.041 IMPA 33.8559 102.038 IMPA 33.8544 102.042 IMPA 33.8541
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.033 PV HR Photoluminescent vinyl 102.041 PV HR Photoluminescent vinyl 102.038 PV HR Photoluminescent vinyl 102.042 PV HR
Photoluminescent rigid 102.033 PR HR Photoluminescent rigid 102.041 PR HR Photoluminescent rigid 102.038 PR HR Photoluminescent rigid 102.042 PR HR
Rigid 102.033 R HR Rigid 102.041 R HR Rigid 102.038 R HR Rigid 102.042 R HR
Selfadhesive vinyl 102.033 V HR Selfadhesive vinyl 102.041 V HR Selfadhesive vinyl 102.038 V HR Selfadhesive vinyl 102.042 V HR
102.043 IMPA 33.8546 102.094 IMPA 33.8547 102.046 IMPA 33.8549 102.047 IMPA 33.8545
Do no enter the
pumproom
NO ENTRY
except by authorised personnel No Authorised
admittance
and unless ventilation has been
in use for at least 15 minutes personnel only
without permission from the chief official prior to entry
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.043 PV HR Photoluminescent vinyl 102.094 PV HR Photoluminescent vinyl 102.046 PV HR Photoluminescent vinyl 102.047 PV HR
Photoluminescent rigid 102.043 PR HR Photoluminescent rigid 102.094 PR HR Photoluminescent rigid 102.046 PR HR Photoluminescent rigid 102.047 PR HR
Rigid 102.043 R HR Rigid 102.094 R HR Rigid 102.046 R HR Rigid 102.047 R HR
Selfadhesive vinyl 102.043 V HR Selfadhesive vinyl 102.094 V HR Selfadhesive vinyl 102.046 V HR Selfadhesive vinyl 102.047 V HR
102.048 IMPA 33.8690 102.049 IMPA 33.8691 102.037 IMPA 33.8658 102.050 IMPA 33.8570
Restricted area no
unauthorised entry
Restricted area
authorised persons anly No mobile Switch off mobile
phones, pagers,
Unauthorised presence within this area
constitutes a breach of security
Unauthorised presence within this area
constitutes a breach of security phones camera etc.
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.048 PV HR Photoluminescent vinyl 102.049 PV HR Photoluminescent vinyl 102.037 PV HR Photoluminescent vinyl 102.050 PV HR
Photoluminescent rigid 102.048 PR HR Photoluminescent rigid 102.049 PR HR Photoluminescent rigid 102.037 PR HR Photoluminescent rigid 102.050 PR HR
Rigid 102.048 R HR Rigid 102.049 R HR Rigid 102.037 R HR Rigid 102.050 R HR
Selfadhesive vinyl 102.048 V HR Selfadhesive vinyl 102.049 V HR Selfadhesive vinyl 102.037 V HR Selfadhesive vinyl 102.050 V HR
102.051 IMPA 33.8548 102.052 NON-IMPA 102.053 IMPA 33.8537 102.054 IMPA 33.8536
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
46
PROHIBITION SIGNS
102.055 IMPA 33.8534 102.056 IMPA 33.8539 102.057 NON-IMPA 102.060 IMPA 33.8553
102.070 IMPA 33.8552 102.071 IMPA 33.8551 102.072 IMPA 33.8560 102.073 IMPA 33.8561
102.074 NON-IMPA 102.075 IMPA 33.8569 102.076 IMPA 33.5747 102.077 IMPA 33.8565
Microwave Oven
No smoking, drinking Do not use 1. As a sensible precaution do not Do not watch
or eating within unless guards are look closely into the oven when it
102.078 IMPA 33.8567 102.079 IMPA 33.8568 102.080 IMPA 33.8576 102.081 NON-IMPA
Do not throw
garbage overboard
Do not Do not switch on Do not
This vessel operates in a special area
designated by International Maritime Low
remove guards under maintenance
block
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.078 PV HR Photoluminescent vinyl 102.079 PV HR Photoluminescent vinyl 102.080 PV HR Photoluminescent vinyl 102.081 PV HR
