Professional Documents
Culture Documents
Battery Capacity
Battery Capacity
THE LOAD: 2 x 12V CCTV Cameras - rated at 5W Peak. During winter time
the cameras will make use of a 15W heater to keep camera protected from
the weather. Also in use is a 12V CCTV recording device and this is rated @
60W peak. It is assumed that the CCTV cameras and recording unit will
operate for 12 hours per day, 7 days per week.
Let's also assume that the equipment is drawing the peak power for the
entire 12 hours per day then we can work the calculations as follows:
CCTV = 2 x 5W x 12h per day = 120 Wh per day (for the cameras) plus
Recording Unit = 1 x 60W x 12 Wh per day = 720 Wh per day (for the recording unit) plus
Heaters = 2 x 15W x 12h per day = 360 Wh per day (for the camera heaters in winter)
Total Load (Wh) = 120 + 720 + 360 = 1200Wh per day or 1.2Kwh per day.
Allowing for a 20% safety factor and system losses means that we need to provide an average of 1440Wh per day on
average.
(Total Load x Days of Storage) / (System Voltage x efficiency after system losses)=
= (1440 x 5) / (12 x 0.8) or 750Ah at 12V.
There are many battery sizes available as we have used a 200Ah battery for
this example:
1. Determine total watt-hours per day required from your load calculation.
2. Determine the number of days of storage (backup) required. NOTE: 5
days storage is considered normal and this equates to the number of cloudy
days in a row.?This figure could be as low as 3 or as many as seven or even
14 depending on the location. Remote sites may be more or less that this.
3. Multiply line 2 by line 1. (storage x watt-hours).
4. Determine depth of discharge (DOD) of the battery. 80% should be
considered the maximum for deep cycle batteries.
5. Ensure that your batteries incorporate low temperatures by multiplying
the answer in line 4 by the factors shown in the table below using the lowest
expected weekly average temperature.
6. Find the watt hour capacity of your selected battery. Watt hours = voltage
x ampere hour capacity.?Example: GEL deep cycle,12 volts x 200 amp-hours
= 2400 watt hours
7. Divide line 5 by line 6.The result is the number of batteries required.
8. Round number of batteries to fit system voltage.
STEP DESCRIPTION EXAMPLE YOUR ACTUAL FIGURES
1. YOUR DETERMINED LOAD 2000 watt hours
2. YOUR REQUIRED STORAGE IN DAYS 5 days storage
3. WATT HOUR STORAGE REQUIRED 10,000
4. DEPTH OF DISCHARGE (DOD) 10,000 / 0.8 =12,500
5. INCLUDE OPERATING TEMPERATURE 12,500 x 1.19 = 14,875
6. YOUR BATTERY CAPACITY 2400 watt hours
7. NUMBER OF BATTERIES REQUIRED 6.19
8. NUMBER OF BATTERIES (ROUNDED UP) 8