Professional Documents
Culture Documents
MSDS 073 S
MSDS 073 S
SECTION 1 - IDENTIFICATION
PRODUSCT’S NAME : NEUTRON 073 S
( Syn Indusrial Open Gear & Cable Lubricant)
DATE PREPARED : 1st May 2003
PREPARED BY : Technical Engineer
NEUTRON LUBRICANT DIVISION
6304 Edgemont Boulevard 1
Broklyn Park, MN 55428 – USA
Telephone : 763-5357122 Facsimile : 763-
5319218
Email : neutron@alckin.com
website:www.alckin.com
EYES CONTACT : This product is minimally irritating to the eyes upon direct
contact. Based on testing of similar products and / or
components.
SKIN CONTACT : Avoid skin contact. This product is minimally imitating to the
skin upon direct contact. Prolonged or repeated contact may
result in contact dermatitis. Which is characterized by dryness,
chapping, and reddening. This condition may take the skin more
susceptible to other irritants, sensitizers, and disease. Prolonged
or repeated contact may result in all acne, which is characterized
by blackheads with possible secondary infection.
INHALATION : This product has a low vapour pressure and is not expected to
present an inhalation hazard at ambient conditions. Caution
should be taken to prevent aerosolization or misting of this
product. The Permissible Exposure Limit (PEL) and threshold
Limit Value (TLV) for this product as oil mist is 5 mg/m3.
Exposures below 5 mg/m3 appear to be without significant health
risk. The short-term exposure limit for this product as an oil mist
is 10 mg/m3. See health data section below.
EYES CONTACT : Rinse immediately with water for at least 15 minutes or until
imitation subsides. In case of eye imitation or material is hot, treat
bums and get medical attention.
INHALATION : This material has a low vapor pressure and is not expected to
present on inhalation exposure at ambient conditions. If Vapour or
mist is generated when the material is heated or handled, remove
victim form exposure.
INGESTION : Do not induce vomiting. Seek medical attention
US Federal Regulation
A : General product information : No additional information
B : Component Analysis
None of this products components are listed under SARA section 302 (40 CFR 355 Appendix
A).
SARA Section 313 (40 CFR 372.65), or CERCLA (40 CFR 302.4)
INSTRUCTION IN CASE OF FIRE OR SPILL : In case of fire. Use water spray, foam, dry
chemical or carbon dioxide. Water spray may be
ineffective but can be to cool containers. In case
of spill, do not use water, soak up with absorbent
material.
The Material safety data sheet complies with basic EU regulatory requirements for
Safety Data Sheets on the date of publication, and is intended for translation and
adaptation into European National documents. This document should NOT be relied upon for
compliance with the laws and regulations of individual countries without the appropriate local
translations and adaptations. It is your responsibility to ensure that any safety data sheet taken
or adapted from this system for re-distribution or use complies with all the laws and
regulations which apply to any such use or re-distribution.