Professional Documents
Culture Documents
DL - CT02 - E1 - 1 EPS Installation 37p - N PDF
DL - CT02 - E1 - 1 EPS Installation 37p - N PDF
DL - CT02 - E1 - 1 EPS Installation 37p - N PDF
1
Contents
EPS Introduction
EPS Cables Installation
EPS Configuration
2
Environment Power System (1)
3
Environment Power System (2)
4
Environment Power System (3)
5
Environment Power System (4)
6
Environment Power System (5)
7
Contents
EPS Introduction
EPS Cables Installation
EPS Configuration
8
EPS Heat Exchanger Monitoring Cable
End A connects to EPS COM interface
End B connects to EPS RS232.1 interface
9
EPS Humidity Monitoring Cable
End A connects to EPS HUM interface
End B is humidity interface with 4-core multiple cord round
cable
10
EPS Liquid Monitoring Cable
End A connects to EPS LIQUID interface
End B is liquid interface with 4-core multiple cord round
cable
11
EPS Smoke Monitoring Cable
End A connects to EPS SMOKE interface
End B is smoke interface with 4-core shielding twisted
cable
12
EPS Transmission Monitoring Cable
End A connects to console port of 9806H
End B connects to EPS RS232_2 interface
13
EPS Temperature Monitoring Cable
End A connects to EPS TEMP interface
End B is temperature interface with 4-core shielding
twisted cable
14
EPS Threshold Monitoring Cable
15
EPS MDF Monitoring Cable
End A connects to EPS FAN1 interface
End B connects to MDF alarm board J2
16
Contents
EPS Introduction
EPS Cables Installation
EPS Configuration
17
EPS Configuration
Enter NetNumen N31
Right-click ZXDSL 9806H and select “Environment Power Monitor” ->
“EPM Version Information”
18
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power
Monitor” -> “Version Download”
19
EPS Configuration
20
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power Monitor” ->
“Environment Alarm Threshold”
Input parameters and click “Set” to change parameters
21
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power Monitor” ->
“Power Alarm Threshold”
Input parameters and click “Set” to change parameters
22
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power Monitor” -> “EPM
Environment Variant”
Select sensor from the drop-down list and click “Set”
23
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power Monitor” ->
“Analog Input Interface”
Click “Create”
24
EPS Configuration
Input parameters of analog input interface, and click “Ok”
25
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power
Monitor” -> “Digital Input Interface”
Click “Create”
26
EPS Configuration
Select “Interface No.” and “Device Type”, and then
click “Ok”
27
EPS Configuration
Right-click ZXDSL 9806H and select “Environment
Power Monitor” -> “Digital Output Interface”
Click “Create”
28
EPS Configuration
Configure parameters of digital output interface,
and then click “Ok”
29
EPS Configuration
Right-click ZXDSL 9806H and select “Environment
Power Monitor” -> “Buzzer Switch”
Select ON, or OFF, or Temporarily OFF
30
EPS Configuration
Right-click ZXDSL 9806H and select “Environment
Power Monitor” -> “Power Config”
Click “Create”
31
EPS Configuration
32
EPS Configuration
33
EPS Configuration
34
EPS Configuration
35
EPS Configuration
Right-click ZXDSL 9806H and select “Environment Power Monitor” ->
“EPM Performance” to check environment parameters
36
37