Photoluminescent rigid 102.078 PR HR Photoluminescent rigid 102.079 PR HR Photoluminescent rigid 102.080 PR HR Photoluminescent rigid 102.081 PR HR
Rigid 102.078 R HR Rigid 102.079 R HR Rigid 102.080 R HR Rigid 102.081 R HR
Selfadhesive vinyl 102.078 V HR Selfadhesive vinyl 102.079 V HR Selfadhesive vinyl 102.080 V HR Selfadhesive vinyl 102.081 V HR
102.087 IMPA 33.8550 102.082 NON-IMPA 102.083 NON-IMPA 102.085 IMPA 33.8563
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.087 PV HR Photoluminescent vinyl 102.082 PV HR Photoluminescent vinyl 102.083 PV HR Photoluminescent vinyl 102.085 PV HR
Photoluminescent rigid 102.087 PR HR Photoluminescent rigid 102.082 PR HR Photoluminescent rigid 102.083 PR HR Photoluminescent rigid 102.085 PR HR
Rigid 102.087 R HR Rigid 102.082 R HR Rigid 102.083 R HR Rigid 102.085 R HR
Selfadhesive vinyl 102.087 V HR Selfadhesive vinyl 102.082 V HR Selfadhesive vinyl 102.083 V HR Selfadhesive vinyl 102.085 V HR
102.088 IMPA 33.8575 102.089 IMPA 33.8585 102.090 IMPA 33.8587 102.086 IMPA 33.8692
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.088 PV HR Photoluminescent vinyl 102.089 PV HR Photoluminescent vinyl 102.090 PV HR Photoluminescent vinyl 102.086 PV HR
Photoluminescent rigid 102.088 PR HR Photoluminescent rigid 102.089 PR HR Photoluminescent rigid 102.090 PR HR Photoluminescent rigid 102.086 PR HR
Rigid 102.088 R HR Rigid 102.089 R HR Rigid 102.090 R HR Rigid 102.086 R HR
Selfadhesive vinyl 102.088 V HR Selfadhesive vinyl 102.089 V HR Selfadhesive vinyl 102.090 V HR Selfadhesive vinyl 102.086 V HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
47
PROHIBITION SIGNS
102.045 IMPA 33.8557 102.091 IMPA 33.8584 102.092 IMPA 33.8555
33.8575 102.093 IMPA 33.8556
33.8585
No Crew only
Unauthorised Do not carry out
access
persons may not maintenance work on
service machines running machinery
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.045 PV HR Photoluminescent vinyl 102.091 PV HR Photoluminescent vinyl 102.092 PV HR Photoluminescent vinyl 102.093 PV HR
Photoluminescent rigid 102.045 PR HR Photoluminescent rigid 102.091 PR HR Photoluminescent rigid 102.092 PR HR Photoluminescent rigid 102.093 PR HR
Rigid 102.045 R HR Rigid 102.091 R HR Rigid 102.092 R HR Rigid 102.093 R HR
Selfadhesive vinyl 102.045 V HR Selfadhesive vinyl 102.091 V HR Selfadhesive vinyl 102.092 V HR Selfadhesive vinyl 102.093 V HR
102.095 IMPA 33.8574 102.096 IMPA 33.8619 102.097 IMPA 33.8582 102.098 IMPA 33.8529
WARNING! No smoking
Test water temperature
before use in bed
Materials Item no. Materials Item no.
Photoluminescent vinyl 102.300 PV EN Photoluminescent vinyl 102.099 PV HR
Photoluminescent rigid 102.300 PR EN Photoluminescent rigid 102.099 PR HR
Rigid 102.300 R EN Rigid 102.099 R HR
Selfadhesive vinyl 102.300 V EN Selfadhesive vinyl 102.099 V HR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
48
PROHIBITION SIGNS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
49
to the ships to VISITORS WILL BE MET ON DECK AND MUST REGISTER ONBOARD WITH
A PHOTOGREAPHIC IDENTIFICATION DOCUMENT AND MAY BE SUBJECT
140.025 IMPA 33.2703 140.026 IMPA 33.2703 140.027 IMPA 33.2703 140.020 NON-IMPA
Security
1 2 3
CREW MEMBERS ONLY
Security Security No admittance without the authority
Level
of a Ships officer.
