Professional Documents
Culture Documents
DL 1802
DL 1802
USN t0cY72
4d.
b. Desigl a bolted connection between the flange of a colunrn ISIIB 450@907 N/r.r.r and a
br acket plate 15 mrn thick. The bracket plate is supporling a load of 150 kN at an
eccentricity of 350 mrr. Adopt HSFG bolts of property class 8.8. (17 Marks)
!o
aL
Fig.Q3
n.a
4 a. Considering the simply supponed beam subjected to gradually increasing concentrated loacj
W, at the center. show that
(i) M).:2/3 : Mp
_ (ii) The hinge length ofthe plasticity zone is equal to 1/3'd ofthe span. (06 Marks)
b. Explain the methods of plastic analysis. (04 Marks)
,l: c. Determine the plastic and section modulus of a built up section as shown in Fig.e4(c).
ca (10 Marks)
zc
E J
I
Fig.Qa(c)
1 ,)
^f
t0cY72
PART _ B
Design the member consists of a single angle to calry a teqsile force of 200 kN. The length
of
tension member is 3.5 m and subjected to reversal stresses due to wind ibrces. If theJiela
strength and the ultimate strength of the steel used are 250 Mpa and 410 ura and uiing
18 mm bolts. (zo Marks)
Design a laced and battened column with two channels back to back of length g m ro cary an
axial factored load of1000 kN. The column is hinged at both ends. (20 Nrarks)
,.,.,\.! r' x x x
2 of 2