Professional Documents
Culture Documents
Programmable Counter/Timer: Flow Chart For Function Setting Mode
Programmable Counter/Timer: Flow Chart For Function Setting Mode
(C)
Parameter group1 ,
Parameter group2 Door/Area
sensor
(GRp1) (GRp2)
※3
Counter Timer (D)
(COUN) Counter/Timer (T1ME) Proximity
sensor
(C-T) Communication
※3 ※3 (E)
Input mode Time range Com. address Pressure
sensor
(IN) (HOUR/MIN/SEC) (ADDR)
※3 ※2 ※3 (F)
Rotary
Output mode Up/Down mode Com. speed encoder
Decimal point ※3
(COmW)
(DP) (L)
OUT1 output time Panel
meter
(OUT1) ※1: Indicator
Min. reset time ※2: Output type (M)
(RST) ※3: If changing the setting Tacho/
Input logic Speed/ Pulse
(SIG) value of function, OUT1, meter
※Press key over 3sec./5sec. in RUN mode to enter into parameter 1 group/ parameter 2 group.
Press key over 3 sec. in function setting mode to return RUN mode.
※Input operation and output control can be set in function setting mode.
※If changing set value of ※3 marked parameters in function setting mode, OUT1 and OUT2 output will be turned OFF and
then the current value is reset.
※Parameter 2 group is not available to non-communication models.
J-17
CT Series
Parameter setting(Counter)
( key: To select setting mode, or key: To change setting value)
Setting mode How to set
Counter/Timer ※CONE: COUNTER
ㅊㅊC-T COUN TIME TIME: TIMER
※Counting speed is that of one by one(1:1) duty ratio of INA or INB input signal,
Max. counting speed
30 1K SY 10K 1 and it is applied in INA and INB at thesame time.
CPS ※In case of setting D in output mode, you can choose 1cps, 30cps, 1Kcps.
: To shift flashing digit position of OUT2 ※Set OUT2 one-shot output time.
OUT2 output time
output time value. ※Setting range: 0.01 to 99.99 sec.
OUT2
: To change OUT2 output time value. ※It does not appear if F, N output mode is selected.
: To shift flashing digit position of OUT1 ※Set OUT1 one-shot setting time
OUT1 output time ※Time range: 0.01 to 99.99 sec., Hold
output time value.
OUT1 ※HOLD is displayed by pressing key 4 times.
: To change OUT1 output time value.
● 6digit type
------ -----.- ----.-- ---.--- --.---- -.-----
※1
Decimal point
● 4digit type ※Setting the decimal point is applied same to counting
DP ---- ---.- --.-- -.--- value and setting value.
● 6digit type
※1
Prescale
decimal point ● 4digit type ※Prescale decimal point position is not set below the decimal
ScDP point setting digits (DP).
J-18