This document provides instructions for a lathe group setup challenge. The challenge is to open the file "MCU Challenge CAM Setup.mcam", select a default lathe machine, and properly set up the stock with an outer diameter of 2.25in, length of 4.25in, 0.125in of excess stock, and a chuck grip length of 1.5in. The program number should be set to 12005 and shade boundaries should be turned on.
This document provides instructions for a lathe group setup challenge. The challenge is to open the file "MCU Challenge CAM Setup.mcam", select a default lathe machine, and properly set up the stock with an outer diameter of 2.25in, length of 4.25in, 0.125in of excess stock, and a chuck grip length of 1.5in. The program number should be set to 12005 and shade boundaries should be turned on.
This document provides instructions for a lathe group setup challenge. The challenge is to open the file "MCU Challenge CAM Setup.mcam", select a default lathe machine, and properly set up the stock with an outer diameter of 2.25in, length of 4.25in, 0.125in of excess stock, and a chuck grip length of 1.5in. The program number should be set to 12005 and shade boundaries should be turned on.
This document provides instructions for a lathe group setup challenge. The challenge is to open the file "MCU Challenge CAM Setup.mcam", select a default lathe machine, and properly set up the stock with an outer diameter of 2.25in, length of 4.25in, 0.125in of excess stock, and a chuck grip length of 1.5in. The program number should be set to 12005 and shade boundaries should be turned on.
Lesson Challenge: Open the supplied file “MCU Challenge CAM Setup.mcam”. Select a default lathe machine and properly set up the stock and program number. Program number should be 12005 and the stock should be 2.25in OD and 4.25in length with 0.125in of stock on the end of the part. Chuck should have a grip length of 1.5in. Shade boundaries should be on.