Professional Documents
Culture Documents
Karcher MV2 Manual PDF
Karcher MV2 Manual PDF
Operating Instructions
Before first use of the unit
read these operating instructions
and act in accordance with them.
w
w
w.
k
ae
rc
he
r.c
om
/re
gi
st
er
59651870 11/13
-a
nd
-w
in
12
2
3
Contents Environmental protection
General notes. . . . . . . . . . . . . . . . . .5 The packaging material can be
Safety instructions . . . . . . . . . . . . . .6 recycled. Please do not place the
Description of the Appliance. . . . . . .7 packaging into the ordinary refuse for
Commissioning and operation . . . . .8 disposal, but arrange for the proper re-
Maintenance and care . . . . . . . . . . .9 cycling.
Troubleshooting . . . . . . . . . . . . . . . .9 Old appliances contain valuable
Helpline . . . . . . . . . . . . . . . . . . . . .10 materials that can be recycled.
Technical specifications . . . . . . . . .10 Please arrange for the proper re-
cycling of old appliances. Please dis-
pose your old appliances using appro-
General notes priate collection systems.
Dear Customer, Disposing the filter
Please read and comply with The filter is made from environment-
these original instructions friendly materials.
prior to the initial operation of your ap- The filter can therefore be disposed off
pliance and store them for later use or through the normal household garbage
subsequent owners. provided you have not sucked in sub-
Proper use stances that are not permitted to be
thrown into household garbage.
In accordance with the descriptions Notes about the ingredients
and the safety information in these op- (REACH)
erating instructions the appliance is in- You will find current information about
tended for use as a multi-purpose vac- the ingredients at:
uum cleaner. www.kaercher.com/REACH
This appliance has been designed for
use in private households and is not in- Warranty
tended for commercial use. The terms of the guarantee applicable
– Protect the unit from rain. Do not in each country have been published
store outside. by our respective national distributors.
– This device may not be used to We will repair possible faults on your
suck in ash and soot. unit free of charge within the warranty
Please use this appliance only with ac- period, insofar as the faults are caused
cessories and spare parts approved by by material defects or defective work-
KÄRCHER. manship. Guarantee claims should be
The manufacturer is not responsible addressed to your dealer or the near-
for any damages that may occur on ac- est authorized customer service cen-
count of improper use or wrong opera- tre, and supported by documentary ev-
tions. idence of purchase.
(See address on the reverse)
English 5
Customer Service by children without supervi-
sion.
Our KÄRCHER branch will be pleased – Keep packaging film away
to help you further in the case of ques-
from children - risk of suffoca-
tions or faults.
tion!
Ordering spare parts and – Switch the appliance off after
special attachments every use and prior to every
At the end of the operating instructions cleaning/maintenance proce-
you will find a selected list of spare dure.
parts that are often required. – Risk of fire. Do not vacuum up
You can procure the spare parts and any burning or glowing ob-
the attachments from your dealer or jects.
your KÄRCHER branch office. – The appliance may not be
English 7
Commissioning and Wet vacuum cleaning
operation 몇 Caution:
Caution Do not use a filter bag!
Always work with an inserted Immediately switch the appliance off if
cartridge filter during wet as well foam forms or liquids escape!
as dry vacuum cleaning! Immediately switch the appli-
ance off or pull the power plug if
Attaching the Accessories foam forms or liquids escape!
Illustration Note: If the container is full, a float
Remove the appliance head and closes the suction opening, and the ap-
take accessories out of the contain- pliance works at a higher speed.
er. Switch off the appliance immediately,
Illustration and empty the container.
Fit the swivel casters on the con-
Finish operation
tainer bottom.
Illustration Illustration
Put the appliance head onto the Turn off the appliance and discon-
container and lock it. nect the mains plug.
Illustration Empty the container
Connect accessories. Illustration
Note: For vacuuming dry dirt or water Remove the appliance head and
off the floor - always work with the in- empty the reservoir.
sert (brush strip and rubber lip) in the
Storing the appliance
floor nozzle.
Illustration
Illustration
Stow away the mains cable and ac-
Connect the mains plug and turn on
cessory at the machine. Store the
the appliance.
appliance in a dry room.
Dry vacuum cleaning
Caution
Work with a dry cartridge filter
only!
Check the filter for damage prior
to installation and replace as
necessary.
Vacuum cold ashes only when
using a pre-filter.
Order no. basic design: 2.863-139.0,
premium design: 2.863-161.0.
8 English
Maintenance and care Troubleshooting
Danger Decreasing cleaning power
Turn off the appliance and re-
move the mains plug prior to any If the cleaning power of the appliance
deteriorates please check the follow-
care and maintenance work.
ing:
Repair works may only be per- Accessories, suction hose or suc-
formed by the authorised cus- tion tubes are clogged, please re-
tomer service. move the obstruction using a stick.
몇 Warning Cartridge filter is dirty, knock off dirt
Do not use abrasives, glass or from cartridge filter and clean under
universal cleaners! Never im- running water if necessary.
merse the appliance in water. Replace damaged cartridge filter.
Clean the appliance and accessory
parts made of plastic with a com-
mercial plastic cleaner.
If required, rinse the container and
accessories with water properly
and dry them before reuse.
Illustration
Only clean the cartridge filter under
running water; do not wipe or brush.
Let it dry completely prior to instal-
lation.
English 9
Helpline Technical specifications
Karcher (UK) Limited operate a hel-
pline allowing customers to discuss Mains voltage 220 - 240 V
any problems experienced with our 1~50/60 Hz
products. Mains fuse (slow- 13 A
The helpline operates during normal blow)
business hours, if you have difficulty
getting through, please understand Container 12 l
that there are peak periods during the capacity
day when our consultants are unable Water intake with 5,5 l
to take all calls coming in. In these cir- handle
cumstances we would ask that you try
to contact us again later in the day. Water intake with 3,0 l
floor nozzle
The helpline number is 01295 Output Pnom 1000 W
752200, open from 8.30am to
5.00pm Monday to Friday. Power cord H 05VV-F2x0,75
Weight (without 4,6 kg
It helps us if you have the model num- accessories)
ber and data plate details to hand be-
fore making your call. Sound pressure 77 dB(A)
level (EN 60704-
Alternatively you may write or E- 2-1)
mail to the address below:
Karcher (UK) Limited Subject to technical modifications!
Karcher House
Beaumont Road
Banbury
Oxon, OX16 1TB
E-mail:
info@karcher.co.uk
10 English