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Rigid plast 140.025 R MR Rigid plast 140.026 R MR Rigid plast 140.027 R MR Self adhesive vinyl 140.020 V PU
Rigid plast 140.020 R PU
1 1 1 1
NO ACCESS TO
UNAUTHORISED
KEEP
OUT
2 2 2 2
3 3 3 3
PERSON
Date: Date:
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
50
ISPS CODE SIGNS
106.247 IMPA 33.5825 106.250 IMPA 33.5824 106.251 NON-IMPA 106.252 NON-IMPA
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.247 PV HR Photoluminescent vinyl 106.250 PV HR Photoluminescent vinyl 106.251 PV HR Photoluminescent vinyl 106.252 PV HR
Photoluminescent rigid 106.247 PR HR Photoluminescent rigid 106.250 PR HR Photoluminescent rigid 106.251 PR HR Photoluminescent rigid 106.252 PR HR
Self adhesive vinyl 106.247 V HR Self adhesive vinyl 106.250 V HR Self adhesive vinyl 106.251 V HR Self adhesive vinyl 106.252 V HR
Rigid 106.247 R HR Rigid 106.250 R HR Rigid 106.251 R HR Rigid 106.252 R HR
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 106.253 PV HR Photoluminescent vinyl 106.254 PV HR Photoluminescent vinyl 106.255 PV HR Photoluminescent vinyl 102.048 PV HR
Photoluminescent rigid 106.253 PR HR Photoluminescent rigid 106.254 PR HR Photoluminescent rigid 106.255 PR HR Photoluminescent rigid 102.048 PR HR
Self adhesive vinyl 106.253 V HR Self adhesive vinyl 106.254 V HR Self adhesive vinyl 106.255 V HR Self adhesive vinyl 102.048 V HR
Rigid 106.253 R HR Rigid 106.254 R HR Rigid 106.255 R HR Rigid 102.048 R HR
102.049 IMPA 33.8691 102.086 IMPA 33.8692 140.012 IMPA 33.2895 140.013 IMPA 33.2907
Restricted area
No
authorised persons anly
Unauthorised presence within this area
constitutes a breach of security
photograhpy Ship security office Reception
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Photoluminescent vinyl 102.049 PV HR Photoluminescent vinyl 102.086 PV HR Photoluminescent vinyl 140.012 PV HR Photoluminescent vinyl 140.013 PV HR
Photoluminescent rigid 102.049 PR HR Photoluminescent rigid 102.086 PR HR Photoluminescent rigid 140.012 PR HR Photoluminescent rigid 140.013 PR HR
Self adhesive vinyl 102.049 V HR Self adhesive vinyl 102.086 V HR Self adhesive vinyl 140.012 V HR Self adhesive vinyl 140.013 V HR
Rigid 102.049 R HR Rigid 102.086 R HR Rigid 140.012 R HR Rigid 140.013 R HR
Private
Photoluminescent vinyl 140.007 PV MM Photoluminescent vinyl 140.008 PV MM
Photoluminescent rigid 140.007 PR MM Photoluminescent rigid 140.008 PR MM
VDR
Voice recording is
Self adhesive vinyl 140.007 V MM CCTV Self adhesive vinyl 140.008 V MM
fitted on this bridge Rigid 140.007 R MM in operation Rigid 140.008 R MM
This vessel
is under CCTV This area
is under
CCTV in CCTV
Surveillance operation surveillance
Materials Item no. Materials Item no. Materials Item no.
