This maintenance inspection checklist summarizes the inspection of electrical installation and maintenance equipment located in the practical work area. The inspection verified that the panel board, circuit breakers, cables, Mig guns, ground cables, gas cylinder outfits, and wire feeder were clean, dry, in good condition, and properly secured. Any equipment issues were reported to authorized personnel. The inspection was conducted by Telesforo Escoto and prepared by Jocelyn G. Esmeña.
This maintenance inspection checklist summarizes the inspection of electrical installation and maintenance equipment located in the practical work area. The inspection verified that the panel board, circuit breakers, cables, Mig guns, ground cables, gas cylinder outfits, and wire feeder were clean, dry, in good condition, and properly secured. Any equipment issues were reported to authorized personnel. The inspection was conducted by Telesforo Escoto and prepared by Jocelyn G. Esmeña.
This maintenance inspection checklist summarizes the inspection of electrical installation and maintenance equipment located in the practical work area. The inspection verified that the panel board, circuit breakers, cables, Mig guns, ground cables, gas cylinder outfits, and wire feeder were clean, dry, in good condition, and properly secured. Any equipment issues were reported to authorized personnel. The inspection was conducted by Telesforo Escoto and prepared by Jocelyn G. Esmeña.
Equipment Type : Electrical Installation and Maintenance
Location : PRACTICAL WORK AREA EIM Person-In-Charge : JOCELYN G. ESMEŇA Inspected by : TELESFORO ESCOTO Date of Inspection : APRIL 5, 2016
YES NO INSPECTION ITEMS
/ 1. Are the panel board and circuit breakers’ electrical
connections, cables, clean and dry? Parts are well- secured/attached, no cracks? Properly labeled?
/ 2. Are the Mig guns (nozzle, contact tip, diffuser) and
ground cables, clean and dry? Parts are well- secured/attached? In good condition?
/ 3. Are the adjustment lever’s amperages/speed
functional?
/ 4. Are the gas cylinder outfits (gate valve. Co2
regulator, gas hose fittings, cleaned and in good condition? No leaks? / 5. Are the wire feeder (rollers, wire speed adjustment, wire spool) free from dust, rust, oil? Dry? / 6. Is the equipment in good condition? If not, was a report prepared and submitted to authorized personnel?
Prepared by: Approved by:
Jocelyn G. Esmeña Telesforo Escoto JOCELYN G. ESMEŇA TELESFORO ESCOTO Trainer Head, Electrical Department