Professional Documents
Culture Documents
Lab Quiz
Lab Quiz
the axis
A. parallel
B. at 45 degree
C. at 35 degree
D. none of the mentioned
ANSWER: A
In tailstock method, the angle at which the axis of rotation of the job is shifted
is equal to______ the angle of taper
A. half
B. double
C. triple
D. none of the mentioned
ANSWER: A
In tailstock method, body of the tailstock is made to slide on its base_____ from
the operation
A. towards
B. away
C. either towards or away
D. none of the mentioned
ANSWER: C
In attachment method, the angle of swiveling the guide bar can be determined from
this equation tan of angle
A. (D-D / L
B. (D-D / 2L
C. (D-D / 4L
D. none of the mentioned
ANSWER: B
The _____ motion is converted into_____ motion of the tool slide in thread cutting
A. rotary, feed
B. feed, rotary
C. transmitting, longitudinal
D. none of the mentioned
ANSWER: A
In thread cutting, the _____ feeds should be equal to the pitch of the thread,
which is to be cut per revolution of the work piece.
A. cross feed
B. longitudinal feed
C. angular feed
D. none of the mentioned
ANSWER: B
In thread cutting, which of the following receives traversing motion from the lead
screw of the lathe.
A. apron
B. top slide
C. cross slide
D. none of the mentioned
ANSWER: C
In thread cutting, definite ratio is calculated between the_____ feed and rotation
of the_____ spindle.
A. longitudinal, headstock
B. cross, headstock
C. cross, tailstock
D. longitudinal, tailstock
ANSWER: A
In thread chasing dial, the half nut is_____ when any live on the dial coincides
with a reference live already set
A. opened
B. closed
C. partially opened and partially closed
D. none of the mentioned
ANSWER: B
In thread chasing dial, half nut is closed when any numbered live coincides with
reference live for_____ thread
A. even
B. odd
C. can’t say anything
D. none of the mentioned
ANSWER: B
Which of the following is not true for table top drill machine
A. it is used in only small jobs
B. it is used for mass production
C. odd shape jobs are not machined
D. none of the mentioned
ANSWER: B
The ______ of a drill is the distance the drill moves into the work at each
revolution of the spindle
A. depth of cut
B. feed
C. cutting speed
D. none of the mentioned
ANSWER: B
If l=length of travel of the drill in mm, n=rpm of the drill, s= feed per
revolution of the drill in mm. Then machining time can be given as
A. (l*n)/s
B. (l*s)/n
C. l/(n*s)
D. none of the mentioned
ANSWER: C.
Which of the following device is not used for holding the work in a drilling
machine
A. step block
B. drill jigs
C. both step block and drill jigs
D. none of the mentioned
ANSWER: D