XII. Repairing Damage Connector IDE Hard Drive XII. Repairing Damage Connector IDE Hard Drive

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 4

Qbonk Media Group Jln Gassing Dg

Tiro - Gowa (Sulawesi)


E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762

6. Good luck!!!
125

XII. Repairing Damage Connector IDE Hard Drive

It is not possible you experience that one of the broken pin IDE hard drive and

you may be confused cope. Gambari whom I have designated with a red mark on

Below is one of the pins are broken and missing.

Device / Equipment needed:

o Aka IDE drives do.

o Sewing needle or pin.

www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762

o TIMAS paper (you can download in a cigarette wrapper dlm).


126
o Wire cutters.

o IDE Cable.

Preparation:

Basically, all you need to do is to get a connection

electricity between small pin IDE Heard drive with pin IDE data cable. So, the first thing

have to do is figure out how to connect the two for IDE drives

living alone pin base.

1) Cut a small piece of tinfoil, fold it more than 2 or 3 times and

put it on where the base of the pin broken in the hard drive.

2) Be careful and do not let it touch the pin tinfoil lai nearby.

3) For details, see the image below;

4) Now prepare a single piece of wire which is somewhat stiff to be included

into the IDE socket until it touches the ends of the wires inside the cable pitan

the data, as shown below.

5) A piece of wire had to be not to be separated although this socket facing

down ... .pikirkan how aga attached.

6) The wire ends should appear approximately 2mm which will be menyen paper

tin on top tadiNow you need to add something to the cable that will contact

the tin foil better than the hole on the connector there. I stuck a pin in sewing

www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762

as far as it would go and then snipped it off with wire cutters, leaving about
127
1 / 8th of an inch or so extra.

7) After that carefully paste this data cable to the hard drive and seocket

really felt until the meeting. See the picture below. Good luck!!!!!

www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762

8) If successful, at least you still have time to save the data in


128
therein.

XIII. Bad Sector And How To Overcome

Bad Sector in the disk in general there are two kinds, namely mechanical / physical and software. Bad

mechanical sector, which is like the surface of a data storage plates physically damaged hard drive

eg due to scratches, dust, hard impact and so on. While

bad sector software can occur when the hard drive is busy suddenly dies, the current drop out and

so.

Bad Sector in the form of physical damage (mechanical), then it is beyond the scope of this,

because it usually can not (very difficult) repaired. If you still have a warranty then

should be exchanged for new ones. But if bad sectors in the form of software, then

may still be improved. So the discussion here focuses only bad sector

in software.

How to fix the Bad Sector?

If the hard disk bad sector is detected, then the first step is

save important data that is either stored on another hard drive, copy it to a CD

or more. And before following the steps below make sure that important data

already in the backup.

Initial step : Try formatting the drive or hard drive bad sectors with format

unusual, for example through a right click in Windows Explorer and select the format. Sometimes this

can eliminate the bad sectors. If the initial langlah not work, it can be tried

some way with some free software below:

1. Easeus Partition Manager

www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com

You might also like