Professional Documents
Culture Documents
Training H2S Model 903 Galvanic
Training H2S Model 903 Galvanic
Training H2S Model 903 Galvanic
Model 903
Common Methods of On-Line
Measurement of H2S
Lead Acetate
UV Absorption
Tunable Diode Laser
H2S Electrochemical Sensor
Gas Chromatograph
How Does A Lead Acetate
Tape H2S Analyzer Work?
Wide Range 0-2000 ppm
Sample Gas with H2S exposed to the tape reacts to turn the
tape brown.
Sensor utilizes a visible LED light onto the tape. As the tape
browns light is absorbed.
Sensor measures the “Rate of Change” over time as to how
brown the tape turns.
Higher concentrations of H2S would turn the tape
brown/black to quickly.
We would utilize a dilution system to establish a ratio of
diluted H2S to the analyzer.
Communication/Interface
6 - 4-20mA outputs (isolated and scaled to range)
3 - SPDT alarm relays 5 amps @ 30 VDC or 8amps
@ 120/240 VAC (up to 3 more optional)
1 - 3 amp max 35 VDC or 3A 24-280 VAC Solenoid
Driver (standard), up to 7 more (optional)
1 - USB port
1 - RS-232 Serial Port
1 - RS-485 isolated serial Port
1 - LAN Port for extended analog outputs
1 - Ethernet (optional)
Modbus communication on all ports
Lead Acetate
Considered “old” technology – but with the
advancements in electronics the Lead Acetate Analyzers
now has a very fast response to an H2S alarm. (RRA)
Requires a tape change every 5 to 14 weeks
Lead acetate is interference free. (This is why it is used
by the vast majority in the industry when accurate
measurement is required)
Cost effective with very fast delivery times
Lowest Power – 10 Watts (24VDC or 120-240VAC)
Simple Design. Easy to operate and maintain
The linear output enables the user to perform a single
point calibration
Commonly Observed Problems
Commonly Observed Problems