2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
2004 ACCESSORIES & BODY, CAB
Steering Column Switches - Escape
DESCRIPTION AND OPERATION
STEERING COLUMN SWITCHES
‘The steering column switches of the following:
« Multifunction switch
# Ignition switch
DIAGNOSIS AND TESTING
STEERING COLUMN SWITCHES
Refer to POWER DISTRIBUTION for schematic and connector information.
73ill Automotive meter or
equivalent
105-RO057
02743938
Fig. 1: Iden
Courtesy of FORD MOTOR CO.
Inspection And Verification
1. Verify the customer concern by operating the ignition switch and the multifunction
switch.
2. Visually inspect the ignition switch and the steering column multifunction switch for
damage; refer to the following chart:2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
‘Mechanical Electrical
= Ignition switen + Connections
‘+ Tum signal switch (cart ofthe steering column ‘+ Battery junction box (BJB) fuse
‘mulfunetion switen) ‘MAIN (120A)
‘+ Hazard flasher switen + 19(408)
+ Wiperiwasher switch + 20 (408)
“Central junction box (CB) fuse IG
Kev.
+ 11 (108)
+ Circuitry
Fig. 2: Visual Inspection Chart
Courtesy of FORD MOTOR CO.
3. If binding occurs, turn the steering wheel left or right to release any pressure on the
ignition switch and make sure the ignition key is cut correctly
4. If the cause of the switch concern is not visually evident, proceed to the SYMPTOM
CHART.
‘Symptom Chart2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Condition
+ The ignition switch is inoperative + Battery junction
box (BJB) fuse
MAIN (120A),
+ BUB fuse 19
(40a)
+ Central junction
box (CJB) fuse 11
(104),
+ Ignition switch
+ Circuitry
+ Battery
+ No power in ACG * Batteryjunction |» GOto
box (BB) fuse 2 Pinaaint
(404) Tesi.
+ Ignition switch
+ ACC relay.
+ Circuitry
+ No power in ON * Ignition switch + Gow
+ IGN relay Pinpoint
+ Cicuiy Tesic
+ No power in START Ignition switch + GOW
+ Circuitry Pinaoint
GO to
‘The ignition switch is Inoperative—key
‘cannot be removed from ignition switch
(automatic transmission only)
+ The ignition switch is inoperative—key can
be removed from ignition switch with
transmission in gear (automatic.
transmission only)
+ Ignition switch
Shift lock module.
Circuitry
= Ignition switch
+ Shift ock module.
+ Circuitry,
Fig, 3: Identifying Symptom Specification Chart
Courtesy of FORD MOTOR CO.
Pinpoint Tests
PINPOINT TEST A: THE IGNITION SWITCH IS INOPERATIVE2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Tost Step, Result / Action to Take
‘At CHECK CIRCUIT 32 (RD/LB) FOR VOLTAGE.
+ Keyin OFF positon,
* Disconnect: Ignition Switch
+ Measure the voltage between the ignition switch C250 pin 4,
circuit 32 (RDILB), harness side and ground.
Yes
INSTALL a new kgntion swite:
REFER to ignition Swit inthis
section, TEST Ine system for
normal operation,
No
REPAIR tho clreul, TEST tho
system for normal operation
|
Is the voltago groator than 10 volts?
ig. 4: Pinpoint Test A: Ignition Switch Is Inoperative
Courtesy of FORD MOTOR CO.
PINPOINT TEST B: NO POWER IN ACC2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Tan
z
|
Fig. 5: Pinpoint Test B: No Power In ACC
Courtesy of FORD MOTOR CO.
PINPOINT TEST C: NO POWER IN ON2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
+47 yong gra
feces a
TACHECE CevTsAt JUNCTION 50eFOROPEE
eee Te Ie
syn aa
[amin
enn nea nt
Fig. 6: Pinpoint Test 0 Power In On
Courtesy of FORD MOTOR CO.
PINPOINT
I D: NO POWER IN START2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Test Step Result / Action to Take
D1 CHECK THE IGNITION SWITCH
*+ Carry out the Ignition Switch Component | Yes
Test; refer to COMPONENT TESTING article] REPAIR circuit 306 (TNILB). TEST the system for
in Accessories & Equipment hornal operation,
+ Is the ignition switch OK? NN
INSTALL a new ignition switch; REFER to Ignition,
[Switch TEST the system for normal operation
ig. 7: Pinpoint Test D: No Power In Start
Courtesy of FORD MOTOR CO.
INOPERATIVE - KEY CANNOT BE REMOVED FROM IGNITION
)
PINPOINT TEST
WITCH (AUTOMATIC TRANSM
IE IGNITION SWITCH
JON ONL2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Teat Step, Rosult/ Action 10 Tako
E71 GHEGK THE SHIFT LOGK MODULE
* Disconect Shift Lock Modul, Yes
+ Key in ON postion, INSTALL a new shi ock
1 Connect fused furiper wie between shi lock zneduie C2067 pin module. REFER to Section
8, circuit 1420 (YENLB). haeness site and ground 207.05.. TEST the system
or noinat operation
REMOVE the jumper wire.
