Professional Documents
Culture Documents
Glenium® Ace 30: Description and Field of Application Zero Energy System
Glenium® Ace 30: Description and Field of Application Zero Energy System
Glenium® Ace 30: Description and Field of Application Zero Energy System
®
• As compared to the traditional
GLENIUM ACE 30 is recommended for use at superplasticizers, the engineering properties
ambient temperature above 15°C. such as early and ultimate compressive and
flexural strengths, bond to steel, modulus of
elasticity, shrinkage, creep, and impermeability
are improved.
GLENIUM® ACE 30
Compatibility
GLENIUM®ACE 30 is compatible and added after all the other components are already in
recommended for use with: the mixer and after the addition of at least 80% of
®
• Glenium Stream admixtures to produce the total water. The water content is adjusted to
Rheodynamic concrete obtain the desired consistence or workability.
®
• Micro-Air , air entraining admixture, to improve
freeze thaw resistance (exposure class XF 1 to Packaging
XF4, EN 206 – 1) GLENIUM®ACE 30 is available in 200litre drums or
®
• Meyco MS 610, silica fume , for high in bulk.
performance concrete and increased durability
in chemical aggressive environments (exposure Storage
class XA1 to XA3, EN 206 – 1) GLENIUM®ACE 30 must be stored where
o
• Rheomac 100 for producing shrinkage temperatures do not drop below +5 C. If product
compensated concrete has frozen thaw and agitate until completely
• Mackure C, curing compound for protection of reconstituted. Store under cover, out of direct
fresh concrete to prevent rapid evaporation of sunlight and protect from extremes of temperatures.
water. N.B: GLENIUM®ACE 30 is not
® Safety precautions
compatible with the Rheobuild
GLENIUM®ACE 30 is not a fire or health hazard.
superplasticizers.
Spillages should be washed down immediately with
cold water. For further information refer to the
Dosage Rate
material safety data sheet.
The normally recommended dosage rate is 0.5 to
1.0 liters per 100 kg of the binder and any material
Note
(fines or fillers) passing the 0.1 mm sieve used for
Field service, where provided, does not constitute
producing Rheodynamic concrete.
supervisory responsibility. For additional
information contact your local BASF Construction
Other dosages may be used in special cases
Chemicals SA representative.
according to specific job site conditions. In this case
please consult our Technical Services Department.
Quality and care
All products originating from BASF Construction
Directions for use
Chemicals SA, are manufactured under a
GLENIUM®ACE 30 is a liquid admixture to be
management system independently certified to
added to the concrete during the mixing process.
conform to the requirements of the quality
The best results are obtained when the admixture is
standards ISO 9001/2000.
Whilst any information contained herein is true, accurate and represents our best knowledge and experience, no warranty is given or
implied with any recommendations made by us, our representatives or distributors, as the conditions of use and the competence of any
labour involved in the application are beyond our control.
As all BASF’s technical datasheets are updated on a regular basis it is the user's responsibility to obtain the most recent issue.
BASF Construction Chemicals South Africa (Pty) Ltd
P.O. Box 420, Westonaria, 1780 852 Sixteenth Road, Midrand
11 Pullinger Street, Westonaria, 1779 PO Box 2801, Halfway House, 1685
Tel: +27 11 754 1343 Tel: +27 11 203 2405
Fax: +27 11 754 1105
Website : basf -cc.co.za