Professional Documents
Culture Documents
Hama Bead Christmas Tree & Presents: Project Sheet
Hama Bead Christmas Tree & Presents: Project Sheet
CHRISTMAS
TREE &
PRESENTS
Nº 06 . 20.02
PROJ EC T SHEE T
SHOW US WHAT
YOU’RE MAKING
/spotlightstores
@spotlightstores
HAMA B E AD CHRISTMAS iron the project. When ironed properly, the
beads will still have open centers. DO NOT
TRE E & PRESE NTS
OVER-IRON as this will cause the beads
to close and can make assembly of your
E ASY
project more challenging. Let the design
cool.
WHAT YOU’LL NEED
Step 3 – Remove the paper and bead design
• Hama Large Square Pegboard from the pegboard. Flip the design over to
• Hama Beads expose the non-fused side. Repeat step two.
• Iron Let cool completely. Once the design is cool,
peel off the ironing paper. Your pegboards
• Baking paper
and ironing paper are reusable.
INSTRUCTIONS Note: Beads need heat for about 10-20
TREES seconds per side to fuse evenly. Lift the
paper occasionally to see how the beads
Total Bead Colors Needed
are fusing. Additional heating time may be
• Magenta – 3 required.
• Red – 108 Step 4 – Assembly – For the natural tree,
• Cheddar – 7 turn the feet at right angles to the tree and
• Hot Coral – 65 slide onto them onto the tree’s lower edge.
For the decorated tree, first connect the five
• Yellow – 23
base pieces as shown here. Push the two
• Prickly Pear – 40 side segments into the center slots of the
• Pastel Green – 60 tree. Gently insert the tree into the base as
• Kiwi Lime – 103 shown.
The information on this project sheet is presented in good faith, but no warranty
is given, nor results guaranteed. Quantities and selections may vary at each store.
Copyright Spotlight 2019.
will cause the beads to close and can make PRESENT BOX TEMPLATE
assembly of your project more challenging.
Let the design cool for 1 minute.
Step 3 – Remove the paper and bead design
from the pegboard gently. Repeat step 3
if the beads have not fully fused. For the
remaining design, repeat step 2 & 3. Let cool
completely before assembling. Pegboards
and ironing paper are reusable.
Step 4 – Assembly – First connect the five
base pieces for the box. For the lid, put
together the bow first and then insert into
the lid. Place lid on top of box and now you
have a 3D Christmas present.
TECHNIQUES
Do not add water to your iron, the steam will
ruin the beading during the fusing stage.
Bead Colour/Number Needed
Beads need heat for about 10-20 seconds
White = 53 Red = 118
per side to fuse evenly. Lift the paper
occasionally to see how the beads are
PRESENT LID & BOW TEMPLATE
fusing. Additional heating time may be
required.
The information on this project sheet is presented in good faith, but no warranty
is given, nor results guaranteed. Quantities and selections may vary at each store.
Copyright Spotlight 2019.
TREE SIDE 1 TEMPLATE TREE SIDE 2 TEMPLATE
The information on this project sheet is presented in good faith, but no warranty
is given, nor results guaranteed. Quantities and selections may vary at each store.
Copyright Spotlight 2019.