Self adhesive vinyl 140.009 V 350x300mm Self adhesive vinyl 140.001 V SR Self adhesive vinyl 140.002 V SR
Rigid plast 140.009 R 350x300mm Rigid plast 140.001 R SR Rigid plast 140.002 R SR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
51
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
52
ACCOMODATION SIGNS
140.016 IMPA 33.2908 140.017 IMPA 33.2877 140.018 IMPA 33.2878 140.019 IMPA 33.2879
140.015 IMPA 33.2908 140.023 IMPA 33.2918 140.024 IMPA 33.2919 140.028 IMPA 33.2920
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
53
COMBI SIGNS
COMBI SIGNS
120.001 IMPA 33.3100 120.002 IMPA 33.3101 120.005 IMPA 33.3102 120.006 IMPA 33.3103
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.001 V NR Selfadhesive vinyl 120.002 V NR Selfadhesive vinyl 120.005 V NR Selfadhesive vinyl 120.006 V NR
Rigid 120.001 R NR Rigid 120.002 R NR Rigid 120.005 R NR Rigid 120.006 R NR
120.007 IMPA 33.3107 120.010 IMPA 33.3109 120.015 IMPA 33.3110 120.016 IMPA 33.3112
smoking
and radio equipment
before accessing the without a Keep out
monkey island permit to work
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.007 V NR Selfadhesive vinyl 120.010 V NR Selfadhesive vinyl 120.015 V NR Selfadhesive vinyl 120.016 V NR
Rigid 120.007 R NR Rigid 120.010 R NR Rigid 120.015 R NR Rigid 120.016 R NR
120.017 IMPA 33.3113 120.018 IMPA 33.3114 120.020 IMPA 33.8522 120.021 IMPA 33.3115
Do not throw
Danger Danger garbage
Asbestos Hazardous area
No smoking
overboard
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.017 V NR Selfadhesive vinyl 120.018 V NR Selfadhesive vinyl 120.020 V NR Selfadhesive vinyl 120.021 V NR
Rigid 120.017 R NR Rigid 120.018 R NR Rigid 120.020 R NR Rigid 120.021 R NR
120.022 IMPA 33.3120 120.023 NON-IMPA 120.025 IMPA 33.3104 120.026 IMPA 33.3105
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.022 V NR Selfadhesive vinyl 120.023 V NR Selfadhesive vinyl 120.025 V NR Selfadhesive vinyl 120.026 V NR
Rigid 120.022 R NR Rigid 120.023 R NR Rigid 120.025 R NR Rigid 120.026 R NR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
54
COMBI SIGNS
120.027 IMPA 33.3106 120.028 IMPA 33.3116 120.029 IMPA 33.3117 120.030 IMPA 33.3118
No valves to be opened
Descend backwards
Valid permit to Ear protectors
or work to be performed
without the permission
work required must be worn
using both handrails
of the Chief Officer before entry in this area
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.027 V NR Selfadhesive vinyl 120.028 V NR Selfadhesive vinyl 120.029 V NR Selfadhesive vinyl 120.030 V NR
Rigid 120.027 R NR Rigid 120.028 R NR Rigid 120.029 R NR Rigid 120.030 R NR
120.031 IMPA 33.3119 120.081 IMPA 33.3141 120.050 IMPA 33.3128 120.051 IMPA 33.3108
Keep well
Minimum safety requirements:
Materials Item no. Overalls No hot work
Head protection No chipping
Selfadhesive vinyl
Rigid
120.031 V NR
120.031 R NR
ventilated Ear defenders
Safety boots
No unapproved
electrical equipment
120.052 IMPA 33.3122 120.053 IMPA 33.3123 120.054 IMPA 33.3127 120.055 IMPA 33.3124
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.052 V RR Selfadhesive vinyl 120.053 V RR Selfadhesive vinyl 120.054 V RR Selfadhesive vinyl 120.055 V RR
Rigid 120.052 R RR Rigid 120.053 R RR Rigid 120.054 R RR Rigid 120.055 R RR
120.056 IMPA 33.3125 120.057 IMPA 33.3126 120.058 IMPA 33.3135 120.059 IMPA 33.3128
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.056 V RR Selfadhesive vinyl 120.057 V RR Selfadhesive vinyl 120.058 V RR Selfadhesive vinyl 120.059 V RR
Rigid 120.056 R RR Rigid 120.057 R RR Rigid 120.058 R RR Rigid 120.059 R RR
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
55
COMBI SIGNS
120.060 IMPA 33.3129 120.061 IMPA 33.3136 120.062 IMPA 33.3137 120.074 NON-IMPA
Materials Item no. Materials Item no. Materials Item no. Materials Item no.
