Start Time SN Job Step Hazard Hazard Controls Status Comments

You might also like

Download as xlsx, pdf, or txt
Download as xlsx, pdf, or txt
You are on page 1of 3

AZURA EDO-POWER PLANT

MAINTENANCE CHECK SHEET / JOB HAZARD ANALYSIS


MAINTENANCE SAFETY PROTOCOL
UNIT NUMBER GT11 Month Start time Stop time
SYSTEM MBK - Turning Gear System WO#
SN Job Step Hazard Hazard controls Status Comments

1 identify maintenance equipment according to P&IDs

2 Inspect the sensors, transmitters for physical damage or abnormal conditions


Use Proper PPE
Noise, Vibration, slips, trips and Take short breaks
falls Clean out spilled oil
Do proper house keeping
3 Check
same.
for any leakage in the complete MBK system. In case of leakage, arrest

4 Check condition of the Turning gear control block

General Comments:

Lead Technician Signature Date


Supervisor Signature Date
AZURA EDO-POWER PLANT
MAINTENANCE CHECK SHEET / JOB HAZARD ANALYSIS
MAINTENANCE SAFETY PROTOCOL
UNIT NUMBER GT12 Month Start time Stop time
SYSTEM MBK - Turning Gear System WO#
SN Job Step Hazard Hazard controls Status Comments

1 identify maintenance equipment according to P&IDs

2 Inspect the sensors, transmitters for physical damage or abnormal conditions


Use Proper PPE
Noise, Vibration, slips, trips and Take short breaks
falls Clean out spilled oil
Do proper house keeping
3 Check
same.
for any leakage in the complete MBK system. In case of leakage, arrest

4 Check condition of the Turning gear control block

General Coments:

Lead Technician Signature Date


Supervisor Signature Date
AZURA EDO-POWER PLANT
MAINTENANCE CHECK SHEET / JOB HAZARD ANALYSIS
MAINTENANCE SAFETY PROTOCOL
UNIT NUMBER GT13 Month Start time Stop time
SYSTEM MBK - Turning Gear System WO#
SN Job Step Hazard Hazard controls Status Comments

1 identify maintenance equipment according to P&IDs

2 Inspect the sensors, transmitters for physical damage or abnormal conditions


Use Proper PPE
Noise, Vibration, slips, trips and Take short breaks
falls Clean out spilled oil
Do proper house keeping
3 Check
same.
for any leakage in the complete MBK system. In case of leakage, arrest

4 Check condition of the Turning gear control block

General Coments:

Lead Technician Signature Date


Supervisor Signature Date

You might also like