Professional Documents
Culture Documents
Detergent Powder Formula PDF
Detergent Powder Formula PDF
Formula
How to make Detergent Powder?Detergent powder making Formula / Recipes
Sunday, 16 December 2012
How to do it?
The procedure is very simple. Here it is:
Divide the 800 milliliter of water into half. Set aside the other half.
On the other half of the water, add the zenamix into it. Make sure that the zenamix is mixed and
fully dissolved evenly into the water.
When the mixture is done, add the color that you prefer for your dish washing liquid. Mix the
color well. You can add more color the way you want it to appear
Add the 1.5 milliliter scent. Constant mixing can help spread the scent all over the solution.
Add the other half of the water. Mix the solution well in constant speed.
Apply the visco plus. Constant stirring is needed after the visco plus has been added.
Add another 100 milliliter of water in the solution.
Mix well in constant speed. You would know when your dish washing liquid is ready because it
would appear smooth and creamy.
There are many other ways in producing dish washing liquids. Some uses borax, grated bar soap and
washing soda. The process in using these ingredients is different from the above process. With these
ingredients, you need to use heat as if you are cooking the soap. The borax and washing soda will be
added right after the soap is dissolved. Constant stirring is again needed in here.
These are the important things that you need to have for making dish washing liquids: water and a
mixer for constant stirring. These are very important that one should prepare.
Probably the biggest reason to make your own laundry detergent is that it is extremely cost effective. And
when you are doing laundry for a family of nine, seven of whom are rowdy, muddy boys, sometimes
covered in carrots, you need cost effective!!
There are a ton of recipes out there to choose from, but I chose to start with the one from the detergent
powder website.
I made the concentrated solution and threw a few loads in to test it out according to their
recommendations. Uncertain, I did a little more looking, and explored another similar version at The
Simple Dollar.
Between those two basic recipes, I realized that you can dilute the mixture as much or as little as you
wish. The detergent powder family makes ten gallons. The other guy at The Simple Dollar makes three.
They both cost roughly the same.
What to do???
I have a front loader, and assumed from the start, that I had better dilute it according to directions. (Have
you ever put too much detergent in one of those machines?!? The results can be a bit overwhelming.)
But I watched at different phases of the cycle, and noticed that I never really saw a lot of suds. At one
point, I “paused” my washer, opened the door, and ran my hand through the water, just to be sure that
there was, in fact, detergent in the washload. There was, and the clothes came out smelling clean, but I
am still leaning toward using a more concentrated amount.
I filled my empty store bought laundry detergent dispenser with 1/3 water and the rest with my homemade
detergent.
What to do:
1. Boil 4 cups water on stove and add the grated soap, slowly, stirring until melted.
2. Fill a five gallon bucket half full of hot tap water.
3. Add melted soap, laundry soda, and borax. Stir.
4. Fill to the top with more hot tap water and stir again.
5. Allow to sit overnight.
6. Fill a large laundry detergent dispenser 1/3 to 1/2 full of water, and fill the rest of way with detergent
mix. Shake container before each use.
7. Use as much or little for each individual load as you prefer. I used 1/4 cup at first, then tried 1/2 cup
and even 3/4 cup and had no problems. Depends on size of load.
Let’s come to know how to make detergent powder. By this blog you can start your own business
of detergent powder.
Recipe
Blend no .1 :- Mix the Sodium carbonate and sodium choroid for 5 minute with machine speed 35 RPM.
Then Add EDTA dye sodium for 1 minute with machine speed 45 RPM. Then mix all the ingredients with
Sodium Perboret monohydrate , Carboxyl Methyl Cellulose Costic Soda.
Blend no .2 :- Mix the Labsa ( Acid slurry ) and Hot water for 15 minute with 10 RPM Speed. After 15
minute this ingredients will be thick. To remove color of labsa (LINEAR ALKYLBENZENE SULFONIC
ACID ) add Cbx.
Then mix the blend no. 1 and blend no. 2.And keep in blender machine till 5 min with 35 RPM machine.
After blending these materials add stain remover and speckle.
Then put this material in dryer machine. Keep it in 60 Degree till 10 minute. And powder is ready to sale.
You can pack in different packing.