Professional Documents
Culture Documents
Justageanleitung 9012 - Justage - English
Justageanleitung 9012 - Justage - English
Justageanleitung 9012 - Justage - English
calibration of
vacuum switches C
3
A
1
B
2
Type 901.20/21
This pressure switch may only be mounted, connected and Arrangement of contacts
started up by trained technicians. You must ensure, that the
electrical connections are not live and the pressure switch 3 normally closed contact
is not pressurized or under high temperature before starting any 1
work. Otherwise, this might endanger life due to electrical shock,
leaking medium or high temperatures. The valid safety regulations, 2 normally open contact
intended use and technical data must be observed. In accordance P
with these regulations, the system voltage must be switched off and
secured >from being unintentionally switched on again. Damaged
products may not be used. Each pressure switch has 3 adjusting screws (A, B, C).
The pressure switches are set to a defined level by the manufacturer Screw A is to be used exclusively if adjustment
according to the stamped numeral (= trip pressure) by means of position has to be changed.
tuned sets of springs. In case of readjustment by the user, all
warranty claims become void. The following directions should only Screw B permits small changes of the
serve to establish the correct pressure setting. reset pressure (2 → 3).
Calibration
Screw: A B C
changes the level, i.e. both changes reset pressure changes trip pressure
Result the trip and the reset pressure
at the same time
and in same direction
turn to right left right left right left
Beck GmbH
Druckkontrolltechnik
P.O. Box 11 31
D-71140 Steinenbronn
Telephone +49 (71 57) 52 87-0
Telefax +49 (71 57) 52 87-83
e-mail sales@beck-sensors.com
http://www.beck-sensors.com