Selfadhesive vinyl 120.060 V RR Selfadhesive vinyl 120.061 V RR Selfadhesive vinyl 120.062 V RR Selfadhesive vinyl 120.074 V RR
Rigid 120.060 R RR Rigid 120.061 R RR Rigid 120.062 R RR Rigid 120.074 R RR
120.075 NON-IMPA 120.076 NON-IMPA 120.080 IMPA 33.3014 120.034 IMPA 33.3522
International shore
120.032 IMPA 33.8525 120.033 IMPA 33.8526 connection is located at:
No No smoking
beyond this point
smoking Materials Item no.
No eating or drinking
beyond this point Selfadhesive vinyl 120.080 V XV
No eating Rigid 120.080 R XV
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
56
TIE TAGS
TIE TAGS
TIE TAGS
125.001 125.002 125.003 125.004 Materials Size codes
IMPA 33.2510 IMPA 33.2503 IMPA 33.2501 IMPA 33.2507
Plast 0,2 mm : E : 75 mm.
Pack of 10 pieces K : 140 mm.
CURRENT LIVE
ON WIRES
DEFECTIVE
EQUIPMENT
EXPLOSIVE FLAMMABLE GAS HARMFUL
Authorised by: Authorised by: Authorised by: Authorised by: Authorised by: Authorised by: Authorised by:
DO NOT
IRRITANT DO NOT DO NOT DO NOT OPERATE
DO NOT DO NOT
OPEN CLOSE OPERATE WORK IN PROGRESS MOVE START
Authorised by: Authorised by: Authorised by: Authorised by: Authorised by: Authorised by: Authorised by:
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
57
125.110 NON-IMPA P P P P P P P P C C C C P P P P FD FD FD FD
W
9L
W
9L
W
9L F W
9L F F F
Pictograms
CO2 CO2 CO2 CO2 D D D D
IG IG IG IG
F F F F W W W W
CO2 CO2 CO2 CO2
2 2 2 2 6L 6L 6L 6L
8 mm.
CO2 CO2 CO2 CO2 CO2 CO2 CO2 CO2
F F F F
P P P P
2 2 2 2 1 1 1 1
www.denfoil.com 125.110
S S S S F F F F WT WT WT WT
C C C C P P P S P S S S
W W W W
P P P P WT WT WT SWT
WT SWT SWT SWT
N N N N F F F CO2 F
C CO2
C CO2
C CO2
C
A A A A
F F F F S S S S WT WT WT SWT
WT SWT SWT CO2
SWT CO2 CO2 CO2
I I I I
Pictograms
M M M M
F F F F P P P P
FL FL FL FL
SWT SWT SWT SWT WT WT WT WT
N N N N
C C C C
G G G G
FE FE FE FE
SWT SWT SWT SWT WT WT WT WT
I I I I
WT WT WT WT
CO2 CO2 CO2 CO2 M M M H M H H HA A A SAFETY A SAFETY SAFETY SWT
SAFETY SWT SWT SWT
FD FD FD FD
I I I I C C C W C W W WM M M M SWT SWT SWT SWT
FD FD FD FD
125.112 NON-IMPA Minisymbols for Minisymbols for Minisymbols for Minisymbols for Minisymbols for Minisymbols for
Life-Saving Plan Life-Saving Plan Life-Saving Plan Life-Saving Plan Life-Saving Plan Life-Saving Plan
Materials Item no.
