Professional Documents
Culture Documents
LMS - Design Philosophy
LMS - Design Philosophy
TYPE OF
Area FLOOR LIGHT No. of zones Floor Scheme STRATEGIES Field Devices Occupancy
(Receiver devices (QSMs) are
not counted here
Please note that apart from the various below details all the areas can be controlled and monitored from the LMS GUI software. Also, the time limits of the sensors can be set from area to area based on client requi
the coverage, if required. Further, high end trim can be done at any %, 80% is indiacted just as a case.
* OCCUPANCY
Lights automatically turn on to 80% (or
* DAYLIGHT HARVESTING
All typical floors and any depending upon lux level reqd) when
AS PER DRAWINGS *TIMECLOCK BASED/*SCHEDULING OCCUPANCY SENSOR, DAYLIGHT
Typical open office area non typical floors open DALI DIMMABLE the user enters the Area and turns off 5
*HIGH END SENSORS
office areas minutes (or any minute more than 1)
TRIMMING *FAVORITE
after the area has been vacated.
SCENE SELECTION
* OCCUPANCY * DAYLIGHT
Lights automatically turn on to 80% when
HARVESTING
RECEPTION, INTERVIEW All floors DALI DIMMABLE AS PER DRAWINGS OCCUPANCY SENSOR, DAYLIGHT the user enters the area and turns off 5
*TIMECLOCK BASED
ROOMS SENSORS minutes after the room has been
SCHEDULING
vacated.
*HIGH END TRIMMING
HY
set from area to area based on client requirement. (minimum 1 min.). Apart from this sensor masking would be done to limit
- NA - -
- NA - -
Dimmed lights are controlled in this area NA - As per office timing light control can be
preset