Professional Documents
Culture Documents
Cantilever Slab
Cantilever Slab
PREAMBLE : The Two Way Slab is assumed to be subjectd Uniform Pressure intensity.
This Design Document represents Design of Two Way Slab
SLAB SPECIFICATION :
SHORT EDGE CONTINOUS
Effective length of Short Span = lx = 1780 mm 1780
Effective length of Long Span = ly = 3750 mm
LONG EDGE
CONTINOUS
LONG EDGE
CONTINOUS
Ratio = ly / lx = 2.1
Effective Width of Slab = b = 1000 mm 3750
Overall Depth of Slab = D = 120 mm
Clear cover to Main R/ f = c = 20 mm
Diameter of Main R/f = f = 8 f mm
Effective Depth of Slab = d = D - c - f/2 = 96 mm SHORT EDGE DISCONTINOUS
Case No = 2
Type of Panel = ONE SHORT EDGE DISCONTINOUS :
MATERIAL SPECIFICATION :
MIDSPAN SUPPORT
ax ay ax ay
SHORT LONG SHORT LONG
Moment Coefficients : #N/A 0.028 #N/A 0.037
Moments in KN-m = M : #N/A 0.8 #N/A 1.1
Factor Moments in KN-m = Mu = M x gf : #N/A 1.2 #N/A 1.6
Ast Required in mm2 : #N/A 35 #N/A 46
Min Area of Main R/f = 0.12%bD = 144 144 144 144
Diameter of Main R/f = f = 8 f 8 f 8 f 8 f
Provided Spacing in c/c : 150 225 #N/A 225
Corresponding Area in mm2 : 335 223 #N/A 223
DISTRIBUTION R / F :
Torsional R/f shall be provided at any corner where the slab is Simply Supported on both edges meeting
at that corner.It shall consists of Top & Bottom R/f , each with layers of bars placed parallel to the sides
of the slab and extending fron the edges a minimum distance of 1/5 of the shorter span
The Area of R/f in each of these Four layers shall be 3/4 of area require for the maximum mid span
moment in the slab.
Provide Square Mesh of 3 Nos of 8 mm dia as Torsional R/f of at each Corner at Top & Bottom
Provide Square Mesh of 2 Nos of 8 mm dia as Torsional R/f of at each Corner at Top & Bottom
DESIGN SUMMARY :
120
A
BARS IN LONGER DIRCTION
0.1 ly
B B
DIST BARS
(2 BARS MIN )
0.1 lx
Ly
BARS IN SHORTER DIRCTION
Ast =
#N/A
S
E
C
TI
O
N
A
- 0.5Ast min
A
Lx
120
A
NOTE : 1. BARS IN SHORTER DIRECTION SHALL BE PLACED BELOW BARS PLACED IN THE LONGER DIRECTION
2. ALL OTHER R/F ARE NOT SHOWN FOR CALRITY.
5 OF 7
6 OF 7
PREAMBLE : The One way slab is assumed to be subjectd Uniform Pressure intensity.
This Design Document represents Design of One Way Slab
SLAB SPECIFICATION :
MATERIAL SPECIFICATION :
DISTRIBUTION R / F :
DESIGN SUMMARY :