Professional Documents
Culture Documents
Question Paper - (Electrical) : Maximum Marks: 50 Time Allowed: 1 Hour
Question Paper - (Electrical) : Maximum Marks: 50 Time Allowed: 1 Hour
Note: There are 50 Questions. Each question has ONE correct answer. One mark for
Each question. Please ( X ) mark in the answer sheet for marking the correct
answer
2. 30 kW, 415 Volt, 2 Pole, 50 Hz Squirrel Cage Induction Motor will run at:
a) 3000 RPM b) 1500 RPM c) Slightly less than 3000 RPM d) Slightly less
than 1500 RPM
3. CPP side (Upstream) breaker of a feeder trips on downstream side fault through
a) 7SJ600 b) 6MB6265 c) 7SD511 d) 7UT512
8. BDV value for 33/6.6 kV X-mer oil should not be lees than
a) 30kv b) 40kv c) 50kv d) 60kv
12. Which of the following is used as the electrolytic solution for Ni - Cd cell ?
a) KMNO3 b) HCL c) H2SO4 d) KOH
17. Which is the relay used for ACB controlled L.T motor
a) AFV b) AMV c) MV d) FV
18. All HT motors can be run in both directions just by changing the phase sequence.
a) True b) False
20. A 400 KW, 3 phases, 440 volts, 50 Hz Induction motor has a speed of 950 rpm on
full load. The machine has 6 poles. The slip of the machine will be
a) 0.06 b) 0.10 c) 0.04 d) 0.05
23. Ideally we should have identical CTs on either side of the motor for a differential
protection.
a) True b) False
34. Under normal condition both UPS share the load in the
following proportion
a. 50:50
b. 25:75
c. 75:25
d. 100:0
35. The actual division of the total load KW load between alternators running in
parallel depends upon
a. Speed-load characteristic
b. Voltage-load characteristic
c. a & b both
d. a or b
38. What is the high winding temperature trip setting for a HT motor?
a) 130 Deg C b) 155 Deg C c) 110 Deg C
49. The phase relationship between the primary and secondary voltage of a transformer is
a) 90 Degree out of phase.
b) In the same phase.
c) 180 Degree out of phase.
d) None of the above.
XXXX