Professional Documents
Culture Documents
TIB427 - Spitfire 100 Extreme - New Firmware SE6.01
TIB427 - Spitfire 100 Extreme - New Firmware SE6.01
Dear Customer,
There is a new firmware version (SE 6.01) for the Spitfire 100 Extreme series printers. Please read this
Technical Information Bulletin to know what the new features are, which items have been changed and
which bug fixes have been made.
Important
Please note that firmware SE 6.01 introduces a set of new features that are not backwards
compatible. After upgrading to SE 6.01, returning to firmware SE 4.04 or older firmware will
not be possible.
Support and specific weaving patterns for MS Ultra ink have been implemented.
You must select the MSUltra Weaving Engine when using MSUltra Ink
When “InkManager” ==> “InkKind” is set to “Ultra”, a new “WeaveEng.” option appears in the
“Utility” menu.
In time selection menus for ink charge / discharge (SetupMenu ' InkManager ' Charge/Dis) and
carriage interval time (SetupMenu ' PrintMode ' PrnModeX ' RepeatPrn. ' IntervalTime), the
abbreviation for “seconds” was changed from “sec” to “s”.
As of SE6.01, the firmware generates a more descriptive message, instead of a CPU error, when
a chip problem occurs.
Specific errors:
E[55]: no chip detected
E[27]: unactivated service chip
Some of the bars were printed using the wrong nozzle rows. Corrected.
Please note: to start up in diagnostics: you must press the F2,F4 and DOWN key at the moment
you start the machine! When the text “Ink Jet Printer” appears, it is too late!
Hold down the keys until you hear a “beep” from the RJ mainboard.
In previous versions, after cutting media, the printer sometimes checked media presence too
early, resulting in an incorrect “Paper Cut Error”.
After cutting media, when trying to perform another action too soon, sometimes the printer would
not perform anything anymore. Fixed.
When choosing “Initial” ==> “Utility”, the “CoverFan” setting changed to “Off”, but the fans did not
stop. Now, they do.
When “OnCleaning” is enabled, previous versions would perform the cleaning even when the
wrong cartridges (e.g. wrong colours in some slots) were loaded. Ink would be mixed
unintentionally. The new version will not perform that cleaning.
CPU error
When “ManualCut” was On, and media measurement set to “Roll LeftRightTop”, there was a
CPU error when performing slant check after printing Setup list.
This has been fixed.
When the Feed Adjust parameter is invalid due to parameter problems, the printer could crash
when entering the Cut&Feed menu ' Crash avoided.
When a heater test was running, it was possible to return to the setup menu by pressing ENTER.
Then, you could start another heater test. It made things go wrong, for example “Error
WrongSensor” could happen.
Now, it is not possible anymore to return to the main menu while the heater test is running.
Additionally, when the test is finished, the text “press ENTER” is displayed.
When a printer chip was defect, it was not possible to activate a new service chip. This problem
is now fixed.
The media load procedure can now be cancelled when the “Please remove retainers” screen
appears.