Professional Documents
Culture Documents
MODEL 633: Infra Red Safety Curtain For Lifts
MODEL 633: Infra Red Safety Curtain For Lifts
INTRODUCTION OPERATION
The Memco élite Model 633 safety system The 633 light curtain uses 32 transmit
provides a light-curtain of infra-red beams diodes in the TX detector and 32 receive
operating between the lift car doors. Any diodes in the RX detector. The light curtain
person or object breaking the beams will uses a 154-beam pattern when the doors
trigger the system and re-open the doors. are fully open (Fig 1). The pattern
The dense beam pattern will pick up even changes to 94 beams as the doors close
very small objects between the car doors. to approximately 400mm and maintains 72
beams right up to closure.
The 633 safety system consists of a
transmitter detector (TX) and a receiver Surface mount technology has led to a
detector (RX) mounted on the car doors. great improvement in the optics allowing
The system will automatically sense the diagonal beams to function to door closure.
door separation and adjust itself for optimum The diodes are manufactured using a
performance. No setting up is required. technique which improves both consistency
and reliability. The special lenses, unique
In many installations a separate controller to Memco, used in conjunction with the
is unnecessary and the detectors can be surface mount diodes optimise the system
connected direct to the lift controller or door performance.
operator.
1. Standard Version
Standard 633 detectors are mounted to the
door sides (Fig 2). They are normally fitted
flush with the door edge, but can be positioned
back from the door edge if necessary.
3. Mixed Version
Mixed 633 detectors are mounted on side- 16mm
SOFTWARE FEATURES
Fig 3
Power Reduction Function
This software feature prolongs the life-span of
the detectors by putting them into a less active
state when the lift is not in use. It automatically
activates when the detectors are stopped very
close together for more than 10 seconds. In
this mode, scanning is reduced to once every 2
seconds. If the doors start to open, or an obstruction is
detected, then the normal scanning and trigger
mode is resumed. The Power Reduction feature
will not operate if the detectors are fitted in a
static position. Fig 4
Trouble-Shooting LEDs
There are two red trouble-shooting LEDs positioned Fig 5: élite 633 wiring connection
18cm and 24cm from the top of the TX detector.
The states they can indicate are shown below.
OFF No Power
OFF
ON Triggered state,
OFF obstruction between detectors
TX CABLE
0V - ORANGE
+12V - RED
TRIG - BLUE
LINK - WHITE or
GREEN
Power Supply
Door Re-Open
Circuit
RX CABLE
TO LIFT CONTROLLER
OR DOOR OPERATOR 0V - ORANGE
+12V - YELLOW (Timeout Enabled)
SYSTEM CONNECTION
Range: 3m
IP Rating IP54
ORDERING INFORMATION
Normal Range
633 500-S Set of Standard Detectors PNP-N/C output
633 510-S Set of Leading Edge Detectors PNP-N/C output
633 520-S Set of Mixed Detectors (1 x Standard, 1 x Leading Edge) PNP-N/C output
All these detectors come with fixing kit and extension cables
Available on Request
633 000-S Set of Standard Detectors NPN-N/O output
633 010-S Set of Leading Edge Detectors NPN-N/O output
633 020-S Set of Mixed Detectors (1 x Standard, 1 x Leading Edge) NPN-N/O output
633 300-S Set of Standard Detectors PNP-N/O output
633 310-S Set of Leading Edge Detectors PNP-N/O output
633 320-S Set of Mixed Detectors (1 x Standard, 1 x Leading Edge) PNP-N/O output
633 400-S Set of Standard Detectors NPN-N/C output
633 410-S Set of Leading Edge Detectors NPN-N/C output
633 420-S Set of Mixed Detectors (1 x Standard, 1 x Leading Edge) NPN-N/C output
All these detectors come with fixing kit and extension cables
Accessories
280 000 Power Supply: 115/230V AC
281 000 Power Supply: 15-36V DC
015 258 Extension Cable: RX, 4m
015 256 Extension Cable: TX, 4m
As a result of our policy of continual improvement, the information in this document is subject to change MEMCO LTD, CLYDE HOUSE
without notice and it is intended only as general guidance on product performance and suitability. This
information shall not form part of any contract WALDECK ROAD, MAIDENHEAD
BERKS SL6 8BY, UK
TELEPHONE: +44 1628 770734
FACSIMILE: +44 1628 621947
www.memco.co.uk
DSHEET10GB/SPA/19.01.2007