Professional Documents
Culture Documents
I833w Otopu
I833w Otopu
(waterوانعدام الماءبالجذر منطقة ةبللتر ينيةبال ت غاـ الفرا لء م ي ف ببتس ةبالتر ق تغد ظاهرة ان )logging
للمياه الكفؤة غير
ةبللتر المضافة.
من مياه حركة ك هنا وتكون مستمر ل شكبالمياه خربتت ةبالتر سـطـحـ من ةبقري ضية
ا.
3-incrases the depth of root zone thereby increasing the available soil
moisture and plant food
42
Dr. amer H. Taher Chapter four Irrigation& drainage
9-improves sanitary and health conditions for the residents of the area.
. ةبالتر بناء:- ابيبح توزريع هونظام ينموذج ف عضهابمع ةبالتر ت
. ةبالتر بنية:- ةبالتر ناءـبعىب يد... المسامية تحديد ي ف هام ل عـامـ وهو
ل داخ الى والهواء الماء ل تخلخ عملية ل تسهي ي يعن التحسن وهذا الثقيلة الـزـرـاعـيـةـ المكائن استخدام تجنب مع
.ةبالتر
3-the depth of the water table below the land surface should be
ascertained
4-the fluctuations of the water table during the year should be also
studied
.تح الماء من للتخلص تستخدم بوبيةنا ل مباز عن عبارة ي وه التغدق ظاهرة حدوث عنم لغرض التربة سطح ت
43
Dr. amer H. Taher Chapter four Irrigation& drainage
ا.
ل لتقلي ل ازبالم هذه من س ا. ةبالتر سـطـحـ على الماء قاـءبزمن ل تقليبك وذل ةبالتر الى الماء غور
كمصب وتستخدم ...عميقة ل ازبالم هذه ولكن الضحلة المفتوحة ل ازبكالم مفتوححة ل ازبم ي وه outletكةبلش
ي سطح ل زبكم تسخدم ك كذل النتغدقة ي اض. )) closed drain system المغلقة ل ازبالم
ل ازبالم ل استعما او استخدام دونبو ةبالتر ق تغد ل لتقلي ل ازبالم هذه فتستخدم جيد ل شكبةنفاذةبالتر ت كان اذا
الفخارية المغلقة( (tile drainsمتر 800الى متر 750من تتراوـح العميقة ل ازبالم ينبالمسافة وتكون.
وتصب فـرـعـيـةـ ل ازبم ي ف الثانوية تصب ثم ثانوية ل ازبم ي ف تصب دورهابي والت مجمعة ل ازبم ي ف لتصب
الكنتورية الخطوط ض اخف وعند زلهابالراد للمساحة ي يعبالط ل زبال عبيت ل ازبالم كةبش مسارـ اختيار ان.
مسارا تقاطع. ض منخف او رباك ل زبمبل زبم ل ك يصب وان ك ربوال ت المستنقعا مع ل ازبالم ت
4-4-2Discharge capacity
المستمرة لمطار ا هذا
The drains are designed to remove excess water from the surface expected from
rains in addition to the natural drainage of the area.
44
Dr. amer H. Taher Chapter four Irrigation& drainage
45
Dr. amer H. Taher Chapter four Irrigation& drainage
Where:-
)
A= the cross sectional area(풎ퟐ
P= the wetted perimeter (m)
S=the bed fall (cm/km)
4-4-3 section of drains ل زبللم ي العرض المقطع
4-4-4provision of a cunnette
As a deep open drain is usually designed for the storm runoff, the discharge is
quite small when it is carrying only the seepage discharge
A cunnette (i.e a small sub drain in the bed of the main drain) is provided to
carry the seepage discharge when there is no storm runoff (fig.4.1)
Fig (4-1)
If the cunnette is not provided, the seepage discharge flows with a small depth
over the entire width of the open drain with a small velocity. it Leeds to silting
and the weed growth.
46
Dr. amer H. Taher Chapter four Irrigation& drainage
ل الطو3-length
متر 250من لقا ي لقالح ل للمبز ل الطو يكون لذا متر 500ي ه المجمعة ل المباز بين ةفالمـسا تكون عمومآ.
ل مانهو 4-manhol
ب يتطل الحالة هذه لثم يفو متر 300عن يزيد ل الطو ت هو ي لقـ ح ل مبز ل اطو 250
لقا أو متر 250ةفالمسا دنع ل هونمـاـ وضع .
