Download as doc, pdf, or txt
Download as doc, pdf, or txt
You are on page 1of 1

FREE Hidden Electricity!

This Instructable will show you how to tap into a FREE source of electricity! All you need is a phone line! All
phone lines have a constant flow of voltage, around 40-70 volts (up to 100 volts when it rings!), but you can't
just plug stuff into it and expect it to work. You can really mess with your phone system by doing that. I
discovered how to do it the right way!

step 1:What You Need...


1. Small project enclosure
2. (1) 240ohm resistor
3. (1) 510ohm resistor
4. (1) LM317L Regulator
5. (1) KBP210 Bridge Rectifier
6. (2) Phone line cables

step 2:The Schematic...


I connected the Positive end to one line of the female
phone jack and the negative to the other. You could
wire it directly to your light but I chose to do it this way
so I could test other sources with just a phone jack
interface cable. The Red and Green go to corresponding
colors on the phone line that plugs into the wall.

step 3:Final steps...


Mount the circuit in the project box and run your wires
through two small drilled holes. Be sure to tie knots in
the wires inside the box to prevent them from pulling
out.

step 4:Interface Cable...


I made an interface cable from an old wall adapter and
phone line to connect the light to the box.

step 5:Test it Out!


After wiring the LED's in parallel, I plugged
everything in and it worked great! It even powered off
when the phone was picked up and flashed when it
rang. While this won't power your new 60" HD
Plasma TV, it will power small amperage electronics
and could come in handy if the power goes out! Enjoy
your FREE source of power.

You might also like