This document contains instructions for a student to complete an end of chapter assignment on electronic circuits in Multisim software. The student is asked to: 1) Draw a circuit diagram; 2) Run a simulation to view input and output waveforms using an oscilloscope; 3) Record results for time and frequency; 4) Compare the output frequency to theoretical calculations; and 5) Identify the type and name of the circuit. The assignment is out of 50 marks and contains 5 questions.
This document contains instructions for a student to complete an end of chapter assignment on electronic circuits in Multisim software. The student is asked to: 1) Draw a circuit diagram; 2) Run a simulation to view input and output waveforms using an oscilloscope; 3) Record results for time and frequency; 4) Compare the output frequency to theoretical calculations; and 5) Identify the type and name of the circuit. The assignment is out of 50 marks and contains 5 questions.
This document contains instructions for a student to complete an end of chapter assignment on electronic circuits in Multisim software. The student is asked to: 1) Draw a circuit diagram; 2) Run a simulation to view input and output waveforms using an oscilloscope; 3) Record results for time and frequency; 4) Compare the output frequency to theoretical calculations; and 5) Identify the type and name of the circuit. The assignment is out of 50 marks and contains 5 questions.
DEE 3043 – ELECTRONIC CIRCUITS END OF CHAPTER (EOC) NAME AND : MATRIX NO. : CLASS : DET3B TOTAL (_/50
Answer All Questions
Figure 1
1. By using Multisim Software, draw the circuit in Figure 1.
(10M) 2. To view the waveform of DC input and AC output, place oscilloscope component at input and output. Running the simulation and display your input and output waveform for your result. (20M) 3. Based on output waveform, record your results : Time = 82.578us Frequency = 12.11kHz (10M)
4. Compare your output frequency with calculation theory.
(5M)
5. State the type of circuit above and name of the circuit.