Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 11

I.

Identification

1. Zone considered to extend out from the antenna to a distance of pi(D^2)/8λ.


_______________________________________

2. Yagi-Uda antenna is a _____ antenna.


_______________________________________

3. Zone considered to extend out from the antenna to a distance of 2(D^2)/λ.


_______________________________________

4. It is also called as input impedance.


_______________________________________

5. It is also called as the “near field”


_______________________________________

6. Yagi-Uda antenna is developed by


_______________________________________

7. It is also called as the “far field”


_______________________________________

8. It states that the pattern, directivity, aperture, and terminal impedance of antenna are the same when it is used
as transmitting or receiving antenna.
_______________________________________

9. It is the zone between two regions


_______________________________________

10. It is a highly _____ antenna, and highly _____ antenna.


_______________________________________

11. If the obstruction is at ____________, the reflected signal and direct signal will have a phase addition thus, the
received signal is “maximum”
_______________________________________

12. It is a graph showing the actual or relative field intensity at fixed distance as a function of the direction from the
antenna system.
_______________________________________

13. If the obstruction is at ____________, the reflected signal and direct signal will have a phase opposition thus,
the received signal is “minimum”.
_______________________________________

14. Yagi-Uda antenna operates above


_______________________________________

1
15. It is the direction of maximum radiation
_______________________________________

16. Any device capable of transmitting electromagnetic energy and/or receiving electromagnetic radiation.
_______________________________________

17. It is also called as “side lobe” and it is the direction of minimum radiation
_______________________________________

18. The range of distance of transmission and reception of a Yagi-Uda antenna is


_______________________________________

19. It is the direction with radiation intensity equal to zero.


_______________________________________

20. It is a polar diagram which indicates how well an antenna transmits or receives in different direction.
_______________________________________

21. The four factors which determine the radiation pattern of an antenna.
______________________________________________________________________________

22. The Yagi-Uda antenna consists of three elements


_______________________________________

23. An Isotropic antenna has a gain of


_______________________________________

24. Any receiving antenna transfers energy from the atmosphere to its terminal with the same efficiency with which
it transfers energy from transmitter into the atmosphere assuming that the frequency is same.
_______________________________________

25. A practical antenna has a gain of


_______________________________________

26. The element of the Yagi-Uda antenna that is connected to the feedline.
_______________________________________

27. It is an antenna that radiates uniformly in all directions in space.


_______________________________________

28. Radiation pattern at the receiver.


_______________________________________

29. Ratio of the power density in a particular direction of one antenna to the power density that would be radiated
by an antenna.
_______________________________________

2
30. The active element of the Ygai-Uda antenna.
_______________________________________

31. The gain of a Hertzian Dipole


_______________________________________

32. Propagation of the wave is perpendicular to its direction.


_______________________________________

33. The gain of a Half-wave Dipole


_______________________________________

34. The Parasitic element of the Yagi-Uda antenna.


_______________________________________

35. The longer the antenna, the __________ the directive gain.
_______________________________________

36. Antenna functions as a _______ circuit.


_______________________________________

37. Non-resonant antennas have __________ directive gain than resonant antennas.
_______________________________________

38. Five applications of the Yagi-Uda antenna.


______________________________________________________________________________

39. The directive gain of all practical antennas is greater than ________.
_______________________________________

40. It is also called as receiving area or effective area or captured area.


_______________________________________

41. The gain in the direction of one of the major lobes in antenna radiation pattern.
_______________________________________

42. __________ and _________ is an additional conducting elements used in order to increase its Directivity.
_______________________________________

43. The ratio of the applied voltage of the flowing current.


_______________________________________

44. Wireless Communication is also called as


_______________________________________

45. It is the AC resistance, ratio of power radiated to the antenna to the source of the current of the feed point.
_______________________________________

3
46. If a Yagi-Uda antenna were used as a _________ antenna. The ___________ as well as the ___________ were
not directly connected to the feed line, only the ___________ was connected to the feed line, thus the
___________ element drives the current, thus it was called as “driven element”.
______________________________________________________________________________

47. It is the ground resistance of the antenna, discharge of corona effects, losses in imperfect dielectric very near
the antennas, and the eddy current loss.
_______________________________________

48. Propagation of the wave is parallel to its direction.


_______________________________________

49. It is also called as the ohmic resistance and effective resistance.


_______________________________________

50. ________ an _________ only obtained power from the dipole.


_______________________________________

51. It is the product of the power fed to an antenna and its power gain.
_______________________________________

52. If the antenna is cut at exact length, its equivalent impedance is ______, voltage and current are ________,
there is ______________, and operating frequency is ______ to resonant frequency.
_______________________________________

53. It is the power radiated by an antenna in its favored direction taking the gain of the antenna into account as
referenced to an isotropic radiator.
_______________________________________

54. The length of the dipole should be 5% shorter than one half wavelength to compensate the _________ due to
the capacitance of the antenna.
_______________________________________

55. It is the physical orientation of radiated waves in space dictated by the direction of the electric field.
_______________________________________

56. Gain of the antenna at 100% efficiency.


_______________________________________

57. It a polarization where the electric vector has a particular direction in space.
_______________________________________

58. Three reasons for putting/ arranging the antennas or elements of the antenna array
_______________________________________

4
59. It is a linear polarization where the electric field is perpendicular to earth’s surface.
_______________________________________

