Professional Documents
Culture Documents
Visit For More DIY Projects
Visit For More DIY Projects
com
Legal:
The content of this guide may not be sold, modified, or distributed in anyway without the expressed
written consent of the publisher. Reprinting, copying, or any other form of distribution for commercial
or non-commercial purposes is strictly prohibited and will be prosecuted.
Disclaimer:
Every attempt has been made to provide the most accurate information as possible. However, the
publisher accepts no liability for any wrong information as a result of purchasing and / or reading this
guide.
You can follow this guide at your own risk the publisher accepts no responsibility for any injury to any
person.
Copyright © www.Construct101.com
ISBN-13:
ISBN-10:
Cut eight 6×6’s to 12′ long (A), square the area and install as showing above. Poles are buried 2′ deep.
Cut two 6×6’s to 16′ long (B). Notch and install as shown above, pre-drill all holes and secure with 4 1/2″
screws.
Cut two 6×6’s to 16′ long (C). Notch 5 1/2″ x 2 3/4″ deep, install as shown above, pre-drill all holes and
secure with 4 1/2″ screws.
Cut two 6x6 to 5' long (D). Cut one 6x6 to 16' long (E) and notch 5 1/2" x 2 3/4" deep as shown in
illustration above. Pre-drill all holes, install as shown on illustration above using 4 1/2" screws.
Cut eighteen 2×6’s to 11′ 1 7/16″ long (F) for the rafters. See illustrations below for details.
Install the rafters 24″ O.C. pre-drill all holes and secure with 3 1/2″ screws.
Cut sixteen 6×6’s to 3′ long (G), cut 45-degree angle cuts on both ends. Pre-drill all holes and install as
shown on illustration above using 4 1/2″ screws.