Professional Documents
Culture Documents
Real Time EEG Bio Signal Measurement Using NIELVIS Aim
Real Time EEG Bio Signal Measurement Using NIELVIS Aim
AIM:
To measure the EEG signal using NI ELVIS II
SOFTWARE REQUIRED:
1. LabVIEW 2015
HARDWARE REQUIRED:
1. NI ELVIS II Prototype Board 2. EEG Sensor Kit
PROCEDURE:
1. Open NI ELVIS Traditional from Computer start » all program» National Instruments »
NI ELVIS.
2. Open NI ELVIS Oscilloscope from NI ELVIS configure window and select the device
connected (NI ELVIS II) and Select SCOPE 0/1 in channel 0/1 settings
3. Connect the Sensor probe from the EEG Sensor kit to the SCOPE 0/1 in NI ELVIS II
Module board
4. Place the EOG electrode in our body where the EEG signals originated and connect the
signal output to EOG sensor kit.
5. Set necessary adjustment in virtual scope and measure the signal form scope.
6. Print the measured signal.
RESULT:
The real time EEG signal is measured and printed using EEG electrode and NI ELVIS II.