Professional Documents
Culture Documents
Pel TP 00 Ins DS 012
Pel TP 00 Ins DS 012
00+000p
PEL-TP-00-INS-DS-012 DATASHEET FOR CONTROL VALVE Page 3 of 5
CLIENT APPROVAL
REV DATE DESCRIPTION PREPARED CHECKED APPROVED
BY DATE
0 8-Aug-16 IFB YF DW BA
1 6-Feb-17 IFB ND DW BA
TABLE OF CONTENT
00+000p
PEL-TP-00-INS-DS-012 DATASHEET FOR CONTROL VALVE Page 4 of 5
CLIENT APPROVAL
REV DATE DESCRIPTION PREPARED CHECKED APPROVED
BY DATE
0 8-Aug-16 IFB YF DW BA
1 6-Feb-17 IFB ND DW BA
GENERAL NOTE
1. Each individual instrumentation that include at control valve package, e.g. valve body, trim, actuator, regulator, positioner, etc.
Shall have a 316 SS label with information about P.O, S/N, material, manufacture, model and, size as minimum,
engraved in 1/4" minimum high lettering.
2. The label shall be permanently attached to each instrumentation using 316 SS screws or rivets.
3. Each Instrument shall supplied with SS identification tags.
4. Vendor shall furnish sizing calc. shall be as per ISA S75.01, indicating Rated CV, % travel, noise, trim size, body size,
valve type and valve characteristic, shall be provided for purchaser's review and approval.
5. The air filter regulator shall be suitable to handle 130% of maximum instrument air supply pressure.
6. All Control valves noise shall not exceed 85 dB (A) at points 3 feet away from the valve and 3 feet downstream.
7. Vendor is required to submit noise calculation and select anti noise trim to comply maximum noise 85 dBA.
If noise exceed
Vendor 85 dBA
shall provide and Choke/Cavitation/Flashing,
detail Vendor
data sheet of control valve and shall provide(actuator,
it's accessories special trim.
Regulator, Filter, etc),
8.
include catalogue and instruction manual.
9. Vendor shall provide calibration certificate and certificate of origin.
10. Vendor shall be responsible for the correct sizing and the model selection of control valve and pressure regulator valve.
JASA KONSULTASI PERENCANAAN PEKERJAAN INSTRUMENTASI TANKI STORAGE
CPO DI PERAK
00+000 p
PEL-TP-00-INS-DS-012 DATASHEET FOR CONTROL VALVE Page 5 of 5
CLIENT APPROVAL
REV DATE DESCRITION PREPRARED CHECKED APPROVED
BY DATE
0 8-Aug-16 IFB YF DW BA
1 6-Feb-17 IFB ND DW BA
33 Body / Bonnet Matl : (*) 73 Tag No. : TY-001 / 002 / 003 / 004 / 005 / 006
34 Liner Material / ID : N/A 74 Type : Electric to Pneumatic
35 End Connection In : ANSI 150#RF(*) 75 On incr. Signal output : Increased (*)
36 Out : ANSI 150#RF(*) 76 Gauge: Yes By-pass : N/A
POSITIONER
Note :
* VTA = Vendor to Advice ( Control Valvea are appplicted at Steam Process)
1 Vendor shall be responsible for calculate Required CV, Travel and Allowable / Predicted SPL.
2 TBA = To be Advice