ي الحقل ل زبالم سعة 5-flow equation
كنمان معادلة من ةقمشت المتعرجة تيكية-:
ퟎ.ퟑퟕퟓ ∗ 푺
) d=0.31∗( 풒 ∗ 푨 )(4-4
−ퟎ.ퟏퟖퟕퟓ
Where:-
)d=pipe diameter (m
)/풔풆풄
q= drainage rate (풎ퟐ
47
Dr. amer H. Taher Chapter four Irrigation& drainage
Consider two drains at spacing of B and the resulting drained water table as
shown in fig(4-2) .an impermeable layer underlies the drain at a depth d. rainfall
intensity (or rate of application of irrigation water)is uniform and is equal to ra
(m/sec).
Hooghoudt equation for either open ditch drains or sub- surface drain is
written as:-
48
Dr. amer H. Taher Chapter four Irrigation& drainage
풒 = 풓풂.
푩ퟒ 풌 푯
풅 풓 풂 푩
=B
)(푯 + ퟐ풅
Or
풒ل ازبالم ينبالمسافة قيمة حساب يمكن معلومة .B 풅فأن وـعـلـيـةـ
The design drain discharge (or the drainage coefficient which is defined as the
)amount of water that must be removed in a 14- hour period
يساو ي الحقيق ل زبالم ق عم ل معد . الماء سـطـحـ منسوب ت تح متر 2ي
النهاية ي ف متر 1.8وـ المصب ي ف 2.2ي الحقل ل زبالم ق عم يكون لذا متر 250ي الحقل ل زبالم ل طو أن ماـبو
التراكيز من وخالية جيدة تهوية ت ذا ت ابالن جذر لمنطقة ةبتر على ل الحصو هو ل زبال عملية من ف الهد ان
ت اتابالن لنمو الجذور منطقة ت تح ي
49
Dr. amer H. Taher Chapter four Irrigation& drainage
ت انالبيا جمع ر يت لذا ليةقالح ل المباز بين ت افالمسا ب حسـاـ يفرئيسيآ دورآ ب تلع الصماء ةقالطب عمق
بها الخاصة .
11-Drainage layout map الحقلية ل ازبالم كةبش تخطيط
)Le=L to (L+30m
المجمع ل زبالم على عمودية تكون الحقلية ل ازبالم :-عآبرا
ض عمق يكون متر 2ي ل ـقالح ل المبز عمق ل معد على اظفللح :-خامسآ 2.2 ل المبز ب مص
الطبيعية
50
Dr. amer H. Taher Chapter four Irrigation& drainage
Example (4-1):-determine the location of closed tile drains below ground for the
following data:-
Root zone depth =1.5m
Capacity rise in soil = 0.3m
풎/풔풆풄
Coefficient of permeability of soil = 1.5*ퟏퟎ−ퟒ
풎ퟑ
Drainage capacity =0.11 /풌풎ퟐ . ery
ynoitauqypy.
풔풆풄
51
Dr. amer H. Taher Chapter four Irrigation& drainage
ومنه المجمعة ل ازبالم الى الحقلية ل ازبالم من المياه جمعبتقوم المفتوحة ل ازبالم من كةبش عن ارةبع ي وه
-:(outfallلمشاريع الرئيسية ل ازبالم من عدد من المياه يستلم مفـتوحـ يربك ل زبم وهو المصب)drain ام الع
عديدة.
-:(mainالمصب الى وينقلها الـمـشروـع لمساحة ل زبال مياه يجمع ي الذ ل زبالم وهو ي الرئيس ل زبالم)drain
والثانوية الـفرعـيةـ ل ازبالم من عدد فيه وتصب ام الع .
-:(branchل وتنق الثانوية ل ازبالم من عدد فيها تصب يرةبك مفتوحة ل ازبم ي وه الـفرعـيةـ ل ازبالم)drains
الرئيسية ل ازبالم الى المياه.
-:(secondaryل ازبالم الى المجمعة ل ازبالم مياه ل وتنق ايضآ مفتوحة ل ازبم ي وه الثانوية ل ازبالم)drains
ي الرئيس ل زبالم أو الفرـعيـة.
-:(collectorاو الثانوية ل ازبالم الى مياه ل تنق مفتوحة ل ازبم عن ارةبع ي وه المجمعة ل ازبالم)drains
الحقلية ل ازبالم واسطةبل الحقو من تجميعها عدباـلـفـرـعـيـةـ.