Self adhesive vinyl 10mm 125.112 V
Persons Persons Persons Persons Persons Persons Persons Persons Persons Persons
Persons Persons Persons Persons Persons Persons Persons Persons Persons Persons
Life-Saving Plan
Persons Persons Persons Persons Persons Persons Persons Persons Persons Persons
Pictograms Persons Persons Persons Persons Persons Persons Persons Persons Persons Persons
TPA
TPA
TPA
TPA
TPA
AES
AES
AES
AES
AES
www.denfoil.com 125.112
NUMBERS
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
58
1.1 1.2
1 1 1
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.240 100 x 100 mm. Roll with 250 pcs. 132.241 100 x 100 mm. Roll with 250 pcs. 132.242
250 x 250 mm. Self adhesive vinyl 132.280 250 x 250 mm. Self adhesive vinyl 132.281 250 x 250 mm. Self adhesive vinyl 132.282
250 x 250 mm. Magnetic 132.280 MF 250 x 250 mm. Magnetic 132.281 MF 250 x 250 mm. Magnetic 132.282 MF
1.3
1.4 1.4
G G
1 1 1
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.243 100 x 100 mm. Roll with 250 pcs. 132.244 100 x 100 mm. Roll with 250 pcs. 132.249
250 x 250 mm. Self adhesive vinyl 132.283 250 x 250 mm. Self adhesive vinyl 132.284 250 x 250 mm. Self adhesive vinyl 132.289
250 x 250 mm. Magnetic 132.283 MF 250 x 250 mm. Magnetic 132.284 MF 250 x 250 mm. Magnetic 132.289 MF
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.250 100 x 100 mm. Roll with 250 pcs. 132.252 100 x 100 mm. Roll with 250 pcs. 132.253
250 x 250 mm. Self adhesive vinyl 132.290 250 x 250 mm. Self adhesive vinyl 132.292 250 x 250 mm. Self adhesive vinyl 132.293
250 x 250 mm. Magnetic 132.290 MF 250 x 250 mm. Magnetic 132.292 MF 250 x 250 mm. Magnetic 132.293 MF
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.255 100 x 100 mm. Roll with 250 pcs. 132.256 100 x 100 mm. Roll with 250 pcs. 132.257
250 x 250 mm. Self adhesive vinyl 132.295 250 x 250 mm. Self adhesive vinyl 132.296 250 x 250 mm. Self adhesive vinyl 132.297
250 x 250 mm. Magnetic 132.295 MF 250 x 250 mm. Magnetic 132.296 MF 250 x 250 mm. Magnetic 132.297 MF
3 4 4
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.258 100 x 100 mm. Roll with 250 pcs. 132.259 100 x 100 mm. Roll with 250 pcs. 132.260
250 x 250 mm. Self adhesive vinyl 132.298 250 x 250 mm. Self adhesive vinyl 132.299 250 x 250 mm. Self adhesive vinyl 132.300
250 x 250 mm. Magnetic 132.298 MF 250 x 250 mm. Magnetic 132.299 MF 250 x 250 mm. Magnetic 132.300 MF
4 5.1 5.2
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.261 100 x 100 mm. Roll with 250 pcs. 132.262 100 x 100 mm. Roll with 250 pcs. 132.263
250 x 250 mm. Self adhesive vinyl 132.301 250 x 250 mm. Self adhesive vinyl 132.302 250 x 250 mm. Self adhesive vinyl 132.303
250 x 250 mm. Magnetic 132.301 MF 250 x 250 mm. Magnetic 132.302 MF 250 x 250 mm. Magnetic 132.303 MF
6 6 7
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.264 100 x 100 mm. Roll with 250 pcs. 132.265 100 x 100 mm. Roll with 250 pcs. 132.266
250 x 250 mm. Self adhesive vinyl 132.304 250 x 250 mm. Self adhesive vinyl 132.305 250 x 250 mm. Self adhesive vinyl 132.306
250 x 250 mm. Magnetic 132.304 MF 250 x 250 mm. Magnetic 132.305 MF 250 x 250 mm. Magnetic 132.306 MF
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
59
RADIOACTIVE RADIOACTIVE
CONTENTS........................ CONTENTS........................ CORROSIVE
ACTIVITY.................... ACTIVITY....................
