Professional Documents
Culture Documents
Serial COnnect ILO Port
Serial COnnect ILO Port
You configure the iLO port to access the iLO console through a web browser. The
iLO console provides out-of-band remote server management and access to
advanced management options. Your configuration steps mayinclude configuring
IPv4, modifying the default static IP address, enabling DHCP, or changing the
default user
name and password.
The server is pre-configured with a default, static IP address to access iLO
(192.168.0.120). The iLOdefault user name and password are found on the label
attached to the top of the chassis. The user name isAdministrator and the
password is an eight-character alphanumeric string.
Procedure
1.Connect an Ethernet cable from the Ethernet port on the laptop to the iLO Ethernet port on
the rear of the
server.
2.If necessary, change the IPv4 address of the Ethernet port on your Windows laptop:
a) Open Network and Sharing Center in the Control Panel and click Change adapter settings
b) Locate the icon for the Ethernet adapter, right-click it, and then select Properties. This is
typically a Local
Area Connection.
c) Select Internet Protocol Version 4 (TCP/IPv4) and click Properties.
d) Record the current settings on the General tab so that you can restore them later.
e) Check the button labeled Use the following IP address.
f) Enter an IP address in the range 192.168.0.[0-255], excluding 192.168.0.120.
g) Enter a subnet mask of 255.255.0.0.
h) Close the dialogs and exit from Network and Sharing Center.