Professional Documents
Culture Documents
ADT Home Security Starter Kit: Setup Guide
ADT Home Security Starter Kit: Setup Guide
GUIDE,QUICK START,NOVA - NORTEK P/N: 10016840C- INK: BLACK PLUS PMS 286C - MATERIAL: 105G COATED PAPER - SIZE: 127MM X 142.24MM -
SCALE: 1-1 - BINDING: TRIM, FOLD AND SADDLE STITCHED - PAGE 1 OF 30
RT HER
STA
E
Welcome to your W
l
ADT Home Security Starter Kit
I
S
a
We're here to help you protect your home and your family, so
let's get started with a few simple steps.
E Troubleshooting
1. Place the ADT Security Hub in an area of your home that has
good Wi-Fi and cellular coverage. Avoid placing it in direct
sunlight, near heat sources, where it can be easily viewed
from doors or windows, or where it can be reached by small
children.
2. Attach the desk mount to the ADT Security Hub and tighten
the mounting plate screw.
Power Receptacle
Mounting Screw
ADT Security Hub
Power Receptacle
Power Connector
Adhesive Tape
Fastening Screw
Retaining Bracket
Power Plug
ADT Security Hub
• Spread the edges of the bracket apart and insert the power N
plug into the power outlet. Thread the zip ties through the V
slots and fasten them to secure the power plug.
Zip Tie
Slots
ADT Security Hub
Note: You can also mount the ADT Security Hub on a wall.
Visit SmartThings.com/Support-ADT for more information.
B Setup your ADT Door and Window Detectors
2. Take the first ADT Door and Window Detector to the door
or window where you intend to mount it. Make sure you are
within 350 feet of the ADT Security Hub.
Detector (Back)
QR Code
ADT Door and Window Detectorss
Battery Tab
ADT Door and Window Detectors
Placement on doors:
Door Frame
Placement on windows:
Magnet
Magnet
Spacer
ADT Door and Window Detectors
Magnet
Spacer
30 Feet Range
0o
60o
2. Take the ADT Motion Detector to the area where you intend
to mount it. Make sure you are within 350 feet of the ADT
Security Hub.
QR Code
Battery Tab
6. Pick a location 6.5 to 7.5 feet above the floor and mount the
detector on a flat wall or in a corner.
Corner Mount
Wall Mount Bracket
Detector (Back)
Detector (Front)
ADT Motion Detector
2. Press and hold the button. The red LED will begin to blink
quickly, and after a short period of time it will stay on.
3. Release the button and after 5 seconds the red LED will
begin to blink slowly.
If the ADT Motion Detector did not pair successfully with the ADT W
Security Hub, follow these instructions to reset it: 2
f
1. Remove the back of the detector
U
2. Press and release the Tamper Switch on the detector twice.
s
3. Press and hold the Tamper Switch. The red LED will begin to
blink quickly, and after a short period of time will stay on.
Tamper Switch
4. Release the Tamper Switch and after 5 seconds the red LED
will begin to blink slowly.
5. Use the SmartThings app to complete setup.
Your ADT Home Security Starter Kit is now setup and ready to use.
Read the enclosed ADT Security Hub User Guide for important
information on using your ADT home security system and make
sure to keep it safe for future reference.
P/N 10016840C