GO Ea.
+ Can the key bo removed from the ignition swatch?
E2 CHECK CIRCUIT 1420 (YE/LB) FOR OPEN
> Key in OFF poslion Yes
+ Disconnect igeton Switch INSTALL a new ignition
+ Measure ihe resisiance betwen the shit lock module C2067 pin | switch, REFER 16 igaiian
8, circuit 1470 (YE!16), haeness site and ignition switch C250 pin | Suiich i this section.
rout 1420 ¢ hamess si. FTEST the system for
nonma! operation
No
REPAIR the creat TEST
the system for roxmat
operation,
+ Is the resistance toss than 5 onms?
Fig. 8: Pinpoint Test E: Ignition Switch Is Inoperative - Key Cannot Be Removed From
Ignition Switch (A/T Only)
Courtesy of FORD MOTOR CO.
PINPOINT TEST F: THE IGNITION SWITCH IS INOPERATIVE - KEY CAN BE REMOVED FROM IGNITION
‘SWITCH WITH TRANSMISSION IN GEAR (AUTOMATIC TRANSMISSION ONLY)2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Test Step
Result / Action to Take
Fi CHECK THE SHIFT LOCK
MODULE
> Disconnect: Shift Lock Module.
* Key in ON position.
+ Can the key be removed from
the ignition switch?
Yes
GO Ea.
No
INSTALL a naw shift lock module. REFER to TRANSAXLE
|RANSMISSION EXTERNAL CONTROLS artciin Transmission,
[TEST the system for normal operation.
F2 CHECK CIRCUIT 1420 (YE/LB)
FOR SHORT TO GROUND
* Key in OFF position
+ Disconnect: Ignition Switch
+ Koy in ON position
+ Can the key be removed from
the ignition switeh?
Yes
REPAIR the circuit. TEST the system for normal operation.
No
INSTALL a new ignition switch; REFER to Ignition Switch.
TEST the system for normal operation
Fis
9: Pinpoint Test F: Ignition Switch Is Inoperative - Key Can Be Removed From
Ignition Switch With Transmission In Gear (A/T Only)
Courtesy of FORD MOTOR CO.
REMOVAL AND INSTALLATION
STEERL
COLUMN MULTIFUNCTION SWITCH
Removal And Installation
1. Remove the clockspring. For additional information, refer to ATR BAG RESTR.
SYSTEMS
2. Remove the multifunction switch.
1, Disconnect the electrical connector.
2. Remove the screws.
3. Remove the multifunction switch.2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
Zs | i
We yeeaw | |
G02743947
Fig. 10: Removing Multifunction Switch
Courtesy of FORD MOTOR CO.
3. To install, reverse the removal procedure
HAZARD FLAS)
ER SWITCH
Removal And Installation
1. Disconnect the battery ground cable. For additional information refer to BATTERY,
MOUNTING AND CABLES .
2. Position the instrument panel center finish panel rearward from the instrument panel.2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
G02743948
Fig. 11: Identifying Instrument Panel Center Finish Panel
Courtesy of FORD MOTOR CO,
3. Remove the hazard flasher switch.
1, Disconnect electrical connector.
2. Remove the hazard flasher switch.2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
G02743949
Fig. 12: Removing Hazard Flasher Switch
Courtesy of FORD MOTOR CO.
4, To install, reverse the removal procedure.
IGNITION SWITCH
Removal And Installation:
1. Depower the supplemental restraint system (SRS). For additional information, refer to
AIR BAG RESTRAINT SYSTEMS
2. Remove the upper steering column shroud2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
ee eee ee
G02743950
Fig. 13: Removing Upper Steering Column Shroud
Courtesy of FORD MOTOR CO.
3. Remove the lower steering column shroud.
1. Remove the screws.
2. Remove the lower steering column shroud2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
02743951
14; Removing Lower ‘ring Column Shroud
Courtesy of FORD MOTOR CO,
4, Disconnect the ignition switch electrical connector.2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
G02743952
Fig. 15: Disconnecting Ignition Switch Electrical Connector
Courtesy of FORD MOTOR CO.
NOTE: Lower steering column to lowest tilt
position.2004 Ford Escape
2004 ACCESSORIES & BODY, CAB Steering Column Switches - Escape
G02743953
Fig. 16: Removing Ignition Switch
Courtesy of FORD MOTOR CO.
5. Remove the ignition switch
1. Press the two tabs.
2. Remove the ignition switch
6. To install, reverse the removal procedure.
* Activate the supplemental restraint system (SRS). For additional information,
refer to AIR BAG RESTRAINT SYSTEMS