Professional Documents
Culture Documents
General Description: Frequency Shuffling
General Description: Frequency Shuffling
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling
Tone energy at below 20KHZ is minimized in the
GENERAL DESCRIPTION design and audio noise is eliminated during operation.
OB2263 is a highly integrated current mode PWM OB2263 is offered in SOT23-6, SOP-8 and DIP-8
control IC optimized for high performance, low packages.
standby power and cost effective offline flyback
converter applications in sub 30W range. FEATURES
PWM switching frequency at normal operation is ■ On-Bright Proprietary Frequency Shuffling
externally programmable and trimmed to tight range. Technology for Improved EMI Performance.
At no load or light load condition, the IC operates in ■ Extended Burst Mode Control For Improved
extended ‘burst mode’ to minimize switching loss. Efficiency and Minimum Standby Power Design
Lower standby power and higher conversion ■ Audio Noise Free Operation
efficiency is thus achieved. ■ External Programmable PWM Switching
VDD low startup current and low operating current Frequency
contribute to a reliable power on startup design with ■ Internal Synchronized Slope Compensation
OB2263. A large value resistor could thus be used in ■ Low VDD Startup Current and Low Operating
the startup circuit to minimize the standby power. Current (1.4mA)
The internal slope compensation improves system ■ Leading Edge Blanking on Current Sense Input
large signal stability and reduces the possible sub- ■ Good Protection Coverage With Auto Self-
harmonic oscillation at high PWM duty cycle output. Recovery
Leading-edge blanking on current sense(CS) input o VDD Over Voltage Clamp and Under Voltage
removes the signal glitch due to snubber circuit diode Lockout with Hysteresis (UVLO)
reverse recovery and thus greatly reduces the external o Gate Output Maximum Voltage Clamp (18V)
component count and system cost in the design. o On-Bright Proprietary Line Input Compensated
OB2263 offers complete protection coverage with Cycle-by-Cycle Over-current Threshold Setting
automatic self-recovery feature including Cycle-by- For Constant Output Power Limiting Over
Cycle current limiting (OCP), over load protection Universal Input Voltage Range.
(OLP), VDD over voltage clamp and under voltage o Overload Protection (OLP)
lockout (UVLO). The Gate-drive output is clamped
to maximum 18V to protect the power MOSFET. APPLICATIONS
Excellent EMI performance is achieved with On- Offline AC/DC flyback converter for
Bright proprietary frequency shuffling technique ■ Battery Charger
together with soft switching control at the totem pole ■ Power Adaptor
gate drive output. ■ Set-Top Box Power Supplies
■ Open-frame SMPS
TYPICAL APPLICATION
©On-Bright Electronics
Confidential to Micro Bridge
-1- OB_DOC_DS_63B5
OB2263
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling
Ordering Information
GENERAL INFORMATION Part Number Description
Pin Configuration OB2263MP SOT23-6, Pb-free
The OB2263 is offered in SOT23-6, DIP8 and SOP8 OB2263AP DIP8, Pb-free
packages, shown as below. OB2263CP SOP8, Pb-free
©On-Bright Electronics
Confidential to Micro Bridge
-2- OB_DOC_DS_63B5
OB2263
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling
Marking Information
TERMINAL ASSIGNMENTS
Pin Name I/O Description
GND P Ground
FB I Feedback input pin. The PWM duty cycle is determined by voltage level into this pin and
SENSE pin input.
RI I Internal Oscillator frequency setting pin. A resistor connected between RI and GND sets
the PWM frequency.
SENSE I Current sense input pin. Connected to MOSFET current sensing resistor node.
VDD P Chip DC power supply pin.
GATE O Totem-pole gate drive output for the power MOSFET.
©On-Bright Electronics
Confidential to Micro Bridge
-3- OB_DOC_DS_63B5
OB2263
BLOCK DIAGRAM
©On-Bright Electronics
Confidential to Micro Bridge
-4- OB_DOC_DS_63B5
OB2263
©On-Bright Electronics
Confidential to Micro Bridge
-6- OB_DOC_DS_63B5
OB2263
CHARACTERIZATION PLOTS
VDD = 16V, RI = 100 Kohm, TA = 25oC condition applies if not otherwise noted.
I_vdd_startup (uA)
4.6
15
4.2
10
3.8
5
3.4
0 3.0
0 2 4 6 8 10 12 14 16 -20 10 40 70 100 130
VDD(V) Temp(C)
VDD UVLO and Ops Current VDD Operation Current vs. Load(pF)
2
50KHz 65KHz 100KHz
1.6 5
I(VDD) (mA)
4
I(V D D ) (m A )
1.2
3
0.8
2
0.4 1
0 0
0 5 10 15 20 25 30 0 500 1000 1500 2000
VDD (V) Gate Load (pF)
8.8 14.4
UVLO(OFF) (V)
8.6 14.3
8.4 14.2
8.2 14.1
8.0 14.0
-20 10 40 70 100 130 -20 10 40 70 100 130
Temp(C) Temp(C)
©On-Bright Electronics
Confidential to Micro Bridge
-7- OB_DOC_DS_63B5
OB2263
115
Fosc (KHz)
65.5
90 65
65 64.5
64
40 63.5
50 70 90 110 130 150 -20 5 30 55 80 105 130
RI(Kohm)
Temp (C)
Vth_OC(V) vs Duty_cycle(%)
1.2
1.1
V th_O C (V )
1
0.9
0.8
0.7
0 10 20 30 40 50 60 70
Duty_cycle(%)
©On-Bright Electronics
Confidential to Micro Bridge
-8- OB_DOC_DS_63B5
OB2263
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling
8-Pin Plastic DIP
©On-Bright Electronics
Confidential to Micro Bridge
- 12 - OB_DOC_DS_63B5
OB2263
www.DataSheet4U.com
Current Mode PWM ControllerFrequency Shuffling