7 7 8
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.267 100 x 100 mm. Roll with 250 pcs. 132.268 100 x 100 mm. Roll with 250 pcs. 132.269
250 x 250 mm. Self adhesive vinyl 132.307 250 x 250 mm. Self adhesive vinyl 132.308 250 x 250 mm. Self adhesive vinyl 132.309
250 x 250 mm. Magnetic 132.307 MF 250 x 250 mm. Magnetic 132.308 MF 250 x 250 mm. Magnetic 132.309 MF
UN
9
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.270 250 mm. Self adhesive vinyl 132.393 50 x 100 mm. Roll with 250 pcs. 132.438
250 x 250 mm. Self adhesive vinyl 132.310
250 x 250 mm. Magnetic 132.310 MF
TIME:
FOODSTUFFS
VENTILATED ON:
DO NOT ENTER 6
Size Materials Item no. Size Materials Item no. Size Materials Item no.
360 x 510 mm. Self adhesive vinyl 132.390 105 x 74 mm. Roll with 250 pcs. 132.391 100 x 100 mm. Roll with 250 pcs. 132.254
210 x 148 mm. Self adhesive vinyl 132.392 250 x 250 mm. Self adhesive vinyl 132.294
250 x 250 mm. Magnetic 132.294 MF
LQ
LTD QTY
Size Materials Item no. Size Materials Item no. Size Materials Item no.
120 x 300 mm. Self adhesive vinyl 132.394 100 x 100 mm. Roll with 250 pcs. 132.396 100 x 100 mm. Roll with 250 pcs. 132.397
250 x 250 mm. Selfadhesive vinyl 132.340
Size Materials Item no. Size Materials Item no. Size Materials Item no.
100 x 100 mm. Roll with 250 pcs. 132.450 100 x 100 mm. Roll with 250 pcs. 132.451 100 x 100 mm. Roll with 250 pcs. 132.398
250 x 250 mm. Self adhesive vinyl 132.500 250 x 250 mm. Self adhesive vinyl 132.501
250 x 250 mm. Magnetic 132.500 MF 250 x 250 mm. Magnetic 132.501 MF
NON-IMPA
OVERPACK
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
60
TRAINING POSTERS
Name Size Item no. IMPA no.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
61
125.251 NON-IMPA
125.229 IMPA 33.1545
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
62
PIPEMARKING
PIPEMARKING
WASTE MEDIA - BLACK ITEM NO. FRESH WATER - BLUE ITEM NO. FUEL - BROWN ITEM NO.
Waste media - Black Item no. Fresh water - Blue Item no. Fuel - Brown Item no.
General 150.001 General 150.021 General 150.041
Black water 150.002 Heary fuel oil (HFO) 150.042
Waste oil/ used oil 150.003 Fresh water, sanitary 150.023 Aviation fuel 150.043
Bilge water 150.004 Potable water 150.024
Exhaust gas 150.005 Distillate 150.025
NON-FLAMMABLE GASES - GREY ITEM NO. MASSES (DRY & WET) - MAROON ITEM NO. OIL OTHER THAN FUEL - ORANGE ITEM NO.
Non-flammable gases - Grey Item no. Masses (dry & wet) - Maroon Item no. Oil other than fuel - Orange Item no.
General 150.061 General 150.081 General 150.101
FIRE FIGHTING / FIRE PROTECTION - RED ITEM NO. ACDIS, ALKALIS - VIOLE ITEM NO. STEAM - SILVER ITEM NO.
Fire fighting / Fire protection - Red Item no. Acdis, alkalis - Violet Item no. Steam - Silver Item no.
General 150.121 General 150.161
Steam for heating 150.162
AIR IN VENTILATION SYSTEMS - WHITE ITEM NO. FLAMMABLE GASES - YELLOW ITEM NO. SEA WATER - GREEN ITEM NO.
Air in ventilation systems - White Item no. Flammable gases - Yellow Item no. Sea water - Green Item no.
