The document describes three types of MR fasteners (MR1, MR2, MR3) that can be used for belt splicing for different belt thicknesses and pulley diameters. The fasteners are made of antimagnetic stainless steel or galvanized steel with polyamide covered stainless steel hinge cables. They come pre-packaged with splices and are installed using a hammer tool or new installation tool for wider belts.
The document describes three types of MR fasteners (MR1, MR2, MR3) that can be used for belt splicing for different belt thicknesses and pulley diameters. The fasteners are made of antimagnetic stainless steel or galvanized steel with polyamide covered stainless steel hinge cables. They come pre-packaged with splices and are installed using a hammer tool or new installation tool for wider belts.
The document describes three types of MR fasteners (MR1, MR2, MR3) that can be used for belt splicing for different belt thicknesses and pulley diameters. The fasteners are made of antimagnetic stainless steel or galvanized steel with polyamide covered stainless steel hinge cables. They come pre-packaged with splices and are installed using a hammer tool or new installation tool for wider belts.
Fasteners with pre-mounted staples. New installation tool for wide belts
MR 1 MR 2 MR 3
Belt thickness 1.5 to 3.2 mm 3.0 to 5.0 mm 4.8 to 6.4 mm
Min. pulley diameter 50 mm 75 mm 100 mm
Max. belt tension 19 N/mm 30 N/mm 38 N/mm
Material Antimagnetic stainless steel or galvanized steel.
Hinge material (*) Polyamide covered Polyamide covered Polyamide covered
stainless steel cable stainless steel cable Ø stainless steel cable Ø 2.3 mm. 3.6 mm. Ø 5.1 mm.
Installation By using a hammer tool.
Packaging Standard boxes each containing complete 4 splices (8 strips + 8 hinge
cables) for belt width from 300 mm to 1,500 mm in one piece. ACCESSORIES : Plastic hammer, Installation tool (minimum 100 mm) with punch. (*) Hinge pin are available on demand