Professional Documents
Culture Documents
Engg.-9 T.E. (Mechanical / Automobile) : Time: 1 Hour) (Maximum Marks: 30 Instructions To The Candidates
Engg.-9 T.E. (Mechanical / Automobile) : Time: 1 Hour) (Maximum Marks: 30 Instructions To The Candidates
Engg.-9 T.E. (Mechanical / Automobile) : Time: 1 Hour) (Maximum Marks: 30 Instructions To The Candidates
OR
Q4) State Taylor's principle of gauge design. Design general type of 'GO' and
'NO GO' gauge for components having 30 H7f8 fit. Given data.
- 30 mm falls in diameter steps of 18-30 mm.
- upper deviation for 'f' type of shaft = -5.5D0.41.
- i = 0.453 3 D + 0.001D .
- IT7 = 16 i
- IT8 = 25 i
- Wear allowance = 10% of gauge tolerance. [10]
P.T.O.
Q5) a) Write note on CMM. [4]
b) State & explain different types of error in screw thread; calculate best
wire size for inspecting thread plug gauge of M16 × 2.5 mm size. [6]
OR
Q6) a) Explain gear rolling tester in detail, calculate the settings of gear tooth
vernier to inspect a gear having 40 teeth and with module 3. [6]
===
[Engg.]-9 -2-