Professional Documents
Culture Documents
Gimbal Expansion Joint
Gimbal Expansion Joint
Gimbal Expansion Joint
Gimbal
MWC & MFC series
MWC MFC
Gimbal expansion joint with welding ends. Gimbal expansion joint with flanges.
Features
Type Series
Gimbal MWC, MFC
Pressure thrust restraint Movements
Axial
Transmits shear and wind
Single-plane loads
Lateral
Multi-plane Supports dead weight
Avoid twisting the bellows
Single-plane
Angular No main anchors required
Multi-plane
MACOGA, S.A.
Leira s/n - 15680 Ordes - A Coruña - Spain
Tel: +34 981 68 00 00
macoga@macoga.com www.macoga.com
Gimbal
MWC & MFC series
Typical applications
PLANAR GUIDE
GIMBAL
EXPANSION JOINT
SPRING HANGER
MWC / MFC
GIMBAL
EXPANSION JOINT
MWC / MFC
GIMBAL
EXPANSION JOINT
MWC / MFC
The capacity of the Gimbal Expansion Joints to absorb an- When it is either impossible or undesirable for the horizon-
gular movements in any plane is usually applied by using tal sections of piping to absorb the expansion of the vertical
two Gimbal Expansion Joints as shown in the diagram. Only section, a system composed of two Gimbal Expansion
two intermediate fixed points are requiered owing to the Joints plus one Hinged Expansion Joint must be used as
fact that the Gimbal system absorbs the thrust produced by shown in the diagram. The use of a Hinged Expansion Joint
the internal pressure. This system of two Gimbal Expansion is justified by the fact that movement in the vertical section
Joints means that any vertical expansion of the pipes is ab- only occurs in one plane.
sorbed by the bend in the horizontal sections of piping and
it may therefore be necessary to install spring hangers in
both sections.
Sample images
MACOGA, S.A.
Leira s/n - 15680 Ordes - A Coruña - Spain
Tel: +34 981 68 00 00
macoga@macoga.com www.macoga.com