Professional Documents
Culture Documents
Rebound Hammer Test
Rebound Hammer Test
(SCE)
DEPARTMENT OF STRUCTURE AND MATERIAL ENGINEERING
FACULTY OF CIVIL & ENVIRONMENTAL ENGINEERING
KUiTTHO
I, hereby confess that I have prepared this report on my own effort. I also admit not to receive or
give any help during the preparation of this report and pledge that everything mentioned in the
report is true.
___________________________
Student Signature
Name : …………………………………………
Date : …………………………………………
FACULTY OF CIVIL AND
ENVIRONMENTAL ENGINEERING
DEPARTMENT OF STRUCTURE AND
MATERIAL ENGINEERING
MATERIAL LABORATORY
LABORATORY WORKSHEET
Subject Code
Course Code
Faculty : Civil and Environmental Page 1/4
Engineering
Department : Structure and Materials Edition 1
Engineering Checking No
Title : Effective Date 17/6/04
REBOUND HAMMER TEST Amendment
Date
1.0 OBJECTIVE
2.1 Able to carry out surface hardness testing by rebound hammer according to BS
1881: Part 202: 1986
3.1 Equipment
(i) Rebound hammer type N
3.2 Material
(i) Close textured concrete
4.0 PROCEDURE
1. The hammer is pressed against concrete. Plunger retracts against spring and the
hammer is ready to be used.
2. Press the hammer to the test location until the mass hammer impact against the
surface through the plunger.
4. Press the button at the side of hammer and read the amount of rebound of the mass, R
from the indicator.
5. Refer to the calibration curve on the standard steel anvil to read the compressive
strength.
6. Estimate the compressive strength with refer to the table given in Appendix I.
Faculty : Civil and Environmental Page 3/4
Engineering
Department : Structure and Materials Edition 1
Engineering Checking No
Title : Effective Date
REBOUND HAMMER TEST Amendment
Date
(5) CALCULATION SHEET
Appendix I: