Professional Documents
Culture Documents
Child Restraint - Child Restraint Precautions - Child Restraint System
Child Restraint - Child Restraint Precautions - Child Restraint System
Child Restraint - Child Restraint Precautions - Child Restraint System
42
(A)INSTALLATION ON REAR SEAT 1. Fasten the center lap belt over the
CENTER (forward-facing rear seat CAUTION child restraint system following the in-
only)
! structions provided by its manufactur-
er.
When installing a rear-facing child re- Do not use a rear-facing child re-
straint system, follow the same procedure straint system in the rear seat if it in-
as when installing a forward-facing child terferes with the lock mechanism of ! CAUTION
restraint system. the front seats. This may cause se- After inserting the tab, make sure
vere injury to the child and front the tab and buckle are locked.
passenger in case of sudden brak- Do not insert coins, clips, etc. in
ing or a collision. the buckle as this may prevent you
from properly latching the tab and
buckle.
If the seat belt does not function
normally, immediately contact your
Toyota dealer.
43
2. Make sure the belt is tight by pulling its 3. If your child restraint system requires
free end while you firmly push down the the use of a top strap, latch the hook onto
child restraint system. the anchor bracket and tighten the top
strap.
44
4. To remove the child restraint system, (B) INSTALLATION ON REAR SEAT
CAUTION press the buckle-release button and un- OUTSIDE (forward-facing rear seat
! hook the top strap. only)
Push and pull the child restraint When installing a rear-facing child re-
system in different directions to be straint system, follow the same procedure
as when installing a forward-facing child
sure it is secure.
restraint system.
45
1. Fasten the lap and shoulder belt over 2. Fully extend the shoulder belt to put it
CAUTION the child restraint system following the in- in the lock mode.
! struction provided by its manufacturer.
Do not use a rear-facing child re- Keep the lap portion of the belt tight.
straint system in the rear seat if it in-
terferes with the lock mechanism of ! CAUTION
the front seats. This may cause se-
vere injury to the child and front After inserting the tab, make sure
the tab and buckle are locked.
passenger in case of sudden brak-
Do not insert coins, clips, etc. in
ing or a collision. the buckle as this may prevent you
from properly latching the tab and
buckle.
If the seat belt does not function
normally, immediately contact
your Toyota dealer.
46
3. Place the shoulder belt between the 4. if your child restraint system requires
vehicle seatback and the child restraint the use of a top strap, latch the hook onto
system and allow it to retract. To hold the the anchor bracket and tighten the top
child restraint system securely, let the strap.
shoulder belt retract as far as it will go
while firmly pushing down the child re-
straint system.
47
5. To remove the child restraint system, (C) TOP STRAP ANCHORS AND
CAUTION press the buckle-release button and al- LOCATIONS
! low the belt to retract. Unlock the top Sedan and coupe—On the filler panel
Make sure the seat belt is securely strap. behind the rear seat
locked. Also make sure the child re- a. Make an anchor hole in the filler panel
straint system is secure by pushing With plugs: Take out the plug.
and pulling it in different directions. Without plugs: Find the hole in the filler
panel by running your fingers across the
filler panel trim at the locations shown in
the illustration. Then cut out the covering
directly above the hole in the filler panel.
b. Insert a 15 mm (0.6 in.) spacer and
tighten down the anchor bracket for your
child restraint system with a bolt. Torque
the bolt to 16.5—24.7 N⋅m (1.68—2.52
kgf⋅m, 12.2—18.2 ft⋅lbf).
48
To comply with Canada Motor Vehicle
Safety Standards, vehicles sold in Cana-
da are provided with a bracket set in the
glovebox, designed for use with any of the
3 anchor locations shown in the illustra-
tion.
49
(D) INSTALLATION ON FRONT SEAT When using a forward-facing 1. Fasten the lap and shoulder belt over
child restraint system, move the the child restraint system following the in-
struction provided by its manufacturer.
! CAUTION seat as far back as possible.
Keep the lap portion of the belt tight.
Do not use a rear-facing child re-
straint system in the front seat be- ! CAUTION
cause the force of the rapid infla-
tion of the passenger airbag may After inserting the tab, make sure
cause severe injury to the child. the tab and buckle are locked.
Vehicles with a passenger airbag Do not insert coins, clips, etc. in
display a caution label on the pas- the buckle as this may prevent you
senger side instrument panel as from properly latching the tab and
shown above to remind you not to buckle.
install a rear-facing child restraint If the seat belt does not function
system on the front seat. normally, immediately contact your
Toyota dealer.
50
2. Fully extend the shoulder belt to put in 3. Place the shoulder belt between the 4. If your child restraint system requires
the lock mode. vehicle seatback and the child restraint the use of a top strap, latch the hook onto
system and allow it to retract. To hold the the tab of the rear center belt and tighten
child restraint system securely, let the the top strap.
shoulder belt retract as far as it will go
while firmly pushing down the child re-
straint system.
51
Tilt steering wheel
5. To remove the child restraint system, To change the steering wheel angle,
CAUTION press the buckle-release button and al- hold the steering wheel, pull up the
! low the belt to retract. Unhook the top lock release lever, tilt the steering
Make sure the seat belt is securely strap. wheel to the desired angle and release
locked. Also make sure the child re- the lever.
straint system is secure by pushing When the steering wheel is in a low posi-
and pulling it in different directions. tion, it will spring up as you release the
lock release lever.
! CAUTION
Do not adjust the steering wheel
while the vehicle is moving.
After adjusting the steering wheel,
try moving it up and down to make
sure it is locked in position.
52