60. If the antenna is greater than wavelength/4, its equivalent impedance is ______, voltage and current are
________, there is ______________, and operating frequency is ______ to resonant frequency.
_______________________________________

61. It is a linear polarization where the electric field is parallel to earth’s surface.
_______________________________________

62. Two classification of array according to the direction of maximum radiation


_______________________________________

63. Three solutions to overshooting.


_______________________________________

64. It is an electrical conductor or array of conductors that radiates signal energy (transmitting) and/or collects
signal energy (receiving).
_______________________________________

65. It is a polarization where the electric vector rotates about the axis of the direction of propagation with equal
magnitude.
_______________________________________

66. The maximum radiation is along the main axis of the antenna.
_______________________________________

67. It is a polarization where the electric vector rotates about the axis of the direction of propagation but the
amplitudes of its 2 linearly polarized components are unequal.
_______________________________________

68. If the antenna is less than wavelength/4, its equivalent impedance is ______, voltage and current are ________,
there is ______________, and operating frequency is ______ to resonant frequency.
_______________________________________

69. There is no fixed pattern of polarization variation.


_______________________________________

70. The maximum radiation is at right angle to the main axis of the antenna.
_______________________________________

71. Operating frequency range of the antenna.


_______________________________________

72. Gain of the antenna at lossless condition.


_______________________________________

5
73. It is the ratio of the power at the optimum direction of the antenna to the power 180 degrees from the optimum
direction.
_______________________________________

74. Two classification of array according to how the elements are connected
_______________________________________

75. It is the degree of concentration of the antenna radiation.


_______________________________________

76. It is a tunable circuit.


_______________________________________

77. It is the angular separation between two half power points in a major lobe of an antenna radiation pattern.
_______________________________________

78. All elements are connected to the feed line.


_______________________________________

79. It is the actual length of an antenna.


_______________________________________

80. It is also defined as transition device, or transducer between guided wave and free space or vice versa.
_______________________________________

81. Length that depends on the velocity factor


_______________________________________

82. Three reasons for the elements are connected to the feed line.
______________________________________________________________________________

83. It counter-balanced the inductive reactance of the equivalent impedance of the antenna to that of the capacitive
reactance or vice versa.
_______________________________________

84. Only one element is connected to the feed line.


_______________________________________

85. It is also called as principle of reciprocity.


_______________________________________

6
II. Problem Solving

1. An antenna slightly greater than λ /4 in length has an impedance of 80 ohms resistance plus 120 ohms inductive
reactance at 3.4 MHz. What size of capacitor should be connected in series with the antenna to shorten it
electrically to a λ /4 antenna?

2. A TV receiving antenna is to be constructed for channel 13. The spacing between the reflector and dipole should
be 2/10 of the wavelength. The spacing between director and dipole should be 1/10 of a wavelength. The length
of the director is 5% shorter than the dipole and the reflector is 5% longer than the dipole. Determine the
following:
a. Length of dipole
b. Length of reflector
c. Length of director
d. Spacing between dipole and reflector
e. Spacing between dipole and director

7
3. An antenna has a radiation resistance of 72 ohms, a loss resistance of 8 ohms, and power gain of 16. What
efficiency and directivity does it have?

4. For a transmit antenna with a radiation resistance of 72 ohms, an effective antenna resistance of 8 ohms, D=20,
and an input power of 100 W. Determine the EIRP in dBw.

5. A satellite transmitter operates at 46 Hz with an antenna gain at 50dBi. The receiver is 36,000 km away. The
receiving antenna gain is 50dBi. If the transmitter power is 10 watts, find EIRP in dBw.

8
6. An antenna has a gain of 14 dB. It is fed by an RG-8/U transmission line 250 ft long whose attenuation is 3.6
dB/100 ft at 220 MHz. The transmitter output is 50 W. Calculate: (Example 14-2 in Frenzel)
a. The transmission line loss
b. The effective radiated power.

7. Calculate the length of a half-wave dipole for an operating frequency of 200 MHz. (Blake)

8. A dipole antenna has a radiation resistance of 67 ohms and a loss resistance of 5 ohms, measured at the
feedpoint. Calculate the efficiency. (Blake)

9. Two antennas have gains of 5.3 dBi and 4.5 dBd, respectively. Which has greater gain?

10. A dipole antenna has an efficiency of 85%. Calculate its gain in decibels. (Blake)

9
11. For the antenna pattern sketched in Figure 8.6, Find: (Blake)

a. The antenna gain in dBi and dBd


b. The front-to-back ratio in dB
c. The beamwidth for the major lobe
d. The angle, gain and beamwidth for the most important minor lobe

10
12. A Yagi antenna has a gain of 10 dBi and a front-to-back ratio of 15 dB. It is located 15 km from a transmitter with
an ERP of 100 kW at a frequency of 100 MHz. The antenna is connected to a receiver via a matched feedline
with a loss of 2 dB. Calculate the signal power supplied to the receiver if the antenna is: (Blake)
a. Pointed directly toward the transmitting antenna.
b. Pointed directly away from the transmitting antenna.

13. A lossless half-wave dipole is located in a region with a field strength of 150 uV/m. Calculate the power that this
antenna can deliver to a receiver if the frequency is: (Blake)
a. 100 MHz
b. 500 MHz

11

You might also like