Professional Documents
Culture Documents
Flow Between Parallel Plates
Flow Between Parallel Plates
html
Next: Flow Down an Inclined Up: Incompressible Viscous Flow Previous: Introduction
transverse coordinate such that the plates are located at and . (See Figure 10.1.)
Suppose that there is a uniform effective pressure gradient in the -direction, so that
(10.4)
where is a constant. Here, the quantity could represent a gradient in actual fluid pressure, a gradient in
gravitational potential energy (due to an inclination of the plates to the horizontal), or some combination of
the two--it actually makes no difference to the final result. Suppose that the fluid velocity profile between the
plates takes the form
(10.5)
From Section 1.18, this profile automatically satisfies the incompressibility constraint , and is
also such that . Hence, Equation (10.2) reduces to
(10.6)
1 of 3 20-03-2020, 13:46
Flow Between Parallel Plates http://farside.ph.utexas.edu/teaching/336L/Fluidhtml/node134.html
(10.7)
If the two plates are stationary then the solution that satisfies the no slip constraint (see Section 8.2),
, at each plate is
(10.8)
Thus, steady, two-dimensional, viscous flow between two stationary parallel plates is associated with a
parabolic velocity profile that is symmetric about the midplane, . The net volume flux (per unit
(10.9)
Note that this flux is directly proportional to the effective pressure gradient, inversely proportional to the
fluid viscosity, and increases as the cube of the distance between the plates.
Suppose that the upper plate is stationary, but that the lower plate is moving in the -direction at the
constant speed . In this case, the no slip boundary condition at the lower plate becomes ,
(10.10)
Hence, the modified velocity profile is a combination of parabolic and linear profiles. This type of flow is
known as Couette flow, in honor of Maurice Couette (1858-1943). The net volume flux (per unit width) of
fluid between the plates becomes
(10.11)
2 of 3 20-03-2020, 13:46
Flow Between Parallel Plates http://farside.ph.utexas.edu/teaching/336L/Fluidhtml/node134.html
Next: Flow Down an Inclined Up: Incompressible Viscous Flow Previous: Introduction
Richard Fitzpatrick 2016-03-31
3 of 3 20-03-2020, 13:46