General 150.181 General 150.201 General 150.221
Discharge air 150.182
Mech. supply air, cold 150.183 Hydrogen 150.203 Decont. water 150.223
Natural exhaust air 150.184 Sea water, san. 150.224
Atmospheric air 150.185
Mech. exhaust air 150.186 Acetylene 150.206
Decont. supply air 150.187
Mech. recirculated air 150.188
Mech. supply air, warm 150.189
Smoke clearance 150.190 Ballast water 150.230
Conditioned supply air 150.191 Liquid gas 150.211
Natural supply air 150.192 Cooling sea water 150.232
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
63
TAPES
TAPES
PHOTOLUMINESCENT TAPE EDGE FIX
GREEN DIAGONAL TAPE - for closing gaps and making the Non-slip tape even stronger
- for highlighting and marking saf areas and exit doors
Color Size Item no.
Color Size Item no. Egde Fix 140 ml. 130.740
Green / Photoluminescent 40 mm. x 10 m. 1 roll 130.018
Green / Photoluminescent 80 mm. x 10 m. 1 roll 130.006
Photoluminescent:
Photoluminescent / Black 50 mm x 18 m. 1 roll 130.735
Photoluminescent 50 mm x 18 m. 1 roll 130.736
REFLECTIVE TAPE
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
64
SKIPPER
The award winning Skipper unit has 9m (30ft) of high visibility retractable tape,
making it the most cost-effective and easy to use barrier on the market.
With a full complement of fantastic accessories, Skipper really is perfect for any
environment. Its range of applications also make it perfect for sectors such as
traffic management, construction, maritime, facilities management and so many
more.
Skipper unit
Skipper is the unique way to cordon off any area, creat- Product Item no. Height Width Depth Weight
ing safer environments with high visibility retractable Skipper unit 130.170 240mm 145mm 145mm 795g
Dummy unit 130.182 240mm 145mm 145mm 400g
9m (30ft) tape.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
65
SKIPPER
SKIPPER - THE VERSATILE ALTERNATIVE TO A CONE
The Skipper post is the amazing system for the
successful Skipper product line. Its great Green
versatility allows it to be used on both hard and
soft ground, indoors and outdoors.
Grey
The unique, interchangeable base allows the post
to be sunk into the ground with a spike or
attached to its sturdy base for use on hard
surfaces.
Red
Orange
Yellow
The Skipper post & base system are
available in a range of standard colors.
Blue
SKIPPER ACCESSORIES
Skipper post & base collar
The Post & base collar attaches firmly to the post by Product Item no. Height Width Depth Weight
simply sliding over the top and seating into posi- Post & base collar 130.191 185mm 194mm 131mm 430g
tion. It provides a strong platform for attaching the
Skipper recycle bins, dispensers and hand sanitiser
brackets.
A4 sign holder
The A4 sign holder’s functional design makes it a great Product Item no. Height Width Depth Weight
complement to the Skipper product range. Simply A4 sign holder 130.180 348mm 266mm 28mm 480g
insert your A4 message into the polycarbonate sleeve,
and slide into the robust u-shaped frame.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
66
The XS unit has all the great versatility of the standard Skipper unit but attaches
to a range of unique accessories that make it possible to connect to any indoor
surface.
From high gloss and glass surfaces, to worktops, shelving, door frames and
pillars, anything is possible.
Skipper XS unit
Designed for internal use, the Skipper XS unit has all Product Item no. Height Width Depth Weight
the great versatility of the standard Skipper unit but is Skipper XS unit 130.184 126mm 145mm 145mm 700g
for use without cones or posts. Skipper XS also has
the full 9 metres (30ft) of retractable tape.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
67
SKIPPER
MANAGEMENT
MODULAR WASTE MANAGEMENT
CONNECTED TO SAFETY
The Skipper range of patent protected waste & safety management products
provide a flexible and effective solution, with a wealth of fixing and display
options. Being compatible with existing Skipper products makes the waste &
safety management range intuitive for people already familiar with Skipper, as
well as newcomers.
The range includes recycle bins for multi-purpose waste & recycling use, a
safety dispenser which provides easy access to safety equipment such as ear
plugs and safety glasses, and a hand sanitiser bracket which will hold any
dispenser up to a diameter of 75mm.
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000
68
www.denfoil.com
Denfoil Maritime Denmark Phone: +45 5485 9692 www.denfoil.com Denfoil Norway Phone: +47 2164 1000