الثال ل الفص ي ف اليها ق التطر تم وقد. ترقيمها او كةبالش تخطيط ث حي من)(4-3الفقرة ث
52
Dr. amer H. Taher Chapter four Irrigation& drainage
انحدار موازيآالى ي الطول ل زبالم انحدار يكون عادة و ل زبالم قـاـعـ منسوب ي يواز الماء منسوب فـأنـ لذا المقطع
Dm=푾푨
풔
Where:-
A=cross section area of drain
Ws= width of water surface
ii-kennedy equation for non-silting in drains
)= 푪 푫ퟎ.ퟔퟒ(ퟒ−ퟏퟏ
푽풎풊풏 ퟐ
53
Dr. amer H. Taher Chapter four Irrigation& drainage
D-Roughness coefficient
54
Dr. amer H. Taher Chapter four Irrigation& drainage
يكون عندما يعيةبالط ض امجمعة ل ازبالم ي ف الماء منسوب يكون العموم على 2.5
ي ف الماء ومنسوب ي الحقل ل زبالم مذب ينبمنسوب ق فر ل اق يكون ان على متر 2الحقلية ل ازبالم ق عمـ
متر 0.2عن ل ق.
هو المجمع ل زبالم ق عم يكون لذا متر 2.2ينهايته ف ي الحقل ل زبالم ق عم كان ولما-:
+m2.5الماء ق عـمـ
55
Dr. amer H. Taher Chapter four Irrigation& drainage
1-Design equation
ퟏ
V= 푹ퟐ/ퟑ푺ퟏ/
풏
ퟐ
Q=VA
2-longitudinal slope
S =20cm/km
min
Smax =250cm/km
3-roughness coefficient
N=0.03
4-bed width
B=0.8m
5-water level in collector drain=G.l-2.5
6-side slope
1.5(H):1(V)
7-discharge in collector drain
ퟏퟎퟎ 푬풂 풄풓풐풑풑풆풅풂풓풆풂
Q=10 I.g( 푬풘 −
ퟏퟎퟎ
)∗ (ퟒ − ퟏퟐ)
ퟑퟎퟖퟔퟒퟎퟎ
∗ퟖퟔퟒퟎퟎ
Where:-
/퐬퐞퐜)
Q= discharge in the collector drain(풎ퟑ
Ig= gross water requirement at farm
turout(mm/month)
Ea= field application efficiency
Ew= water course conveyance efficiency
8-Cross section of collector drain
56
Dr. amer H. Taher Chapter four Irrigation& drainage
)
Cross section area A = (B+ZD)D ( 풎ퟐ
Wetted perimeter P= B+2D√풁ퟐ + ퟏ (m)
Q1:- Calculate drainage coefficient for design of open ditch to drain an area of
/풔풆풄).
about 2000ha of land at the rate of 3(풎ퟑ
Solution:-
풅풊풔풄풉풂풓품풆풊풏
ퟐퟒ
풉풐풖풓풔
풑풆풓풊풐풅
풂풓풆풂풐풇풘풂풕풆
Drainage coefficient= 풓풔풉풆풅
ퟑퟔퟎퟔퟎ
∗ퟔퟎ∗ퟔퟎ
∗ퟐퟒ
ퟐퟎퟎퟎ∗
=ퟏퟎퟎퟎퟎ
=0.01296m , = 1.296cm
Q2:-Determine the increase in drainage coefficient , if discharge rate of open
ditch constructed for draining the watershed area of 1500 ha land is increased
/풔풆풄)
from 3.5 (풎ퟑ
Solution:-
ퟑ.ퟓ ퟔퟎ
∗ퟔퟎ ∗
Drainage coefficient at discharge Q, (3.5cm)=ퟔퟎퟐퟒ
ퟏퟓퟎퟎ
∗ퟐퟒ∗ퟏퟎퟎퟎퟎ
=0.02m
=2cm Drainage coefficient at discharge Q, (10.5cm) =ퟏퟎ ퟓ∗ퟔퟎ∗ퟔퟎ∗ퟐퟒ
.
ퟏퟓퟎퟎ∗
ퟏퟎퟎퟎퟎ
=0.06m ,= 6.0cm
Therefore, increase in drainage coefficient =6-2=4.0cm
57
Dr. amer H. Taher Chapter four Irrigation& drainage
Where:-
d=pipe diameter (m)
/풔풆풄/풎ퟐ
q=drainage rate 풎ퟑ
ퟎ.ퟎퟎퟑ −ퟖ
q=ퟐퟒퟔퟎ =3.472*ퟏퟎ
∗ퟔퟎ∗
ퟔퟎ m/sec
A=250*100 풎ퟐ
ퟎ.ퟏퟓ
S= ퟏퟎퟎ= ퟎ. ퟎퟎퟏퟓ풎/
풎
d=0.31*(3.472*ퟏퟎ−ퟖ ∗ ퟐퟓퟎ ∗ ퟏퟎퟎ) ∗ ퟎ.ퟎퟎퟏퟓ
−ퟎ.ퟏퟖퟕퟓ
d=0.0746m=74.6mm
use d=80mm
58