Professional Documents
Culture Documents
Special Features Description: Hri Dataunit
Special Features Description: Hri Dataunit
More than 10-year battery life The HRI is more than an extension of a simple sensor. It
has been expanded to provide a reliable data source for
Hermetically-sealed housing (IP68) remote reading of a conventional meter. It is the interface
for all today’s requirements for data interrogation and
remote transmission.
Applications
Route-planned meter reading for billing, for Leakage detection when connected to a data logger.
example mobile reading systems.
Generation and transmission of flow profiles using a data
Load profiles via a fixed network using M-bus logger and GSM/GPRS modem.
or via radio, telephone or GSM/GPRS Modem.
The design of the HRI allows the system to be installed in
Industrial application e.g. dosing. extreme conditions, such as flooded meter pits.
System Overview
Fixed Network
GSM/GPRS
Telemetry Center
HRI
WaterMeter
Technical Data
Cable length 1.5 m
Temperature range
- Storage: -20° to +65° C
- Operation: -10° to +65° C
Divisor
HRI PulseUnit
Depending on the application, the HRI PulseUnit can be offered in four modes: Mode A1, A2, A3 and A4.
HRI DataUnit
The HRI DataUnit has an interface to read out the data and subsequent configuration. It also works as a PulseUnit, but is
programmable in the field.
Order Information
HRI PulseUnit HRI DataUnit
Mode and Divisor are factory-set according tocustomer’s All settings are programmable in the field.
specification
. - Default setting*:
- Default setting*: Mode A1, Divisor = 1 Mode = B1,
Divisor = 1,
Meter number = HRI production number,
Counter start = 0,
Unit = m3
* Please specify, when ordering, if settings are to be different
from the above.
Scope of Delivery
Installation and operating instructios - HRI
Delivery parts - 1
HRI sensor, Bayonet ring, Cut Meter lid, 2 screws, 2 screw seals,
1 adhesive seal
1
Installation:
Just before mounting the HRI on the meter it is essential to
remove the aluminum foil at the bottom side. A screwdriver
Torx (T8) or Slot (3.5*0.6) is recommended for mounting. The
torque should be 0.6Nm 1
2 4
Meters with plastic register - 2 2
3
Change the lids and put the HRI on the meter, so that the two pins
on top of the register fit exactly into the holes at the bottom of the
6
HRI. Fit the two screws. For tamper protection fit the plastic seals
on top of the screws. The bayonet ring and the adhesive seal are 5
not used for this register type.
Type - 4
Depending on the order specification, HRI can be delivered in four
different pulse modes
HRI Pulse Unit: Type A1, A2, A3 and A4
HRI Data Unit: Type B1, B2, B3 and B4 4
with following pulse weights:
Ground (brown)
Technical data:
• Temperature range
Storage: -20° to +65° C
Operation: -10° to +65° C
• Cable length: 1,5 m
• Hermetically-sealed housing IP 68
• EMC acc. EEC directive 98/34 equal European standards
EN61000-6-1