Professional Documents
Culture Documents
PLXDRMM1862 R410A Inv Wall Mounted 50Hz (Myanmar) CO - FTKQ V12 PDF
PLXDRMM1862 R410A Inv Wall Mounted 50Hz (Myanmar) CO - FTKQ V12 PDF
FTKQ Series
What is Inverter
An Inverter is energy saving technologythat eliminates wasted operation in air conditioners by efficently contolling
motor speed.
Comfort
Daikin Swing Compressor
Needs Proposals
Normal operation
Handles from
150 V to 440 V Max.
Power consumption
440 V
150 V
Econo Mode
When the voltage is higher or lower than the operable range, the air Time
conditioning system switches itself off. When the voltage is adjusted back
to its original value, the system automatically starts operating again. Maximum capacity decreases during Econo Mode, requiring
more time to reach the set temperature.
• Outdoor come with anti-corrosion heat exchanger fin. • R32 does not deplete the ozone layer unlike R22.
• Surface coated with a thin acrylic resin layer to provide • R32 is 1/3 lower in gobal warming potential comparing
enhanced resistance to acid rain and salt corrosion. with R410A.
• R32 has 9 % lower liquid density compared to R410A. In
a same system, R32 charge is lesser than R410A.
• R32 is single component refrigerant which makes it
Cross section of anti-corrosion treated fin
easy to repair and top up.
Hydrophilic film
Aluminium • R32 has the same pressure as R410A enable the installer
Corrosion-resistant to reuse the same copper pipe.
acrylic resin
in GWP R32
(HFC)
1,810
675
CO2
1
Specifications FTKQ Series Cooling Only
Measurement conditions
1. Cooling capacity is based on: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; piping length 7.5 m.
2. Sound pressure levels are measured in an anechoic chamber based on the temperature conditions in 1 above. These are anechoic conversion values. These values are
normally somewhat higher during actual operation as a result of ambient conditions.
Specifications, designs and other content appearing in this brochure are current as of January 2019 but subject to change without prior notice. © All rights reserved.