The choke drill procedure involves tripping pipe above the cement, circulating mud to fill the pipe, closing the annular preventer, pressuring the annulus to 200 psi, slowly pumping to close the float and obtain shut-in drill pipe pressure, gradually increasing pump rate while holding casing pressure constant by adjusting the choke until the selected kill rate is achieved, measuring lag time after choke adjustments, maintaining constant circulation rate and drill pipe pressure by choke adjustment, then bleeding off pressure to prepare for drilling.
The choke drill procedure involves tripping pipe above the cement, circulating mud to fill the pipe, closing the annular preventer, pressuring the annulus to 200 psi, slowly pumping to close the float and obtain shut-in drill pipe pressure, gradually increasing pump rate while holding casing pressure constant by adjusting the choke until the selected kill rate is achieved, measuring lag time after choke adjustments, maintaining constant circulation rate and drill pipe pressure by choke adjustment, then bleeding off pressure to prepare for drilling.
The choke drill procedure involves tripping pipe above the cement, circulating mud to fill the pipe, closing the annular preventer, pressuring the annulus to 200 psi, slowly pumping to close the float and obtain shut-in drill pipe pressure, gradually increasing pump rate while holding casing pressure constant by adjusting the choke until the selected kill rate is achieved, measuring lag time after choke adjustments, maintaining constant circulation rate and drill pipe pressure by choke adjustment, then bleeding off pressure to prepare for drilling.