The document describes modeling an under voltage relay using MATLAB to protect an electrical system during faults. It lists the objectives as implementing the relay using Simulink libraries, setting the time and voltage thresholds, and coordinating the relay. The task is to create a Simulink model of an under voltage relay that monitors voltage, detects faults when voltage decreases, and sends a trip signal to open the circuit breaker.
The document describes modeling an under voltage relay using MATLAB to protect an electrical system during faults. It lists the objectives as implementing the relay using Simulink libraries, setting the time and voltage thresholds, and coordinating the relay. The task is to create a Simulink model of an under voltage relay that monitors voltage, detects faults when voltage decreases, and sends a trip signal to open the circuit breaker.
The document describes modeling an under voltage relay using MATLAB to protect an electrical system during faults. It lists the objectives as implementing the relay using Simulink libraries, setting the time and voltage thresholds, and coordinating the relay. The task is to create a Simulink model of an under voltage relay that monitors voltage, detects faults when voltage decreases, and sends a trip signal to open the circuit breaker.
The document describes modeling an under voltage relay using MATLAB to protect an electrical system during faults. It lists the objectives as implementing the relay using Simulink libraries, setting the time and voltage thresholds, and coordinating the relay. The task is to create a Simulink model of an under voltage relay that monitors voltage, detects faults when voltage decreases, and sends a trip signal to open the circuit breaker.
Objectives: At the end of this lab session students will be able to:
Implement “Under voltage Relay” by using Matlab Simulink Libraries.
Set the “time and voltage Setting” of Under voltage Relay. Co-ordination of Under voltage relay
5.0Under Voltage Relay
Under current relay is one which monitors the voltage only and gives trip signal to the circuit breaker in faulty condition. In case of faults, if voltage in the system decreases from its normal value it will open the breaker.
5.1 Laboratory Task
Implement under voltage relay in Matlab Simulink that protect the system in faulty conditions. After sensing the fault relay should give a trip signal to the circuit breaker.